Jump to content
SAU Community

Recommended Posts

  • Replies 160
  • Created
  • Last Reply

Top Posters In This Topic

yes but everything else in this thread says you should do the PCV valve as well...

Simple. Few options here:

#1) PCV valve + exhaust side valve cover -> T-fitting -> catch can -> intake pipe [block intake manifold nipple for PCV]

#2) PCV valve + valve covers (separate hoses) -> catch can -> intake pipe [3 high ports required on catch can; block intake manifold nipple for PCV]

#3) Stock PCV valve setup; exhaust side valve cover -> catch can -> intake pipe

Obviously #3 is the easiest.

ive just bought a catch can and reading through this thread is soo confusing causing everyone has their own method of installation so to make everything much more simpler could the people that have one installed "properly" please post a pic of it installed in your engine bay. this would clear up alot of questions.

thanks

  • 5 months later...
ive just bought a catch can and reading through this thread is soo confusing causing everyone has their own method of installation so to make everything much more simpler could the people that have one installed "properly" please post a pic of it installed in your engine bay. this would clear up alot of questions.

thanks

Here is my installation, there is a lot of confusing info around but here is my 2 cents:

Most of the catch cans available have only 2 outlets the best and easiest way to set it up is as I have.

No need to block any hoses or frig around with PCV valves etc.

You are not really worried about the crankcase fumes being drawn into the plenum via the PCV under no boost (as in option #1 & #2 above)

You are concerned about the fumes (& oil) going into the intake and through you intercooler (reducing cooling efficiency as oil is a poor conductor of heat) under boost conditions. This can also lower the RON (octane) of the fuel mix and cause detonation... v bad!

So all you need is a 50% plumb back install as I have done (option #3 above)... very easy, simple and takes care of the main issue.biggrin.gif

P.S. I filled one side of the catch can with steel scourers caged in with steel mesh screen to help scrub the oil out of the fumes

post-52301-1246175862_thumb.jpg

Edited by Checkbuzz
  • 1 month later...

I always wondered if there was anything wrong with the way mine was set up..? (i think i posted the pic earlier.. but here it is again)

PCV is stock because blocking it gave me blowby issues and was getting smoke taking off from lights.. Returning it to stock fixed it. So wont be blocking it again.

Both rocker covers are vented to Atmo via the large catch can. And the line going to the turbo is blocked, although you cant tell, it is. Just makes it look less messy :down: If you look closely at it you can see a black ring, and thats a double ended bung i made from alloy.

MetalcastHigh.jpg

Is it absolutely necessary to keep the turbo line connected? I know it aides in sucking the fumes into the can, but air will take the easiest path regardless. And in my setup, that would be VIA the catch can?

Edited by gotRICE?

You can run two breathers into catch can. run a line through a one way valve from bottom of catch can into the exhaust with the fitting welded on at a 45 degree angle facing against the flow of the exhaust. Bypassing exhaust creates a vacuum in the line and can and sucks any oil/vapours out always leaving the can empty or near enough. One way valve stop exhaust gasses filling the catch can if for whatever reason it backfires up the line instead of bypassing it. Obviously dont use the factory plastic one.

Block off everyother line. Get rid of the pcv line and anyother line that runs into your intake. Only want breathers going into catch can. Dont want any fumes going back into the motor, whether it be manifold or intake of turbo.

Hey guys, here is how my catch can is currently setup:

gqytisb0.jpg

That is how the previous owner set it up, as you can see the PCV valve pipe is still there so you can actually feel the sucking on the catch can vent pipe( the pipe going down towards the rad from the catch can) but i'll be blocking the pcv valve this week anywho. At the moment the catch can is using heater hose but I got some better heat resistant hose to put on this week too, just a quick Q if I do all this while engine is cold it's not gonna spew oil everywhere is it? (replacing the catch can hoses and blocking off the pcv valve that is)

Also another Q is at the moment the catch can vent pipe has no filter on the end but once I block off the pcv valve will I even need one since it will no longer be going into the intake? cheers!

Be interesting to see if the idle is a bit smoother once the afm knows wtf is going on properly since atm it hunts a little bit sometimes.

Hey guys, here is how my catch can is currently setup:

gqytisb0.jpg

That is how the previous owner set it up, as you can see the PCV valve pipe is still there so you can actually feel the sucking on the catch can vent pipe( the pipe going down towards the rad from the catch can) but i'll be blocking the pcv valve this week anywho. At the moment the catch can is using heater hose but I got some better heat resistant hose to put on this week too, just a quick Q if I do all this while engine is cold it's not gonna spew oil everywhere is it? (replacing the catch can hoses and blocking off the pcv valve that is)

Also another Q is at the moment the catch can vent pipe has no filter on the end but once I block off the pcv valve will I even need one since it will no longer be going into the intake? cheers!

Be interesting to see if the idle is a bit smoother once the afm knows wtf is going on properly since atm it hunts a little bit sometimes.

Your idle will be much smoother once you block that off. Any air going in through your catch can is not read by the AFM and will result in a crap idle... You should still attach a filter as sometimes the engine can naturally create vacuum and you don't want the risk of anything getting in there regardless as it would go straight in to the cam cover (When the PCV valve is blocked off)

PS: If you want to keep the PCV valve connected then you should plumb the line of the catch can back in to the intake AFTER the AFM. Then it is the same as the factory setup but with something to catch the oil.

vent to Atmo = Block off PCV valve

Re-circ = two options...

1, Block off the PCV valve and run a single line from the catch tank to AFTER the AFM

2, Leave PCV valve and run a line ALSO from the catch tank to AFTER the AFM

The setups above that vent to atmo with the PCV valve connected will run fine when on boost because obviously the PCV valve only opens during negative pressure in the intake manifold (idle) But will have noticeable problems when at idle especially on warmer days.

Edited by GT-RZ
The setups above that vent to atmo with the PCV valve connected will run fine when on boost because obviously the PCV valve only opens during negative pressure in the intake manifold (idle) But will have noticeable problems when at idle especially on warmer days.

So in theory with my setup (Post #149) at idle when the PCV is open, the engine is getting a little bit of un AFM'd air through the catch can breather?

I do notice that very occasionally when i am parking (using alot of steering with minimal revs) i get a slight rev hunt. It happens so rarely i never think anything of it.

But that would make sense correct?

Edited by gotRICE?
So in theory with my setup (Post #149) at idle when the PCV is open, the engine is getting a little bit of un AFM'd air through the catch can breather?

I do notice that very occasionally when i am parking (using alot of steering with minimal revs) i get a slight rev hunt. It happens so rarely i never think anything of it.

But that would make sense correct?

yes. I know at least one person who had done this and got regular stalling until they blocked the pcv valve off.

yes. I know at least one person who had done this and got regular stalling until they blocked the pcv valve off.

Cool thanks.

Have never had a stall ever. And when i really think about it, it only happens at night with the lights on.

I refuse to block the PCV again because of the blowby i was getting. I guess ill live with the ever so rare hunt. And i do also have an SAFC, so ill just tune it out :P

I refuse to block the PCV again because of the blowby i was getting.

Running PCV doesn't stop the blow by, it's still happening except it's going into the engine instead of breathing out of the catch can. So you are still contaminating the combustion process with oily vapour when the engine is not under boost. Hence reducing the octane of the fuel, fouling up the plugs and the combustion chambers.

I'm very surprised that blow by is problem off boost anyway, because the PCV is closed when the engine is on boost. Which is when 99% of the blow by occurs.

I guess ill live with the ever so rare hunt. And i do also have an SAFC, so ill just tune it out :D

That won't help, the correction factors vary too much to be able to tune it out. Air con, power steering and electrical load plus ambient temperature and engine temperature are all variables that the SAFC doesn't know about.

There are only 2 ways way to cure it properly, block off the PCV or run the catch can outlet back into the inlet after the AFM and before the turbo. As long as your catch can wroks effectively (ie; separates the oil vapour) then that's not such a bad solution.

Cheers

Gary

  • 2 weeks later...
Your idle will be much smoother once you block that off. Any air going in through your catch can is not read by the AFM and will result in a crap idle... You should still attach a filter as sometimes the engine can naturally create vacuum and you don't want the risk of anything getting in there regardless as it would go straight in to the cam cover (When the PCV valve is blocked off)

Finally got around to doing it this weekend.

Attacked an M10 bolt with an angle grinder, took off the thread and the head to be left with the smooth part

Hacksawed the hose in half in the middle, bolt fits perfectly, smeared some gorilla glue on the bolt piece, put the hose back together, more gorilla glue at the join and then a hose clamp to finish her off

Holy crap the difference in idle is like night and day, amazing, wish I had done it sooner.

xyf0n3vl.jpg

Finally got around to doing it this weekend.

Attacked an M10 bolt with an angle grinder, took off the thread and the head to be left with the smooth part

Hacksawed the hose in half in the middle, bolt fits perfectly, smeared some gorilla glue on the bolt piece, put the hose back together, more gorilla glue at the join and then a hose clamp to finish her off

Holy crap the difference in idle is like night and day, amazing, wish I had done it sooner.

xyf0n3vl.jpg

You did it the best way too.... looks like it's still connected so the piggas with half a brain won't know the difference. And yea now on idle your computer can read the correct amount of air that's going inside the crunch and add the appropriate amount of fuel! perfect.

  • 1 month later...

Create an account or sign in to comment

You need to be a member in order to leave a comment

Create an account

Sign up for a new account in our community. It's easy!

Register a new account

Sign in

Already have an account? Sign in here.

Sign In Now



  • Similar Content

  • Latest Posts

    • I did end up getting it sorted, as GTSBoy said, there was a corroded connection and wire that needed to be replaced. I ended up taking out the light assembly, giving everything a good clean and re-soldered the old joints, and it came out good.
    • Wow, thanks for your help guys 🙏. I really appreciate it. Thanks @Rezz, if i fail finding any new or used, full or partial set of original Stage carpets i will come back to you for sure 😉 Explenation is right there, i just missed it 🤦‍♂️. Thanks for pointing out. @soviet_merlin in the meantime, I received a reply from nengun, and i quote: "Thanks for your message and interest in Nengun. KG4900 is for the full set of floor mats, while KG4911 is only the Driver's Floor Mat. FR, RH means Front Right Hand Side. All the Full Set options are now discontinued. However, the Driver's Floor Mat options are still available according to the latest information available to us. We do not know what the differences would be, but if you only want the one mat, we can certainly see what we can find out for you". Interesting. It seems they still have some "new old stock" that Duncan mentioned 🤔. I wonder if they can provide any photos......And i also just realized that amayama have G4900 sets. I'm tempted too. 
    • Any update on this one? did you manage to get it fixed?    i'm having the same issue with my r34 and i believe its to do with the smart entry (keyless) control module but cant be sure without forking out to get a replacement  
    • So this being my first contribution to the SAU forums, I'd like to present and show how I had to solve probably one of the most annoying fixes on any car I've owned: replacing a speedometer (or "speedo") sensor on my newly acquired Series 1 Stagea 260RS Autech Version. I'm simply documenting how I went about to fix this issue, and as I understand it is relatively rare to happen to this generation of cars, it is a gigantic PITA so I hope this helps serve as reference to anyone else who may encounter this issue. NOTE: Although I say this is meant for the 260RS, because the gearbox/drivetrain is shared with the R33 GTR with the 5-speed manual, the application should be exactly the same. Background So after driving my new-to-me Stagea for about 1500km, one night while driving home the speedometer and odometer suddenly stopped working. No clunking noise, no indication something was broken, the speedometer would just stop reading anything and the odometer stopped going up. This is a huge worry for me, because my car is relatively low mileage (only 45k km when purchased) so although I plan to own the car for a long time, a mismatched odometer reading would be hugely detrimental to resale should the day come to sell the car. Thankfully this only occurred a mile or two from home so it wasn't extremely significant. Also, the OCD part of me would be extremely irked if the numbers that showed on my dash doesn't match the actual ageing of the car. Diagnosing I had been in communication with the well renown GTR shop in the USA, U.P.garage up near University Point in Washington state. After some back and forth they said it could be one of two things: 1) The speedometer sensor that goes into the transfer case is broken 2) The actual cluster has a component that went kaput. They said this is common in older Nissan gauge clusters and that would indicate a rebuild is necessary. As I tried to figure out if it was problem #1, I resolved problem #2 by sending my cluster over to Relentless Motorsports in Dallas, TX, whom is local to me and does cluster and ECU rebuilds. He is a one man operation who meticulously replaces every chip, resistor, capacitor, and electronic component on the PCB's on a wide variety of classic and modern cars. His specialty is Lexus and Toyota, but he came highly recommended by Erik of U.P.garage since he does the rebuilds for them on GTR clusters.  For those that don't know, on R32 and R33 GTR gearboxes, the speedometer sensor is mounted in the transfer case and is purely an analog mini "generator" (opposite of an alternator essentially). Based on the speed the sensor spins it generates an AC sine wave voltage up to 5V, and sends that via two wires up to the cluster which then interprets it via the speedometer dial. The signal does NOT go to the ECU first, the wiring goes to the cluster first then the ECU after (or so I'm told).  Problems/Roadblocks I first removed the part from the car on the underside of the transfer case (drain your transfer case fluid/ATF first, guess who found out that the hard way?), and noted the transfer case fluid was EXTREMELY black, most likely never changed on my car. When attempting to turn the gears it felt extremely gritty, as if something was binding the shaft from rotating properly. I got absolutely no voltage reading out of the sensor no matter how fast I turned the shaft. After having to reflow the solder on my AFM sensors based on another SAU guide here, I attempted to disassemble the silicone seal on the back of the sensor to see what happened inside the sensor; turns out, it basically disintegrated itself. Wonderful. Not only had the electrical components destroyed themselves, the magnetic portion on what I thought was on the shaft also chipped and was broken. Solution So solution: find a spare part right? Wrong. Nissan has long discontinued the proper sensor part number 32702-21U19, and it is no longer obtainable either through Nissan NSA or Nissan Japan. I was SOL without proper speed or mileage readings unless I figured out a way to replace this sensor. After tons of Googling and searching on SAU, I found that there IS however a sensor that looks almost exactly like the R33/260RS one: a sensor meant for the R33/R34 GTT and GTS-T with the 5 speed manual. The part number was 25010-21U00, and the body, plug, and shaft all looked exactly the same. The gear was different at the end, but knowing the sensor's gear is held on with a circlip, I figured I could just order the part and swap the gears. Cue me ordering a new part from JustJap down in Kirrawee, NSW, then waiting almost 3 weeks for shipping and customs clearing. The part finally arrives and what did I find? The freaking shaft lengths don't match. $&%* I discussed with Erik how to proceed, and figuring that I basically destroyed the sensor trying to get the shaft out of the damaged sensor from my car. we deemed it too dangerous to try and attempt to swap shafts to the correct length. I had to find a local CNC machinist to help me cut and notch down the shaft. After tons of frantic calling on a Friday afternoon, I managed to get hold of someone and he said he'd be able to do it over half a week. I sent him photos and had him take measurements to match not only the correct length and notch fitment, but also a groove to machine out to hold the retentive circlip. And the end result? *chef's kiss* Perfect. Since I didn't have pliers with me when I picked up the items, I tested the old gear and circlip on. Perfect fit. After that it was simply swapping out the plug bracket to the new sensor, mount it on the transfer case, refill with ATF/Nissan Matic Fluid D, then test out function. Thankfully with the rebuilt cluster and the new sensor, both the speedometer and odometer and now working properly!   And there you have it. About 5-6 weeks of headaches wrapped up in a 15 minute photo essay. As I was told it is rare for sensors of this generation to die so dramatically, but you never know what could go wrong with a 25+ year old car. I HOPE that no one else has to go through this problem like I did, so with my take on a solution I hope it helps others who may encounter this issue in the future. For the TL;DR: 1) Sensor breaks. 2) Find a replacement GTT/GTS-T sensor. 3) Find a CNC machinist to have you cut it down to proper specs. 4) Reinstall then pray to the JDM gods.   Hope this guide/story helps anyone else encountering this problem!
    • So this being my first contribution to the SAU forums, I'd like to present and show how I had to solve probably one of the most annoying fixes on any car I've owned: replacing a speedometer (or "speedo") sensor on my newly acquired Series 1 Stagea 260RS Autech Version. I'm simply documenting how I went about to fix this issue, and as I understand it is relatively rare to happen to this generation of cars, it is a gigantic PITA so I hope this helps serve as reference to anyone else who may encounter this issue. NOTE: Although I say this is meant for the 260RS, because the gearbox/drivetrain is shared with the R33 GTR with the 5-speed manual, the application should be exactly the same. Background So after driving my new-to-me Stagea for about 1500km, one night while driving home the speedometer and odometer suddenly stopped working. No clunking noise, no indication something was broken, the speedometer would just stop reading anything and the odometer stopped going up. This is a huge worry for me, because my car is relatively low mileage (only 45k km when purchased) so although I plan to own the car for a long time, a mismatched odometer reading would be hugely detrimental to resale should the day come to sell the car. Thankfully this only occurred a mile or two from home so it wasn't extremely significant. Also, the OCD part of me would be extremely irked if the numbers that showed on my dash doesn't match the actual ageing of the car. Diagnosing I had been in communication with the well renown GTR shop in the USA, U.P.garage up near University Point in Washington state. After some back and forth they said it could be one of two things: 1) The speedometer sensor that goes into the transfer case is broken 2) The actual cluster has a component that went kaput. They said this is common in older Nissan gauge clusters and that would indicate a rebuild is necessary. As I tried to figure out if it was problem #1, I resolved problem #2 by sending my cluster over to Relentless Motorsports in Dallas, TX, whom is local to me and does cluster and ECU rebuilds. He is a one man operation who meticulously replaces every chip, resistor, capacitor, and electronic component on the PCB's on a wide variety of classic and modern cars. His specialty is Lexus and Toyota, but he came highly recommended by Erik of U.P.garage since he does the rebuilds for them on GTR clusters.  For those that don't know, on R32 and R33 GTR gearboxes, the speedometer sensor is mounted in the transfer case and is purely an analog mini "generator" (opposite of an alternator essentially). Based on the speed the sensor spins it generates an AC sine wave voltage up to 5V, and sends that via two wires up to the cluster which then interprets it via the speedometer dial. The signal does NOT go to the ECU first, the wiring goes to the cluster first then the ECU after (or so I'm told).  Problems/Roadblocks I first removed the part from the car on the underside of the transfer case (drain your transfer case fluid/ATF first, guess who found out that the hard way?), and noted the transfer case fluid was EXTREMELY black, most likely never changed on my car. When attempting to turn the gears it felt extremely gritty, as if shttps://imgur.com/6TQCG3xomething was binding the shaft from rotating properly. After having to reflow the solder on my AFM sensors based on another SAU guide here, I attempted to disassemble the silicone seal on the back of the sensor to see what happened inside the sensor; turns out, it basically disintegrated itself. Wonderful. Not only had the electrical components destroyed themselves, the magnetic portion on what I thought was on the shaft also chipped and was broken. Solution So solution: find a spare part right? Wrong. Nissan has long discontinued the proper sensor part number 32702-21U19, and it is no longer obtainable either through Nissan NSA or Nissan Japan. I was SOL without proper speed or mileage readings unless I figured out a way to replace this sensor. After tons of Googling and searching on SAU, I found that there IS however a sensor that looks almost exactly like the R33/260RS one: a sensor meant for the R33/R34 GTT and GTS-T with the 5 speed manual. The part number was 25010-21U00, and the body, plug, and shaft all looked exactly the same. The gear was different at the end, but knowing the sensor's gear is held on with a circlip, I figured I could just order the part and swap the gears. Cue me ordering a new part from JustJap down in Kirrawee, NSW, then waiting almost 3 weeks for shipping and customs clearing. The part finally arrives and what did I find? The freaking shaft lengths don't match. $&%* I discussed with Erik how to proceed, and figuring that I basically destroyed the sensor trying to get the shaft out of the damaged sensor from my car. we deemed it too dangerous to try and attempt to swap shafts to the correct length. I had to find a local CNC machinist to help me cut and notch down the shaft. After tons of frantic calling on a Friday afternoon, I managed to get hold of someone and he said he'd be able to do it over half a week. I sent him photos and had him take measurements to match not only the correct length and notch fitment, but also a groove to machine out to hold the retentive circlip. And the end result? *chef's kiss* Perfect. Since I didn't have pliers with me when I picked up the items, I tested the old gear and circlip on. Perfect fit. After that it was simply swapping out the plug bracket to the new sensor, mount it on the transfer case, refill with ATF/Nissan Matic Fluid D, then test out function. Thankfully with the rebuilt cluster and the new sensor, both the speedometer and odometer and now working properly!   And there you have it. About 5-6 weeks of headaches wrapped up in a 15 minute photo essay. As I was told it is rare for sensors of this generation to die so dramatically, but you never know what could go wrong with a 25+ year old car. I HOPE that no one else has to go through this problem like I did, so with my take on a solution I hope it helps others who may encounter this issue in the future. For the TL;DR: 1) Sensor breaks. 2) Find a replacement GTT/GTS-T sensor. 3) Find a CNC machinist to have you cut it down to proper specs. 4) Reinstall then pray to the JDM gods.   Hope this guide/story helps anyone else encountering this problem!
×
×
  • Create New...