Jump to content
SAU Community

Recommended Posts

Morning Gents,

I've got two different idle issues but only one occurs at any given time.

1st: A very small hunt, like 50rpm hunt, it just bounces back and forth a little, only just registers on the tacho but you can hear it in the exhaust.

2nd: If it's not doing that at idle then when gearing down to a complete stop when I put the clutch in and engage first the idle will jump to say 1100rpm then after maybe 1-2 seconds, return to normal. It will do this any time I am coming to a stop and it happens when I engage the clutch.

Background, I've searched about these issues and have removed and cleaned the AAC and AFM. The AAC did have a fair bit of build-up on it and I did my best to clean it, it was literally swimming in carby cleaner :happy: For a period the idle hunt (which at the time was a bigger hunt) went away. The idle increase on clutching has not gone away. The AFM was cleaned with Electrical contact cleaner and the mesh was wiped over carefully, no change.

For reference, car only has a POD with a mr_crust airbox, cat back, low boost bypass on the solenoid and a boost guage as far as mods that could interfer with air flow characteristics, these problems were evident before these mods and have seemingly not been affected by them for the better or worse.

Thoughts? Otherwise I might take the AAC valve off again and totally dismantle it so I can really clean it properly but I'd like to hear other peoples thoughts on the matter.

Cheers

Link to comment
https://www.sau.com.au/forums/topic/137371-idle-issues/
Share on other sites

The sensor is no more than 1yr old as I replaced it when I got the car (it was shagged) and my rego is due next week :P The car does smell a bit rich on start and despite checking the seals I still see fuel vapour from the filler cap so I assume the smell is coming from there. The car returns around 12.5-13L per 100 around town so that's acceptable as I understand it.

Link to comment
https://www.sau.com.au/forums/topic/137371-idle-issues/#findComment-2556551
Share on other sites

It's been intermittent since I've had the car and I've tried the things above that I mentioned and haven't really gotten far besides when I cleaned the AAC valve which seemed to stop the hunt issue. The hunt comes and goes but the idle jump on engaging the clutch and putting it into gear when approaching an interesection is pretty consistent.

Link to comment
https://www.sau.com.au/forums/topic/137371-idle-issues/#findComment-2562905
Share on other sites

Only time I have really seen what you describe is when you put an Auto ECU into a manual car.

The Auto ecu looks at the neutral position sensor on the gearbox and goes ok, you just put it in gear, lets idle up for the load the auto puts on the engine when in gear.

But if you have a manual just because you change out of neutral doesn't mean there is any load on the engine because the clutch is still dipped.

The manual ecu doesn't have this extra idle up because it isn't needed.

If the ecu is the correct item for the vehicle then maybe the clutch is not releasing properly and putting slight drag on the engine when the gear is engaged, does the clutch release fully when dipped?

Link to comment
https://www.sau.com.au/forums/topic/137371-idle-issues/#findComment-2562933
Share on other sites

I've had the ECU out before and it 'seemed' normal but I couldn't honestly say if it was right or not, the problem is intermittent thoguh so if it was ECU I doubt it would be behaving this way. As for the clutch booster, how di I tell.

Link to comment
https://www.sau.com.au/forums/topic/137371-idle-issues/#findComment-2562940
Share on other sites

I had a similar prob with idle being abit wierd and getting stuck and going up to 1,100rpm by itself. Ended up being TPS cleaned the contacts and all good :D Not to sure if it would help but atleast its something else to look into.Another person I know had a pod filter changed it back to stock ecu reset and good. RB25's r mysterious sometimes good luck mate!!!!

Link to comment
https://www.sau.com.au/forums/topic/137371-idle-issues/#findComment-2563255
Share on other sites

Did you see these threads from last week.

Slightly different problem to yourself, but you might as well check the air regulator if you are still hunting for the problem.

http://www.skylinesaustralia.com/forums/in...=135917&hl=

http://www.skylinesaustralia.com/forums/in...=136269&hl=

Link to comment
https://www.sau.com.au/forums/topic/137371-idle-issues/#findComment-2563348
Share on other sites

Create an account or sign in to comment

You need to be a member in order to leave a comment

Create an account

Sign up for a new account in our community. It's easy!

Register a new account

Sign in

Already have an account? Sign in here.

Sign In Now


  • Similar Content

  • Latest Posts

    • Seat of the pants assessment of the new intake: The car is way less "doughy" when hitting the loud pedal, especially off idle when stopped or in traffic, I did use a cheapo lazer thermal thingo to measure the temp around where the pod filter got its air, it was between 55 - 60°C, in saying this the car was shut off and not moving, so the OEM intake pipe was not supplying any fresh air to where the pod was when the car was at least moving A weird bonus was induction noise on the throttle in the cabin increased a bit,  I was worried that I was actually going to lose some of that induction noise I love so much, outside though, when I got the daughter to do a WOT drive by pass for me, the induction noise has increased alot when on the throttle, not quite ITB doort, but well up there I'm extremely happy with the results and have been exploring the country roads in the region  As for house mods: 1.New front fence is up and is awesome, it really upgraded how the joint looks from the street, and the added security is nice 2. Electricians have replace some interior lights, and with more lighting in the garage, a few new motion detecting lights out the front above the garage, front room, and at the front door, which I have already found heaps helpful coming and going, also now has fancy pants CCTV all round the house The only hold point for power though is the solar and batteries due to supply issues, although this will happen over the next few weeks 3. I have done a heap of landscaping out the front and I'm almost ready to do a new small retaining wall with some nice blocks to replace the brick and cemented in rocks around the raised garden beds cemented in river stone "was the fashion at the time" the house was built. I currently have a pallet of retaining wall blocks and 2 bulka bags of 20mm blue metal to replace the wood chip that is in the raised garden beds around the house 4. I now have 3 big raised garden beds for out the back to grow some vegetables, about 70cm high, 200cm long and 100cm wide 5. My 2 compost bins are already pretty full with brown, green and kitchen waste from the landscaping I'vedone so far, but they will probably take a few months to break down, so anything else that gets chopped, trimmed, and kitchen waste will just start filling the base of the raised garden beds to about 30cm before I start throwing 40cm of good compost, and stuff, for the vegetables to grow in, I'll need a few ton of compost and soil, but the local supplier can sent me bulka bags of the stuff Basically the logs, wood chips and a few strategically placed rocks for drainage, will give the beds some good organic materials down low to break down over time, and they will hold moisture during the warmer months to save the water in my big arse water tank if we don't get alot of rain So, all in all, the car and house mods are going well, and I'm really enjoying being retired, I sleep in too 0700 and slowly plod around inside until I feel like actually doing anything, and only work in the yard for as long as want, which has actually been alot over the last few weeks,  although when you look at it, it seems that not a huge amount of work has been done,  until I look at the before I started the work pics Happy days and good times indeed 
    • hahaha yeah. Plan is to get side skirts and probably just rear pods. But going to do them one-by-one. I've got a set that I really like from RHDJapen, but that one isn't shipped to AU. So need to find someone who can get it for me
    • Here's an idea, answer the questions I asked you as they are trying to work out WHY the LSD will be binding up in a straight line.
    • You haven't driven many modern cars then have you? Most of them have sfa steering feel with their stupid electric bullshit steering systems.
×
×
  • Create New...