Jump to content
SAU Community

Recommended Posts

Hi, I have had some sveatty days working out with the rb25 gearbox. First time the two plates were not aligned so I couldn't even get the gearbox in and had to take it out again. This time the box went all the way in but now I can't get any gears in when the engine is on. I tried bleeding the fluids and adjusted the pedal as much as it goes. Then I lifted the rear up and started with a gear on, then the wheels spinned even with the pedal down. When I pushed the break and cluthc the rews went down a bit but the engine didn't stop. Could it be that I put one plate the wrong way? That could show some slipping, like what I have? Now the plates are not the same way. The plate closer the engine has the "outcoming" part in the middle facing the engine, and the plate closer the gearbox is the other way. Does anybody remember how they should be. Or is there maybe something else you could easily mess up in the installation since this was my first time :) . All I have is japanese instructions wich didn't help so much. Thanks.

Link to comment
https://www.sau.com.au/forums/topic/233019-orc-709/
Share on other sites

Did you use the right bearing carrier? Have to decipher the instructions to figure out which one is right for you.

Sorry my english for the parts names isn't so good, but bearing carrier? I think it's the new part we changed with the bearing that I ordered with the clutch set from rhd japan. It is the part you attach to the bearing between the clutch and gearbox? It has the same effect you're right. I can send the japanese instructions if someone understands them. Yeah, by the way it is a dampered clutch if it has any difference. What is the right bearing carrier, have to check it out when I remove the gearbox... again.

Link to comment
https://www.sau.com.au/forums/topic/233019-orc-709/#findComment-4087305
Share on other sites

By the sounds of it, I would have to agree with BNR#@.

It sounds like your bearing carrier is too short for your application, so that even at full throw the clutch isn't being disengaged.

Even though the manual is in japanese it isn't really hard to work out which one you need for your car.. numbers and pics make it easier to follow.

By the way, Thanks to Serg for helping out gavin at cypher with my clutch. Thanks heaps mate. I think they were under the impression that I didn't have the manual. Hopefully it is the nastiest clutch install that they have to deal with for a long time as it needed a pile of other bits replaced and a real bastard to fit it all back in.

Clutch bites like a bitch, but seems to be getting a bit nicer after a couple of days use. Zacka tuned it on thursday night and it made 350.6 rwhp @ ~17psi. All via hand controller too. Very happy.. for now.

Link to comment
https://www.sau.com.au/forums/topic/233019-orc-709/#findComment-4087847
Share on other sites

post-43975-1219666533_thumb.jpgOkay, according to the picture the distance between the lines in the bearing carrier should be 14-16mm, agreed? I'll take the box out tomorrow and measure it. I just thought that the pieces would be right because they came in the same package, well you learn from your mistakes.... :D
Link to comment
https://www.sau.com.au/forums/topic/233019-orc-709/#findComment-4090939
Share on other sites

By the sounds of it, I would have to agree with BNR#@.

It sounds like your bearing carrier is too short for your application, so that even at full throw the clutch isn't being disengaged.

Even though the manual is in japanese it isn't really hard to work out which one you need for your car.. numbers and pics make it easier to follow.

By the way, Thanks to Serg for helping out gavin at cypher with my clutch. Thanks heaps mate. I think they were under the impression that I didn't have the manual. Hopefully it is the nastiest clutch install that they have to deal with for a long time as it needed a pile of other bits replaced and a real bastard to fit it all back in.

Clutch bites like a bitch, but seems to be getting a bit nicer after a couple of days use. Zacka tuned it on thursday night and it made 350.6 rwhp @ ~17psi. All via hand controller too. Very happy.. for now.

Haha, I was actualy there helping them lift the gearbox when they were trying to get it in with your front pipes still attached, not fun, bloody heavy bugger to... No matter how the box was angled it wasnt going in... The clutch does bite but you realy get use to it fairly fast, yours rattle to?

Link to comment
https://www.sau.com.au/forums/topic/233019-orc-709/#findComment-4093061
Share on other sites

Rattle? hmm.. put it this way, my wife reckons that my car came back broken. :D

Bit of a zing when starting, and bit of a clunk when coming in to a stop with the clutch in like a uni-joint type of noise. Pedal effort is almost half of what the original one was, a heavy duty single I am led to believe.

Gavin found out how much fun it was to try and refit the front pipe to those dump pipes as well, it took me about 3 hours to do it myself on the shed floor the first time..

Link to comment
https://www.sau.com.au/forums/topic/233019-orc-709/#findComment-4093166
Share on other sites

Rattle? hmm.. put it this way, my wife reckons that my car came back broken. :D

Bit of a zing when starting, and bit of a clunk when coming in to a stop with the clutch in like a uni-joint type of noise. Pedal effort is almost half of what the original one was, a heavy duty single I am led to believe.

Gavin found out how much fun it was to try and refit the front pipe to those dump pipes as well, it took me about 3 hours to do it myself on the shed floor the first time..

Haha, get use to explaining to everyone that it rattles because its so hardcore :)

Mine has a nismo slave cylinder so is light as a feather, would have actualy prefered it a bit heavy er but use to it now...

Was there when he was taking your fronts off, was gone by the time he was puting them back on, figured wasnt gona hang arround for the second round of lifting that box :(

Link to comment
https://www.sau.com.au/forums/topic/233019-orc-709/#findComment-4093315
Share on other sites

My friend had a similar problem, he found out that the tube which carries the bearing carrier pressed the clutch plate all the time. And that didn't allow it to release, he had to cut about 1cm of the tube away to get it to work. Have to check today if there is any signs of contact. The bearing carrier had the lenght that was adviced in the instructions, but still there is about 1,5cm loose in the fork movement before it started to push the clutch (before it got stiff). Is that okay?

Link to comment
https://www.sau.com.au/forums/topic/233019-orc-709/#findComment-4096781
Share on other sites

Create an account or sign in to comment

You need to be a member in order to leave a comment

Create an account

Sign up for a new account in our community. It's easy!

Register a new account

Sign in

Already have an account? Sign in here.

Sign In Now


  • Latest Posts

    • You are selling this? I have never bought something from marketplace...i dont know if i trust that enough. And the price is little bit "too" good...
    • https://www.facebook.com/share/19kSVAc4tc/?mibextid=wwXIfr
    • It would be well worth deciding where you want to go and what you care about. Reliability of everything in a 34 drops MASSIVELY above the 300kw mark. Keeping everything going great at beyond that value will cost ten times the $. Clutches become shit, gearboxes (and engines/bottom ends) become consumable, traction becomes crap. The good news is looking legalish/actually being legal is slighly under the 300kw mark. I would make the assumption you want to ditch the stock plenum too and want to go a front facing unit of some description due to the cross flow. Do the bends on a return flow hurt? Not really. A couple of bends do make a difference but not nearly as much in a forced induction situation. Add 1psi of boost to overcome it. Nobody has ever gone and done a track session monitoring IAT then done a different session on a different intercooler and monitored IAT to see the difference here. All of the benefits here are likely in the "My engine is a forged consumable that I drive once a year because it needs a rebuild every year which takes 9 months of the year to complete" territory. It would be well worth deciding where you want to go and what you care about with this car.
    • By "reverse flow", do you mean "return flow"? Being the IC having a return pipe back behind the bumper reo, or similar? If so... I am currently making ~250 rwkW on a Neo at ~17-18 psi. With a return flow. There's nothing to indicate that it is costing me a lot of power at this level, and I would be surprised if I could not push it harder. True, I have not measured pressure drop across it or IAT changes, but the car does not seem upset about it in any way. I won't be bothering to look into it unless it starts giving trouble or doesn't respond to boost increases when I next put it on the dyno. FWIW, it was tuned with the boost controller off, so achieving ~15-16 psi on the wastegate spring alone, and it is noticeably quicker with the boost controller on and yielding a couple of extra pounds. Hence why I think it is doing OK. So, no, I would not arbitrarily say that return flows are restrictive. Yes, they are certainly restrictive if you're aiming for higher power levels. But I also think that the happy place for a street car is <300 rwkW anyway, so I'm not going to be aiming for power levels that would require me to change the inlet pipework. My car looks very stock, even though everything is different. The turbo and inlet pipes all look stock and run in the stock locations, The airbox looks stock (apart from the inlet being opened up). The turbo looks stock, because it's in the stock location, is the stock housings and can't really be seen anyway. It makes enough power to be good to drive, but won't raise eyebrows if I ever f**k up enough for the cops to lift the bonnet.
    • There is a guy who said he can weld me piping without having to cut chassis, maybe I do that ? Or do I just go reverse flow but isn’t reverse flow very limited once again? 
×
×
  • Create New...