Jump to content
SAU Community

Recommended Posts

Ok, finally have an aftermarket ecu in the car and went to the track for some testing instead of just fun.

It came about in a race when the bleed valve hose came off and the boost pressure never changed. Then in the pits we set the rev limit to 5k and wound the advance up from there to spool the turbo to flat out, again we never passed 7psi.

The car is stock essentially, as far as I know turbo is standard and only has cat back from a previous owner. I am presuming it should go significantly higher than 7psi and now I am pretty much ready to do some winding up as the new ecu can control all of this as a preset or from a dash dial.

Should I be looking for a wastegate problem/adjustment/fault or is there something else?

Any suggestions welcome

Thanks in advance

D

well if you were running and the bleed valve line came off then you would have lost manifold pressure and the actuator would have never opened which would have resulted in some catastrophic event??? anyway the ecu won't control boost nor does it have the ability to. the stock boost is about 7psi, controlled by the turbo's actuator. if you change the actuator spring to a higher pressure one, it will open later. or you can change the rod length also. or you can get an electronic boost controller and trick the actuator into seeing less pressure than is actually at the manifold so it opens the actuator much later, thus running more boost.

so in summary you need a boost controller.

- actuator change

- actuator rod change

- electronic boost controller

- bleed valve

first check all intercooler hoses,never no one could be split. wire the wastegate shut,drive with caution it should boost up. if not drop the dump pipe and check that the wastegate is seating and isnt broken. if all fails might be time to pull the turbo off for inspection

my old laurel (with r33 gtst rb25det installed) would not boost above 7 psi at first too, but i found the factory bov was leaking, blocked it off and hey presto, more boost!! may be worth trying, blocking it off??

Thanks for the suggestions people, definately gives me something to go one with.

Paulr33 - I have a bleedvalue on the wategate actuactor but this is the hose that came off - making me thing it must be jammed in its current position or it should have boosted off the scale. The ecu I am running is capable of controlling the boost with the factory components fitted but even trying this we peaked at 7psi. So it must be a prob that under any (including fault condition) its limited to 7psi. Might be just as well given the bleed valuve hose came off and going off scale is not a place I want to be.

Grim32 - I will look into this and see if there are any probs in that area. Kinda was what I was thinking but never had to deal with it before. Also hoping to get rid of the factory turbo soon anyway - the new ecu wants more :P

Blur - I will try that as well - easily enough done to see if it's a quick fix.

Will let you know what I find. Can't wait to finally have a bit more than 7psi.

Create an account or sign in to comment

You need to be a member in order to leave a comment

Create an account

Sign up for a new account in our community. It's easy!

Register a new account

Sign in

Already have an account? Sign in here.

Sign In Now


  • Similar Content

  • Latest Posts

    • And finally, the front lower mount. It was doubly weird. Firstly, the lower mount is held in with a bracket that has 3 bolts (it also acts as the steering lock stop), and then a nut on the shock lower mount itself. So, remove the 3x 14mm head bolts , then the 17mm nut that holds the shock in. From there, you can't actually remove the shock from the lower mount bolt (took me a while to work that out....) Sadly I don't have a pic of the other side, but the swaybar mounts to the same bolt that holds the shock in. You need to push that swaybar mount/bolt back so the shock can be pulled out past the lower control arm.  In this pic you can see the bolt partly pushed back, but it had to go further than that to release the shock. Once the shock is out, putting the new one in is "reverse of disassembly". Put the top of the shock through at least one hole and put a nut on loosely to hold it in place. Put the lower end in place and push the swaybar mount / shock bolt back in place, then loosely attach the other 2 top nuts. Bolt the bracket back in place with the 14mm head bolts and finally put the nut onto the lower bolt. Done....you have new suspension on your v37!
    • And now to the front.  No pics of the 3 nuts holding the front struts on, they are easy to spot. Undo 2 and leave the closest one on loosely. Underneath we have to deal with the wiring again, but this time its worse because the plug is behind the guard liner. You'll have to decide how much of the guard liner to remove, I undid the lower liner's top, inside and lower clips, but didn't pull it full off the guard. Same issue undoing the plug as at the rear, you need to firmly push the release clip from below while equally firmly gripping the plug body and pulling it out of  the socket. I used my fancy electrical disconnect pliers to get in there There is also one clip for the wiring, unlike at the rear I could not get behind it so just had to lever it up and out.....not in great condition to re-use in future.
    • Onto the rear lower shock mount. It's worth starting with a decent degrease to remove 10+ years of road grime, and perhaps also spray a penetrating oil on the shock lower nut. Don't forget to include the shock wiring and plug in the clean.... Deal with the wiring first; you need to release 2 clips where the wiring goes into the bracket (use long nose pliers behind the bracket to compress the clip so you can reuse it), and the rubber mount slides out, then release the plug.  I found it very hard to unplug, from underneath you can compress the tab with a screwdriver or similar, and gently but firmly pull the plug out of the socket (regular pliers may help but don't put too much pressure on the plastic. The lower mount is straightforward, 17mm nut and you can pull the shock out. As I wasn't putting a standard shock back in, I gave the car side wiring socket a generous gob of dialectric grease to keep crap out in the future. Putting the new shock in is straightforward, feed it into at least 1 of the bolt holes at the top and reach around to put a nut on it to hold it up. Then put on the other 2 top nuts loosely and put the shock onto the lower mounting bolt (you may need to lift the hub a little if the new shock is shorter). Tighten the lower nut and 3 upper nuts and you are done. In my case the BC Racing shocks came assembled for the fronts, but the rears needed to re-use the factory strut tops. For that you need spring compressors to take the pressure off the top nut (they are compressed enough when the spring can move between the top and bottom spring seats. Then a 17mm ring spanner to undo the nut while using an 8mm open spanner to stop the shaft turning (or, if you are really lucky you might get it off with a rattle gun).
    • You will now be able to lift the parcel shelf trim enough to get to the shock cover bolts; if you need to full remove the parcel shelf trim for some reason you also remove the escutcheons around the rear seat release and you will have to unplug the high stop light wiring from the boot. Next up is removal of the bracket; 6 nuts and a bolt Good news, you've finally got to the strut top! Remove the dust cover and the 3 shock mount nuts (perhaps leave 1 on lightly for now....) Same on the other side, but easier now you've done it all before
    • OK, so a bunch of trim needs to come off to get to the rear shock top mounts. Once the seat is out of the way, the plastic trim needs to come off. Remove 2 clips at the top then slide the trim towards the centre of the car to clear the lower clip Next you need to be able to lift the parcel shelf, which means you need to remove the mid dark trim around the door, and then the upper light trim above the parcel shelf. The mid trim has a clip in the middle to remove first, then lift the lowest trim off the top of the mid trim (unclips). At the top there is a hidden clip on the inner side to release first by pulling inwards, then the main clip releases by pulling the top towards the front of the car. The door seal comes off with the trim, just put them aside. The the lighter upper trim, this is easy to break to top clips so take it carefully. There is a hidden clip towards the bottom and another in the middle to release first by pulling inwards. Once they are out, there are 3 clips along the rear windscreen side of the panel that are hard to get under. This is what the rear of the panel looks like to assist:
×
×
  • Create New...