Jump to content
SAU Community

Recommended Posts

Um, just dont use any flame source near fuel vapour. Its more flammable than fuel itself. That goes for using torches etc as well when looking into the tank....try using a digital with night vision...lol :D

edit: These views are only represented on behalf of the writer. He takes no responsibility in actions caused by others, and any injuries / deaths caused by plain stupidity :D

get a dolphin torch they are pretty well sealed i used it and a flourecent light.The flouro was a light made for working on cars with seals at both ends of the light.

To get at the tank once youve accessed the pannel you need to take the hoses off these can be absolute bastards to get off but they come off eventually.Then you need a bar and a hammer to unscrew the big black thread that holds the pick-up and seal in place once thats done the pump is very easy to get out.To tightem the big black thread back up you need to hand tighten it and then bash it back on with the hammer and bar again.When you put it all back together and turn the car on to see if it works leave the cover plate off to make sure that there are no leaks coming from any of the hoses you have put back on

Just in case you needed help from someone whos done it before.

well mission unsuccessful :D

its a braver man than me that buggers around in there,

got the black lid off with difficaulty, lifted the white lid off but simply could not see in there, shined a torch in with hesitation (but all was good) but there were too many wires and stuff in there couldnt get the white one off all the way, just lifted it up which made evereything too awkward. so its a job for a proffesional for me :D

PLUS i think that might not even be my problem, my prob is the needle has dropped ff past empty but then comes back up intermitantly, might juts be electrics

i'm slightly worried, i didnt pull anything hard or anyhting... can the fuel pump be buggered with at all from the exercise i just prformed?

i know the sound of my car, (you just get to know exactly what everything sounds like) and the fuel pump priming sounds just a little different, like its lower by one octave if you know what i mean.

upon first startup the check engine light flashed on for like a millisecond too but i'm chalking that down the the battery being out for a few hours becasue it took just slightly longer to turn over.

Hi ,allways thought that the fuel sender was the line coming from the pump to the distribution block that then sent fuel to the injector rail.

Its easy as pie and once you get access to the underneath of the fuel distribution block you should easily be able to get the sender line thats in tank if its the one im thinking of.

But the pump itself is attatched to a bracket.If you put your arm inside the tank directly in front of you is the bracket that holds the pump bracket.Admitably it is hard to see inside,so just run your hand down the pickup line to the pump lift it out easy.

When putting the bracket and pump back in remember the two forks on the bracket slide it back into its stock location,and it does so with ease no force nessessary.

You should make sure you push it against the back wall of the tank where it came from,and that the fuel pump pickup is facing in the direction from whence it came.

Keep us updated.

I want to know what you mean and if i am right about where the fuel sender in the fuel tank is.:):):P:)

Haha! we did that little exercise at the racetrack today. The fuel pump wasn't in right and I was getting fuel cut in the corners. About an hour of fiddling and swearing and finally Belgarian got it in for us. The fuel sender is the large white plastic thingy that sits to the driverside of the pump.

Create an account or sign in to comment

You need to be a member in order to leave a comment

Create an account

Sign up for a new account in our community. It's easy!

Register a new account

Sign in

Already have an account? Sign in here.

Sign In Now


  • Similar Content

  • Latest Posts

    • Must have been an absolute nightmare to drive when the power steer was out, the rack ratio/wheel size/caster is all set up for power assistance
    • Welcome to SAU, what are you looking at buying?
    • I checked the injectors again (1 and 2, since they’re easiest to access) to make sure they weren’t clogged. Even though the entire fuel system had been cleaned, I wanted to be certain. Everything looked clean, so I reinstalled and connected everything. When I started the car to confirm everything was okay, it immediately revved up high, so I shut it off straight away. I checked to see if I’d missed a vacuum hose or something, but everything was connected. On the second attempt, the car ran without the high idle, but I noticed a distinct “compressed air” sound coming from the engine bay. Tracing the sound, I pushed injector #6 forward slightly and the noise stopped — it turned out it wasn’t seated properly, despite the fuel rail being bolted down. While holding it in place, the car idled steadily without stalling and ran for over 5 minutes. At this point, I pulled all six injectors out just in case I hadn’t seated them correctly or dirt had gotten onto the O-rings. Unfortunately, I discovered that I had damaged 3 out of 6 injectors (the OEM 270cc ones) during installation. So yes, this was my fault. Since only the pintle caps were damaged, I’ve ordered a Fuel Injector Service Kit from NZEFI to refurbish them. In the meantime, I reinstalled my new injectors – the car now idles fine for over 15 minutes without stalling. I have not attempted to drive it so far. It’s not perfect yet, as it hesitates when the throttle is pressed, but it’s a big improvement. Unplugging the IACV with the new injectors idles at around 800rpm, even with the IACV screw tightened fully. But this is probably due to tune.
    • I wanted to try and preserve the front bumper as long as possible, they're not cheap and are made to order in Japan. Taking inspiration from my previous K11 Micra build where I made an undertray for the Impul bumper, I did the same for this BN Sports bumper but a little slimmed down.  This time round I only made a 'skid plate' (if that's the correct wording/term) for just the bumper surface area, the Micra version covered the gap like an undertray. Starting off with a sheet of mild steel approx. 0.9mm thick 4ft x 2ft in size. I traced around the bumper, cut it out and cleaned the edges. Luckily I was able to get two halves from one piece of metal In the video I installed it as is, but I've since then I've removed it to spray and add a rubber edging trim. The rubber trim is suitable for 1-2mm and it's a really nice tight fit. The bolts had to be loosened due to the plates being too tight against the bumper, the trim wouldn't push on I used some stainless M6 flat headed bolts for a flusher finish (rather than hex heads poking down), I believe this style fastener is used for furniture too incase you struggle to source some. The corner's are a little wider, but this may be an advantage incase I get close to bumping it  The front grill got some attention, finally getting round to repairing it. Upon removal one fixing pulled itself out of the plastic frame, one side is M8 that fixes inside of the frame, where as the other side is M5. Not knowing I could get replacements, I cut down an M8 bolt, threaded it inside the frame along with a decent amount of JB Weld.  The mesh was replaced to match the bumper. One hole on the bonnet/hood had to be drilled out to 8mm to accommodate the new stud, once the glue had set it could be refitted. I think the reason the grill was double meshed was to hide the horn/bonnet latch (which makes sense) but I much prefer it matching the bumper Bumper refitted and it's looking much better IMO The Youtube video can be seen here: https://www.youtube.com/watch?v=bVZP35io9MA
    • The video for the servicing and fuel filter change can be seen here: https://www.youtube.com/watch?v=uLJ65pmQt44 One of the main jobs I wanted to do before the car officially went on the road, was to remove the awful looking blue silicone hoses. There's nothing wrong with having coloured silicone hoses, but I realise as I'm getting older I prefer monotone engine bays with a splash of colour on the engine cover(s). I cover this in a lot more detail in the Youtube video, so unfortunately there's limited photos of the process. The intercooler, upper radiator, boost vacuum and upper breather hoses were all changed to black silicone with mikalor clamps. The only blue left is a blanking cap at the back of the inlet manifold and the GReddy pulleys (which will be replaced for stock when the cambelt gets replaced) While the intercooler pipes were off I gave them a quick clean/polish too A before photo I do have a replacement air filter on its way. Fuse box covers were painted blue, they're now satin black Another job on the list while the bumper was off, is to add some mesh https://live.staticflickr.com/65535/54737966256_99b28bfa30_c.jpg[/img] I was hoping to use some thin wire to secure it, but it seems I've misplaced it and the wire I had was too thick to twist easily. I ended up using cable ties for the time being https://live.staticflickr.com/65535/54737131882_c2b7989dcc_c.jpg[/img] Was pleasant to see this https://live.staticflickr.com/65535/54737131627_8b2aab13b3_c.jpg[/img] The last thing to do was to fix the front grill and re-mesh that to match but I ran out of time The Youtube video can be seen here: https://www.youtube.com/watch?v=R4FsF6tgizE&t=23s
×
×
  • Create New...