Jump to content
SAU Community

Recommended Posts

Smokey, Misfire (valve stem seals maybe)

I have a rebuilt rb30 bottom end with new rings and bearings. New standard head gasket and an rb25det head.

I have got a misfire from idle and it struggles as you accelerate gently (wideband reads lean as expected due to misfire).

My crankcase breather is just venting to air at the moment with very little smoke at idle, but if I kink this pipe I get excessive smoke from the exhaust on deceleration. It still smokes a bit a idle from the exhaust.

The smoke is more white than anything, but has a slight smell of oil.

I have done the usual search and come to the conclusion its the valve stem seals.

Am I right?

Can bad valve stem seals cause a misfire?

P.s. I have wasted spark running perfectly, fuel pressure and injectors are ok, afm is ok.

Link to comment
https://www.sau.com.au/forums/topic/299729-smoke-on-overrun/
Share on other sites

connect your crankcase breather asap to see if it stops it THEN see if you still have a problem THEN we can start ruling things out. common sense would tell you to connect anything thats supposed to be connected to see if its causing the problem, and i dont mean blocking it off... connect it as standard.

its happened before - dysfunctional PCV has caused an oil problem on other cars including my own. start from there.

Edited by SECURITY

SECURITY saved my life with the same situation!

Stock RB25, catch can setup with blocked PCV, would smoke just after start up when i took off from lights, and came to a stop.

Reconnected PCV, never seen another whiff :D

Defiantly never blocking the PCV again.

Im running msd coils in wasted spark mode. Cas has been replaced. Plugs at 0.8.

Misfire happens from startup most of the way up the rev range have not taken the revs over 4000rpm as mototr has only been built and not mapped yet.

Create an account or sign in to comment

You need to be a member in order to leave a comment

Create an account

Sign up for a new account in our community. It's easy!

Register a new account

Sign in

Already have an account? Sign in here.

Sign In Now


  • Similar Content

  • Latest Posts

    • Wife wanted basket things in the wardrobe in our temporary house. Thought about ripping our the wardrobe and fitting the entire IKEA set, but it's a temporary house and we want to move in a few years. So IKEA advertises this as a 50cm unit, however the actually basket and rails measure 46cm wide. Only issue was depth, IKEA stuff is quite deep, where as the builder special junk is super shallow at less than 40cm. Send it, chopped the rails, then offset the mounting holes, job done, happy wife, less shit scattered all over the bedroom. Did the same to the other side too. Also drove the Skyline shit box today, dropped off oil at Supercheap Auto. I didn't realise they only now take max 2x bottles per visit. I visited 2x Supercheap Autos.  
    • I've seen similar actually in my situation. You never know what tables are attempted to be used when the car thinks it's -99C or +200C. The fail state is not usually that extreme but you know what I mean - it was in my case though! This is where being able to read all the sensors is useful cause you see this stuff really quickly.
    • The above is very important. However as long as you keep timing relatively low, it's plausible to make your own knock ears and plausible to learn to tune with a modern ECU that can do wideband O2 correction like a boost controller. I mean if you only have one viable road to even drive the car on, learning to tinker to this level may be worth doing given you can't do much else with the car...?
    • I find the fact that the rear plate has to be bent inwards at the rear not so bad: but the front is just awful: It's like come on. (these are my very old, now retired/turned in plates) TBH it is a lot of money to fix a minor issue, the fact I said "I'll never really spend the money on doing this" is why people ended up buying them as a gift for a 'car guy' who can be hard to shop for.. for car guy things.
    • I just bent the ends of my premo plates. It even went through Regency like that after the engine conversion and the inspector (a great bloke!) just squinted his eyes and said "I didn't see that". Plates, and how they look, are just something that have zero importance to me.
×
×
  • Create New...