Jump to content
SAU Community

Recommended Posts

Went over to my cousins house the othe night for a few drinks and we ended up looking in my engin bay. He noticed that the boost controller was plumbed back on itself. Was my car overboosting, and if so wouldnt the turbo have shit itself from 18 months of overboosting

Cheers Jon

ps can someone tell me how to put photos in I have taken 2 to show what is going on :D

Link to comment
https://www.sau.com.au/forums/topic/46155-was-it-overboosting/
Share on other sites

It sounds like the waste gate is still connected to the plenum line, so in effect the solenoid carn't bleed off any eccess leving u with less boost if anything.

? for u getting a car from WA & want to register it in NSW are your compliance rules the same, do u have a australian compliance plate?

The way it was set up was ok. The boost solenoid (that was bypassed) allows the boost to jump from 5-7 psi above approx 4800 rpm. If it is set up the way it was u will not have the 2 stage boost. In otherwords u will get 7 psi from as low as 3000rpm. Its up to u how u set it up, I would go back to how it was.

The way its set up in the before picture is no good as u thought as it will over boost but from memery the size of that tubing will only give u approximatly 14psi thats why it wasn't hitting the boost cut. the after picture is ok but will only give u 7 or 8psi like Damo said. If u ask me ur better off bleeding a bit off to give u 10psi. Won't give u the bottom end punch of 14 but will increase life of engine and turbo and give u almost the same top end if its a pre 95 model.

P.S. my quickest time of 13.8 was done on 10 psi :flamed:

the series 1 and 2 have boost cut at 12psi and more.

Without that little nissan boost controller colenoid connected you would only be running 5 psi.

The nissan one bleeds of a little, and runs the car at 7 psi after around the 4500rpm mark.

Create an account or sign in to comment

You need to be a member in order to leave a comment

Create an account

Sign up for a new account in our community. It's easy!

Register a new account

Sign in

Already have an account? Sign in here.

Sign In Now


  • Similar Content

  • Latest Posts

    • Wife wanted basket things in the wardrobe in our temporary house. Thought about ripping our the wardrobe and fitting the entire IKEA set, but it's a temporary house and we want to move in a few years. So IKEA advertises this as a 50cm unit, however the actually basket and rails measure 46cm wide. Only issue was depth, IKEA stuff is quite deep, where as the builder special junk is super shallow at less than 40cm. Send it, chopped the rails, then offset the mounting holes, job done, happy wife, less shit scattered all over the bedroom. Did the same to the other side too. Also drove the Skyline shit box today, dropped off oil at Supercheap Auto. I didn't realise they only now take max 2x bottles per visit. I visited 2x Supercheap Autos.  
    • I've seen similar actually in my situation. You never know what tables are attempted to be used when the car thinks it's -99C or +200C. The fail state is not usually that extreme but you know what I mean - it was in my case though! This is where being able to read all the sensors is useful cause you see this stuff really quickly.
    • The above is very important. However as long as you keep timing relatively low, it's plausible to make your own knock ears and plausible to learn to tune with a modern ECU that can do wideband O2 correction like a boost controller. I mean if you only have one viable road to even drive the car on, learning to tinker to this level may be worth doing given you can't do much else with the car...?
    • I find the fact that the rear plate has to be bent inwards at the rear not so bad: but the front is just awful: It's like come on. (these are my very old, now retired/turned in plates) TBH it is a lot of money to fix a minor issue, the fact I said "I'll never really spend the money on doing this" is why people ended up buying them as a gift for a 'car guy' who can be hard to shop for.. for car guy things.
    • I just bent the ends of my premo plates. It even went through Regency like that after the engine conversion and the inspector (a great bloke!) just squinted his eyes and said "I didn't see that". Plates, and how they look, are just something that have zero importance to me.
×
×
  • Create New...