Jump to content
SAU Community

Recommended Posts

I've noticed some great power figures popping up lately from some well set up RB25's such as b-mans etc and got to wondering what would be the power limit of a balanced, forged pistoned and shot pleened rods cryo treated etc bot end

For instance would 400rwkw be out of the question?What rpm is a prepped RB25 bot end able to rev to without shortening the life of the motor to much?

Please don't go into detail about how much it will cost etc or 3 litre would be easier to do it with as I have read the 3L thread from back to front and agree it would be easier and probably cheaper, I'm mainly interested in the RB25 limits

What would be the power limit of the stock gear box?

Link to comment
https://www.sau.com.au/forums/topic/34860-power-limits-of-rb25det-bot-end/
Share on other sites

I've noticed some great power figures popping up lately from some well set up RB25's such as b-mans etc and got to wondering what would be the power limit of a balanced, forged pistoned and shot pleened rods cryo treated etc bot end

For instance would 400rwkw be out of the question?What rpm is a prepped RB25 bot end able to rev to without shortening the life of the motor to much?

Please don't go into detail about how much it will cost etc or 3 litre would be easier to do it with as I have read the 3L thread from back to front and agree it would be easier and probably cheaper, I'm mainly interested in the RB25 limits

What would be the power limit of the stock gear box?

if its all checked and balanced properly they should handle around 350rwkw i think, the only thing that will cause problems is the rods, if you will spend a extr 1500 get new forged rods then it should handle over 400 easily.

The rpm limit is determined by the head, components like lifters, valve springs will need to be changed, std 8k should be doable with a built motor

ok so what would be the limit of stock prepped rods?

Hi Shibby, if it was only that easy. The tuning and how the engine gets to the power is just as important as the amount of power itself. A 500 bhp engine at 1.3 bar might be OK, but a 500 bhp engine at 1.6 bar is less likely to survive. A 500 bhp engine with an a/f ratio at 11.5 might be OK but a 500 bhp engine at 12.8 is far less likely to avoid detonation.

Look at it another way, a set of prepped rods is only going to handle maybe 50 bhp more than standard. By the time you replace the big end bolts, shot peen the rods, cryo them, replace the litte end bush bearings and balance them, you have almost spent as much as buying a set of forged rods.

There are quite a few RB25's running around the 500 bhp mark (300 rwkw) with totally standard internals, but how long will they last? I have always considered 450 bhp to be a reasonable limit. The pistons being the weakest, then the rod bolts and finally the rods themselves.

Hope that helps

ok so what would be the limit of stock prepped rods?

I put GTR rods in my rebuild with new rod bolts (thanks SK). Can find them cheap on the forum...300 - 400 a set and 140 for bolts and nuts as opposed to the retail price.

Denham, the GTR rods are more heavily tapered out toward the big end giving a greater load area for the forces of higher power/rpm to be withstood. They are also thicker in the web while the 25t rods have more pronounced end plates on the I beam area.

http://www.skylinesaustralia.com/forums/at...achmentid=10064

http://www.skylinesaustralia.com/forums/at...achmentid=10063

There is a guy in the US who put down 587 WHP on his internally stock RB25. He has since upgraded the headgasket and studs and is shooting for 650-700. This is of course done on race gas. And I don't think it's a setup I would expect to last for a very long time.

The rpm limit is determined by the head, components like lifters, valve springs will need to be changed, std 8k should be doable with a built motor

Rod length plays a very, very large part as well.

4500 feet-per-min is a safe limit for stock rods (6000 fpm for nice ones)

RB25 rods = 71.7mm

Piston speed = (Stroke * RPM)/152

=(71.7*9000)/152

=4245fpm

A stock RB25 bottom end is limited to a little more than 9000RPMs

If we shoot for the 6000 FPM number...

=(71.7*12750)/152

=6014fpm

A fully done up bottom end should safely withstand 12750RPMs routenly.

That is just the lower end - valvetrain and fuel mods would be necessary too.

Yes but you still have to take into account the second moment of area for flexure/torque and integrated momentum force over cross sectional area to ensure the stress limit is not exceeded or even more importantly the fatigue limit so that discounting wear they will have an infinite life.

Good topic! :(

Has anyone done any testing on strength of the RB30 rods?

From what I've seen - it's not generally the amount of power that'll kill rods, it's torque... Hence why a single cam RB30 won't be able to make as much top end power as a twin cam...

Cheers,

matt

Well my previous engine which i thought was full house (built by rigoli) had standard internals (and standard head and cams) except for arias pistons. I had it up to 340rwkw @ 1.9bar but dropped it down to 320rwkw. Lasted a month before it dropped a rod. Max rpm was 7200rpm aswell.

Ouch! 1 month? Mine's been running for coming up to 2 years now with around the 320-340rwkw mark (depending on which dyno you put it on)...

I'm only running around 16psi and it's rev limited to 7500rpm.

I was going to start upping the boost to 20-22psi, but after hearing that, I think I won't get greedy!

Cheers,

matt

Well my previous engine which i thought was full house (built by rigoli) had standard internals (and standard head and cams) except for arias pistons. I had it up to 340rwkw @ 1.9bar but dropped it down to 320rwkw. Lasted a month before it dropped a rod. Max rpm was 7200rpm aswell.

Nah mate, I've got a RB30 bottom end... The static CR would be too low with GTR rods!

I've just got shot peened, nitried rods... They are series 3 VL rods though - apparently they were slightly thicker at the big end than the series 2.... Doubt that's gonna make it much stronger though...

If I decide to hang onto the car, I might pull it down in 6-8 months time and stick in a set of aftermarket rods and bump up the rev limit to 8000...

Cheers,

matt

matt

u r running gtr rods 2 aint u?

so geoff how much rwkw power u recon u can get with your gtr rods before they start to bend?
I think it will be track safe on the ZR road tyres up to 250 rwkw, any more and it will overcome the rears and I'll lose time, depending on the tune. If I get some decent sponsorship for track rubber I'll go hunting for 300+ and a few extra rpm.

After that it will be head off and solid lifters and new springs.

I doubt the RB25 crank will allow the big rpm and power numbers GTRs enjoy on stock internals + forged slugs so the GTR rods will not the the limiting factor. If some bastard at work will give me back my laptop I'll be able to model and FEA the rods for limitations

Thats a good question. Depends if the turbine was replaced with steel. It certainly doesn't respond like a stocker, more lag until 4K then the switch goes, but I hope to tune that out. If it is a steel turbine I would guess it's not ball bearing. Also produces power differently...more power at 11psi than a stocker at 15psi so it isn't as restrictive in the exhaust.

I could replace it and be more certain, or I could drive it until it's dead or I'm surprised. Just not sure yet.

I did the hicas replacement bracket today and got the alignment, including the caster, and it is on rails now with some fresh front (30% used) rubber.

Create an account or sign in to comment

You need to be a member in order to leave a comment

Create an account

Sign up for a new account in our community. It's easy!

Register a new account

Sign in

Already have an account? Sign in here.

Sign In Now


  • Similar Content

  • Latest Posts

    • Hi, is the HKS  Tower Bar still available ? negotiable ? 🤔
    • From there, it is really just test and assemble. Plug the adapter cables from the unit into the back of the screen, then the other side to the car harness. Don't forget all the other plugs too! Run the cables behind the unit and screw it back into place (4 screws) and you should now have 3 cables to run from the top screen to the android unit. I ran them along the DS of the other AV units in the gap between their backets and the console, and used some corrugated tubing on the sharp edges of the bracket so the wires were safe. Plug the centre console and lower screen in temporarily and turn the car to ACC, the AV should fire up as normal. Hold the back button for 3 sec and Android should appear on the top screen. You need to set the input to Aux for audio (more on that later). I put the unit under the AC duct in the centre console, with the wifi antenna on top of the AC duct near the shifter, the bluetooth antenna on the AC duct under the centre console The GPS unit on top of the DS to AC duct; they all seem to work OK there are are out of the way. Neat cable routing is a pain. For the drive recorder I mounted it near the rear view mirror and run the cable in the headlining, across the a pillar and then down the inside of the a pillar seal to the DS lower dash. From there it goes across and to one USB input for the unit. The second USB input is attached to the ECUtec OBD dongle and the 3rd goes to the USB bulkhead connected I added in the centre console. This is how the centre console looks "tidied" up Note I didn't install the provided speaker, didn't use the 2.5mm IPod in line or the piggyback loom for the Ipod or change any DIP switches; they seem to only be required if you need to use the Ipod input rather than the AUX input. That's it, install done, I'll follow up with a separate post on how the unit works, but in summary it retains all factory functions and inputs (so I still use my phone to the car for calls), reverse still works like factory etc.
    • Place the new daughterboard in the case and mount it using the 3 small black rivets provided, and reconnect the 3 factory ribbon cables to the new board Then, use the 3 piggyback cables from the daughterboard into the factory board on top (there are stand offs in the case to keep them apart. and remember to reconnect the antenna and rear cover fan wires. 1 screw to hold the motherboard in place. Before closing the case, make a hole in the sticker covering a hole in the case and run the cable for the android unit into the plug there. The video forgot this step, so did I, so will you probably. Then redo the 4 screws on back, 2 each top and bottom, 3 each side and put the 2 brackets back on.....all ready to go and not that tricky really.      
    • Onto the android unit. You need to remove the top screen because there is a daughterboard to put inside the case. Each side vent pops out from clips; start at the bottom and carefully remove upwards (use a trim remover tool to avoid breaking anything). Then the lower screen and controls come out, 4 screws, a couple of clips (including 3 flimsy ones at the top) and 3 plugs on the rear. Then the upper screen, 4 screws and a bunch of plugs and she is out. From there, remove the mounting brackets (2 screws each), 4 screws on the rear, 2 screws top and bottom and 3 screws holding in the small plates on each side. When you remove the back cover (tight fit), watch out for the power cable for the fan, I removed it so I could put the back aside. The mainboard is held in by 1 screw in the middle, 1 aerial at the top and 3 ribbon cables. If you've ever done any laptop stuff the ribbon cables are OK to work with, just pop up the retainer and they slide out. If you are not familiar just grab a 12 year old from an iphone factory, they will know how it works The case should now look like this:
    • Switching the console was tricky. First there were 6 screws to remove, and also the little adapter loom and its screws had to come out. Also don't forget to remove the 2 screws holding the central locking receiver. Then there are 4 clips on either side....these were very tight in this case and needed careful persuading with a long flat screw driver....some force required but not enough to break them...this was probably the fiddliest part of the whole job. In my case I needed both the wiring loom and the central locking receiver module to swap across to the new one. That was it for the console, so "assembly is the reverse of disassembly"
×
×
  • Create New...