Jump to content
SAU Community

Recommended Posts

  • Replies 103
  • Created
  • Last Reply

Top Posters In This Topic

Well, all went as planned on the weekend, and it is all fitted

No pics as yet, as my plan was to fit it, then wait until Wednesday and remove it to inspect to see wether it was working succesfully.

So far it seems to be doing a great job, inspecting the differance between the cam cover hose and the hose going into the inlet pipe shows that the hose going into the inlet pipe contains no visible signs of any oil or oil vapour

The hose coming off the rocker cover has minimal amounts of oil in it, so I think its filtering the oil vapour very succesfully

Will take it out tomorrow, take a few pics and post them up, along with a template to make up a internal divider if any other Greddy catch can owners want to do the same

Chris

Hi guys,

I am yet to see a commercially produced oil/air seperator as functionally or financially viable as the one outlined below. Very easy for the keen DIYer provided you can operate a drill & know someone who can weld. I think I'll post my design in the DIY section. Enjoy, & spend your hard earned dosh elsewhere :)

Please excuse my lame-ass sketching.

I use Cusco.

And a 1 litre catchcan is damn overkill...

Unless you're SkylineGeoff... ha ha...

T.

Ha ha T. The trick is not to have broken ring lands on multiple pistons for 2500km :)

There is a company in melbourne does ally containers split at halfway would be ideal for BigDatto's design, and cheap too. I'll hunt around and find the brochure and post later.

My catch can was an early prototype by a mate in ACT and has swirl inserts in the top similar to a dry sump oil/air separator or centrifugal air filter on a truck. It spins the gas as it enters and allows it to settle before it comes up to the vent to atmoshere. After driving Tanks for 2 years that use more than 2L per km I could care less for the tiny amount of contaminated GH gas mine emits.

Just a baffle is not going to do much in getting the gas to drop oil but combinations of accelerators and scrubbers will.

Researched a similar problem for helicopter dust filters on Mil aircraft for my thesis but decided I didn't want to have sh)t to do with the aviation industry.

  • 2 weeks later...

Well, all worked succesfully

I removed it last night for inspection and to take a few photgraphs of it so you can all see how it works

I have attached some pics as well of how it fits etc.

After a bit over a week of driving, I can report that it seems to be doing its job very well.

The internal stocking/scourer combo does catch the small amounts of blow-by very well, with the air coming out if the can clean of pretty well all the oily vapour. Its hard to see in the photo's but the stocking on the 'in' side of the can had small amounts of vapour on it, and the stocking on the 'out' side has none that I can see. The pics are as it came out of the car, and weren't cleaned or anything

I'd say buy the look of things, replacing the stocking/scourer combo would be a once in every six months to a year job. I guess this will depend on how much your engine breathes, but you can use the level indicator on the side to tell how much oil is in there

I have made up a template for the divider, I will try and scan it today and post it up. Here are some pics of what it looks like

Regards, Chris

The old scourer in the stocking trick, works well every time. :wavey:

yeah, it works a treat!

Best thing I reckon is it gets rid of the majority of oil vapour, and doesn't have that catch can smell. and it totally legal

Chris

i have a custom one which came with my car but i have never hooked it up, it just doesn't seem to have enough outlets/inlets.

its been made to shape to your strut tower and has two inlets at the top and one (drain) at the bottom.

i am guessing i will have to finish it off by cutting a hole in the top and fitting a cap/filter to vent to atmo. and of course stuff it with steel wool.

as for the pcv what does this do? is it just a one way valve for the breather pipe?

PCV = positive crankcase ventilation

The PCV valve operates via the vacum load on your car. When your car is off boost or in negative vacum, the PCV valve is sucked open, drawing the gases from the motor into the inlet.

When under boost, it gets foreced shut by the positive pressure, and the gas is sucked into your inlet system, usually just before the turbo. Its then pumped into your intercooler, through your inlet and then into your motor. This leads to filthy intercoolers and can casue detonation

By cleaning these gases (via catch can arrangment) before they get sucked into the inlet system, it gets rid of most of the crap that you don't want in your inlet air, which can only be a good thing

Chris

PCV = positive crankcase ventilation

The PCV valve operates via the vacum load on your car. When your car is off boost or in negative vacum, the PCV valve is sucked open, drawing the gases from the motor into the inlet.

 When under boost, it gets foreced shut by the positive pressure, and the gas is sucked into your inlet system, usually just before the turbo. Its then pumped into your intercooler, through your inlet and then into your motor. This leads to filthy intercoolers and can casue detonation

 By cleaning these gases (via catch can arrangment) before they get sucked into the inlet system, it gets rid of most of the crap that you don't want in your inlet air, which can only be a good thing

Chris

and if you vent your catch can to atmo can you block this off or do away with it altogether? (i seem to get sh*tloads of oil in my intercooler piping).

and if you vent your catch can to atmo can you block this off or do away with it altogether? (i seem to get sh*tloads of oil in my intercooler piping).

yeah, it can then be blocked off, what type of motor do you have?

atmo venting catch cans are illegal, and smell alot, for a race car I'd say they are fine, but for a road car I'd suggest a re-circulating setup

Mine smelt alot, mainly due to where it was positioned, the smell would end up in the cabin

I'd look at making a sealed system, then if your are not happy with that, vent it to amtmsophere

its a normal stocking - just not stretched heaps so it looks quite thick once it has something inside

I kept the stainless wool pretty much in one piece, just pulled it apart a little and shaped it to suit, seemed to fit well

Create an account or sign in to comment

You need to be a member in order to leave a comment

Create an account

Sign up for a new account in our community. It's easy!

Register a new account

Sign in

Already have an account? Sign in here.

Sign In Now



  • Similar Content

  • Latest Posts

    • I wasn’t able to replicate the sound anymore. It was a one time sound so maybe it was just coincidence but it was like small pebbles being dropped in a coke can.   should I try cleaning the MAF? It could be it’s functioning but dirty? I don’t know.
    • Update 4: Hi all. The car drives again! Haven't driven for long, only to store it in the garage again, but the test drive was successful. The coolant and oil leaks seem to be fixed for now. Temps on the engine were also very good, while moving I never even saw 80C water during the approx. 30 minute drive. Ate up all the coolant in the reservoir though so will have to fill that even more when I go to the car next time. One thing that pisses me off is that the RPM gauge is still f**ked, I even resoldered the board twice and used copper paste on the silly screws that are used as connections. Next time I take it out I'll take apart the board and fit new components, I'll see if I can get a replacement IC for it.  I have an appointment set for 22nd of September for the engine tune to 370hp. Alignment also still needs to be done. My hope is that I can get all the legal stuff over with by the end of this season. Anyone of you have advice regarding intercoolers? Currently there is an APEXI core fitted, one of those weird hybrid ones, 600x270x76. I don't think it's bad but it's not new and now I still have the chance to change it now to legally include it in the paperwork. Only issue is that the only options that would arrive in time are a HKS Type R intercooler or generic Ebay spec intercoolers comparable to a JustJap one. Ideally I'd order a Plazmaman but it takes over a month to receive which would mean making the car legal has to wait until next season. Would love to hear some input on this. Same story for my injectors, the previous owner was a nunce and put ID 1050x on the engine. They work but are obviously not ideal at "normal" power levels. But I don't see a reason to change them unless the tuner says it's necessary. I read online before buying a different exhaust that the top secret style rear diffusers won't fit due to the size of the rear resonators. My buddy and I made it work by slightly "adjusting the shape" of the mounting bracket and making some spacers out of 3d print for the mounting bolts. Fits like a charm. Just putting this here in case someone has this problem. Even the hefty HKS Silent Hi Power rear can fits without hitting anything.
    • Well they got my money but they are not getting my gearbox ! 
    • It's needed for rolling idle up, and I think it is a decider on VCT also.
    • I mean, not really. Link ECU's can absolutely still have errors from the ECU thinking it's getting a sensor it's not expecting. I would imagine the speed at the ECU level in Nistune does absolutely nothing anyway? I assume the ECU does not do any fancy TC stuff with regards to front+rear wheel speed or anything of that like anyway. Someone who uses Nistune may be more fluent in it. 
×
×
  • Create New...