Jump to content
SAU Community

Recommended Posts

have searched...

basically i have some ringland issues so a full rebuild is in order.

i have allready got forged pistons, and forged h beam rods,

and have sent the motor off to get bored, and crank balanced etc.

now my general question more refered to what else shoud i do while its apart.

my car is a r33 s1 4 door auto.

consists of

full 3 inch exhaust turbo back

high flow cat

600x300x80 fmic

gt3076r-sp

stainless exhaust manifold

nismo 550cc injectors

q45 afm

power fc

walbro pump

sard fuel reg

MV Automatic shift kit

Any suggestions?

cams?

Link to comment
https://www.sau.com.au/forums/topic/110518-rb25det-rebuild/#findComment-2036706
Share on other sites

Hi mate..

I've just finished rebuilding my RB25DET engine. I've now done 7,000kms and haven't had any major problems (touch wood!)

While the engine is apart, I would change your water pump (about $40-$50), def change the thermostat (under $50)... you could do the oil pump if you wanted to, I didn't though...

You gonna change your clutch while it's all apart? I think it was called the 'thrust bearing'.... replace that... aparently the 'piolt bush' should be replaced as well...

Are you going to build the engine yourself?

If you've got any questions... just ask me.. I'd be more then happy to help.. I've been there and done that so fire away with any questions you have and I'll do my best to guide you in the right direction.

Link to comment
https://www.sau.com.au/forums/topic/110518-rb25det-rebuild/#findComment-2037155
Share on other sites

I don't know that turbo so I don't know how far you are expecting it to take you but I would suggest you ditch that fuel pump and put something decent in there.

Tomei Poncams (type B) are good.

I wouldn't port the head but a polish of the combustion chamber would be worthwhile.

I would have expected things like water pumps and oil pumps would be replaced as a matter of course.

Put a crank collar on for the oil pump drive if going over say 250rwkw.

Have you thought about what compression ratio you are going to run?

Link to comment
https://www.sau.com.au/forums/topic/110518-rb25det-rebuild/#findComment-2037819
Share on other sites

How much did it cost you?

Did you do it yourself or workshop - which one?

Standard new parts or heavy duty after market stuff?

What power you got now?

Hi mate..

I've just finished rebuilding my RB25DET engine. I've now done 7,000kms and haven't had any major problems (touch wood!)

While the engine is apart, I would change your water pump (about $40-$50), def change the thermostat (under $50)... you could do the oil pump if you wanted to, I didn't though...

You gonna change your clutch while it's all apart? I think it was called the 'thrust bearing'.... replace that... aparently the 'piolt bush' should be replaced as well...

Are you going to build the engine yourself?

If you've got any questions... just ask me.. I'd be more then happy to help.. I've been there and done that so fire away with any questions you have and I'll do my best to guide you in the right direction.

Link to comment
https://www.sau.com.au/forums/topic/110518-rb25det-rebuild/#findComment-2037884
Share on other sites

RB26 cylinder head= 2 oil feed galleries between the block and the head

We block one off, same as RB26's are standard

We use a 1.5 mm restrictor in the other

Plenty of oil flow to the camshaft bearings, not too much oil slopping around in the head, getting chucked into the catch can and leaving the sump in short supply.

RB25 with VVT= 2 oil feed galleries between the block and the head

Plus 1 feed to the VVT actuator

We block one off, same as RB26's are standard

We use a 1.5 mm restrictor in the other

Plus leave the VVT oil feed as per standard

Plenty of oil flow to the camshaft bearings and VVT actuator but not too much oil slopping around in the head, getting chucked into the catch can and leaving the sump in short supply.

RB25 without VVT= 2 oil feed galleries between the block and the head

Plus 1 feed to the VVT actuator

We block one off, same as RB26's are standard

We use a 2.0 mm restrictor in the other

Plus block off the VVT oil feed

Plenty of oil flow to the camshaft bearings, no VVT actuator. Not too much oil slopping around in the head, getting chucked into the catch can and leaving the sump in short supply.

Link to comment
https://www.sau.com.au/forums/topic/110518-rb25det-rebuild/#findComment-2038115
Share on other sites

the head has had a full three angle valve grind, and all stem seals replaced.

i was more thinking down the track changing to a rb26 head..

due to big cams and lifters..

will they bolt straight on?

my original question i was wondering if any one else has done the full rebuild,

how much grunt?

did you lift the standard 7000 rpm limiter to 7500 or 8000 with new rods and pistons?

any other experiences?

Link to comment
https://www.sau.com.au/forums/topic/110518-rb25det-rebuild/#findComment-2040782
Share on other sites

well i got 582.7hp out of my rb25 and thats without nos

depending what funds you have.

head

tomi cams 270 deg with 10.5mm lift

ferrera double valve springs

ferera 2mm oversize valves

solid buckets

cutom lifters

wesco conrods

race bearings drilled

heat treated stnd crank je rings

cp pistons

extra oil galleries

n1 oil pump

n1 waterpump

bored out 20thou

everything port and polished

flow tested..

:)

Link to comment
https://www.sau.com.au/forums/topic/110518-rb25det-rebuild/#findComment-2041160
Share on other sites

How much did it cost you?

Did you do it yourself or workshop - which one?

Standard new parts or heavy duty after market stuff?

What power you got now?

Hi mate... in answer to your question.. I built the engine myself but got the machining done by pro's..

All up I spent about $7,000 and I did put heavy duty parts in because I'm aiming to get 300 at the wheels.

After I had run the engine in.. I had it dynoed and running about 9PSI with stock intercooler, I got 176kw at wheels... not bad I thought..

I've now brought a Hybrid front mount and will soon buy an aftermarket ECU, then I will probably run 15 - 20 PSI through it and see how much power I get then...

I did post up a thread here a few months back on my entire rebuild.. I can't remember what I called it but search and you might have soome luck...

Link to comment
https://www.sau.com.au/forums/topic/110518-rb25det-rebuild/#findComment-2043750
Share on other sites

take note about replacing valve springs, even smaller cams 256 with 8.5mm lift require more seat pressure.

standard springs start to fall over when you make around 275-280kw at tyres. a decent turbo pushing 20psi will overpowrer them. seems like you have downstairs sorted, but all the power is made upstairs.

well i got 582.7hp out of my rb25 and thats without nos

depending what funds you have.

head

tomi cams 270 deg with 10.5mm lift

ferrera double valve springs

ferera 2mm oversize valves

solid buckets

cutom lifters

wesco conrods

race bearings drilled

heat treated stnd crank je rings

cp pistons

extra oil galleries

n1 oil pump

n1 waterpump

bored out 20thou

everything port and polished

flow tested..

>_<

Link to comment
https://www.sau.com.au/forums/topic/110518-rb25det-rebuild/#findComment-2046642
Share on other sites

just on the quiet, if your looking to push that much boost through it I suggest you sell your Hybrid & buy a quality, more efficient core for it.

Hi mate... in answer to your question.. I built the engine myself but got the machining done by pro's..

All up I spent about $7,000 and I did put heavy duty parts in because I'm aiming to get 300 at the wheels.

After I had run the engine in.. I had it dynoed and running about 9PSI with stock intercooler, I got 176kw at wheels... not bad I thought..

I've now brought a Hybrid front mount and will soon buy an aftermarket ECU, then I will probably run 15 - 20 PSI through it and see how much power I get then...

I did post up a thread here a few months back on my entire rebuild.. I can't remember what I called it but search and you might have soome luck...

Link to comment
https://www.sau.com.au/forums/topic/110518-rb25det-rebuild/#findComment-2046645
Share on other sites

tomi cams 270 deg with 10.5mm lift

ferrera double valve springs

ferera 2mm oversize valves

solid buckets

cutom lifters

would love to get some details on how much and where you got the above parts from..

looking into this kind of setup on a rb25/30 but the tomei rplacement valve springs and solid lifters are unavailable.

cheers

Link to comment
https://www.sau.com.au/forums/topic/110518-rb25det-rebuild/#findComment-2046667
Share on other sites

Create an account or sign in to comment

You need to be a member in order to leave a comment

Create an account

Sign up for a new account in our community. It's easy!

Register a new account

Sign in

Already have an account? Sign in here.

Sign In Now


  • Similar Content

  • Latest Posts

    • You just need to remove the compressor housing, not the entire turbo. I would not be drilling and tapping anything with the housing still on anyways. 
    • So, I put my boat on a boat. First of all, I'm going to come out and say it. Why is Tasmania not considered a holy goal, an apex that all road-legal modified cars go to, to experience? This place is an absolute wonderland of titanic proportions. If people are already getting club runs for once in a lifetime 30 person cruises to Tassy then I've never seemed to see it. It is like someone replaced the entire place with an idyllic wonderland for cars, and all of the people living there with paid actors who are kind, humble, and friendly. Dear god. After doing a lap of almost all of the place I've found that it's a great way to find out all of the little things that the car isn't doing quite right and a great way to figure it all out. All in all, I drove for 4 hours a day for a week and nothing broke. I didn't even need to open the engine bay. This is by all means a great success, but it has left me with a list of things to potentially address. I also now have a 3D printed wheel fitment tool which annoyingly hasn't got any threads in it to actually assemble it. I might be able to tape it together to check the sizing I actually want to use, but it'll likely involving pulling the shocks out to properly measure travel at least at the front, and probably raise the car while I'm at it, at least in the rear. I scraped on quite a few things and I'm not sure how else to go about it. I was taking anything with a bump at what felt like 89 degree angles. And address those 10 other tasks. And wash the car. God damn it is dirty. And somehow, the weather was perfect the entire time - And because I was on the top of Mt Wellington it turns out it was very much about to freeze up there. I did something I typically never do and took some photos up there in what must have been -10 and the foggy felt like suspended ice, rather than mere fog. If you own a car in Australia, you owe it to yourself to do it.
    • Damn that was hilarious, and a bit embarrassing for skylines in general 😂 vintage car life ey. That R33 really stomped. Pretty entertaining stuff
    • Hi, I have a r32 gtr transmission. Does any of you guys have an idea how much power it will hold with the billet center plate and stock gearset? At what power level and use did yours brake with or without billet plate? Thanks, Oystein Lovik
    • Saw this replica police car based on a Mitsubishi Starion XX parked next to a 'police box' (it's literally a box) in Hirohata, Himeji City in Hyogo prefecture the other day. It's owned by Morii-san who is a local Mitsubishi Starion enthusiast. According to a local radio station blog post, he always wanted to make a police car himself based on ones he saw in his favourite Manga comics.  As it's illegal to modify a car to look like a police car and drive on the road, Morii-san tried many times to get permission from Aboshi police station headquarters nearby. They refused initially by after they got tired of that they granted him permission. However, the car can only be displayed on private property and obviously can't be registered as long as the police livery is present. The car was completed at a cost of 1.5 million yen (US$ 10,000) in addition to the car cost. A location was chosen outside Hirohata Police box where the car can easily been seen from the street. Morii-san has two other Starion road cars, both widebody GSR-VRs.
×
×
  • Create New...