Jump to content
SAU Community

Recommended Posts

Hey guys,

I'm having a few electrical problems with my car which at this stage are more of an annoyance than a problem, I just don't want it to get any worse. There are two possibilities in my mind that could be causing it, a dodgy earth or a dodgy battery. I have recently done an engine swap on my car, and the problem was there before and it is still there now. I've had the battery tested multiple times and it shows up fine every time.

What's happening is often when I turn the car to accessories to prime the fuel pump (still standard GTT fuel pump, Walbro 550 going in next week), the dash lights will be very very dim and flicker a bit, my volt gauge (aftermarket) will show anywhere from 7v to 10v, etc. When I try to start the car it eventually starts ok every time, but it struggles a bit. Sometimes everything is fine and it will start pretty much instantly, the dash lights will be bright as all hell, the volt gauge will read ~11.5-12.5, etc.

Another thing that often happens is when I change gears or clutch in, the sound system will die. I haven't got a huge system either. It will come back on straight away, but it pretty much just resets. Often when this happens one of my headlights will go out as well, comes back on if I flick them off and back on again.

I had suspected alternator before the engine swap, but seeing as I have changed the alternator with the new engine and the problem is still there I sort of ruled that out.

What could this be? Also sorry if this is in the wrong section, it struck me as a general maintenance type problem...

Cheers guys,

Martin.

Link to comment
https://www.sau.com.au/forums/topic/333107-possible-earthing-problem/
Share on other sites

First things first. I'd start with getting a multimeter, and testing the voltage at the battery while driving in these conditions. Just run some cables from your battery, out the side of the bonnet and into your cabin, put the meter on them, and drive in the above conditions. If there is a drop at the battery, undo your clamps and test the battery voltage by itself, should be over 12 volts = very healthy.

If the voltage at the battery is fine, you have at least eliminated that from the problem. Also test the voltage at the battery before starting, and while started and check the difference in voltage. If the battery voltage if good without the clamps, put has a large drop when using certain accessories, you could have a dead short that's not fused for some reason. This will cause a voltage drop, and risking a fire.

Does your fuel pump run the stock wiring? Most people bypass them and run a fresh cable to the boot from the battery and put a relay in. I recently wired my pump to the 2 gauge cable I have in there for the amps. No voltage drop for me when priming, or at the fuel pump in any conditions.

Edited by GTRPowa

Secondly, depending on how many accessories you are running, it may be good advice to upgrade the earth between the - battery terminal and the chassis/body. Make it a 4 gauge cable with the appropriate lugs at either end. If in doubt even go 2 gauge, but I'd steer clear of 8 gauge.

I've tried using Datascan to monitor the voltage, thing is it doesn't happen very often while driving, it's very unpredictable. The main problem is on start up.

The fuel pump is still stock so I imagine it would still be stock wiring.

Well the things is, whatever you use to monitor the voltage, it's monitoring it at the point you do the test, or have the gauge connected.

Eg, if you had a stock wired fuel pump, I could find 3 differing voltages on the car. The battery, where the dash voltage gauge is, and where the pump is. I can bet all 3 test spots will yield differing voltages.

I don't know what Datascan is? Consult? Possibly it's measuring the voltage at the computer?

What this means though is even if there are voltage sags everywhere, but the battery isn't reflecting the voltage sag, you can eliminate the battery and start looking at wiring.

On top of this, once that earth cable between your - battery terminal and the chassis is overloaded, the returning current needs somewhere else to go. It routes through the engine earth, into the alternator. By overloaded it can be anything from too many accessories, to small of a cable, the quality of the earth connection has diminished. You can pretty much test this without too much work, just get a metre of 8 guage, strip it down, put one end on the - battery terminal, and the other end where the old earth strap meets the chassis. This will reinforce the connection and provide a route for the extra current to head through.

Speaking of engine earths, how are they? I'd also run a meter of 8 gauge from the - terminal to the engine as well. All in all it depends on the earth straps you have on the car. It's one of the overlooked things with engine swaps.

DO NOT PUT IT FROM YOUR + TERMINAL TO THE CHASSIS OR SPARKS AND FIRE GOES EVERYWHERE!

I take 0 responsibility.

Edited by GTRPowa

Lol I know, I understand electrics pretty well.

My earth cable is not very quality at all, it is slightly greened which looks like it will be causing resistance. I'm missing 1v between my alternator and my battery, the alternator reads around 14.3v when the engine is one, but the charge going into the battery is only about 13.2v. But this is on the positive terminal, the negative seems ok.

This is why I suspect it is a dodgy earth, the earth cable does not look too healthy at all. How good an idea would it be to get some 8 gauge wires and connect them to multiple chassis points? Or should I use 4 gauge wire?

Edited by Hanaldo

Well you have choices, if it's at all possible, I'd simply run a 4 gauge to the normal spot, clean the metal well, use proper lugs, and continue the earth strap with at least 8 gauge to the engine.

Hey I was thinking, you should be able to measure the voltage between the +12 terminal and the chassis somewhere in the car. So you were getting voltage sag because of your earth strap, in theory you should see that on the meter since you're testing the voltage through the strap?

I think with those earth kits you can buy, they normally have what, one earth to the - terminal, one to the chassis, and multiple points of the engine, ie: block, head, intake plenum etc, so one run to the chassis should be sufficient.

You could also test continuity on the strap, but my guess is it will be close to 0 ohms.

I hope my help is helping to find a direction, nobody else posting...

Edited by GTRPowa

if you know your missing 1 volt try putting a multimeter between battery + and alternator + and this will tell you how much is lost in positive side of wiring and the rest of the 1volt is lost through negative cables. Agree with Glen about bumping up size of cables. Skyline battery cables were good when the cars were new but they are getting on. i have 4 gauge from negative to chassis and 4 gauge from positive to starter and 8 gauge starter to alternator. makes a noticable difference

Yeh that's what I did mate, the 1v is missing in the positive lines.

I've connected a number of 8 gauge wires to different points on the chassis, it does seem to be making a difference. Before the voltage was sitting at about 12.3 with the car off, now it sits at about 12.8. Also charges at 14.2 consistently now instead of being around 13.6-14.4

Will see if it fixes the problems

Ok so the extra earth lines didn't work, problem is still there. I am now suspecting it is my alarm/immobilizer that is causing the issues, as from memory these problems started when I had it installed. Would there be anyway of finding out for sure, before taking it back to identimark (I think they are a bit dodgy)

you said above the 1v was missing in the positive lines but in the latest post you upgraded the earths and it didnt fix it.... did you fit various earth straps or positives or both. if it started after fitting imobilizer etc then check the voltage at the fuse panel as something may have been disrupted

Create an account or sign in to comment

You need to be a member in order to leave a comment

Create an account

Sign up for a new account in our community. It's easy!

Register a new account

Sign in

Already have an account? Sign in here.

Sign In Now


  • Similar Content

  • Latest Posts

    • I came here to note that is a zener diode too base on the info there. Based on that, I'd also be suspicious that replacing it, and it's likely to do the same. A lot of use cases will see it used as either voltage protection, or to create a cheap but relatively stable fixed voltage supply. That would mean it has seen more voltage than it should, and has gone into voltage melt down. If there is something else in the circuit dumping out higher than it should voltages, that needs to be found too. It's quite likely they're trying to use the Zener to limit the voltage that is hitting through to the transistor beside it, so what ever goes to the zener is likely a signal, and they're using the transistor in that circuit to amplify it. Especially as it seems they've also got a capacitor across the zener. Looks like there is meant to be something "noisy" to that zener, and what ever it was, had a melt down. Looking at that picture, it also looks like there's some solder joints that really need redoing, and it might be worth having the whole board properly inspected.  Unfortunately, without being able to stick a multimeter on it, and start tracing it all out, I'm pretty much at a loss now to help. I don't even believe I have a climate control board from an R33 around here to pull apart and see if any of the circuit appears similar to give some ideas.
    • Nah - but you won't find anything on dismantling the seats in any such thing anyway.
    • Could be. Could also be that they sit around broken more. To be fair, you almost never see one driving around. I see more R chassis GTRs than the Renault ones.
    • Yeah. Nah. This is why I said My bold for my double emphasis. We're not talking about cars tuned to the edge of det here. We're talking about normal cars. Flame propagation speed and the amount of energy required to ignite the fuel are not significant factors when running at 1500-4000 rpm, and medium to light loads, like nearly every car on the road (except twin cab utes which are driven at 6k and 100% load all the time). There is no shortage of ignition energy available in any petrol engine. If there was, we'd all be in deep shit. The calorific value, on a volume basis, is significantly different, between 98 and 91, and that turns up immediately in consumption numbers. You can see the signal easily if you control for the other variables well enough, and/or collect enough stats. As to not seeing any benefit - we had a couple of EF and EL Falcons in the company fleet back in the late 90s and early 2000s. The EEC IV ECU in those things was particularly good at adding in timing as soon as knock headroom improved, which typically came from putting in some 95 or 98. The responsiveness and power improved noticeably, and the fuel consumption dropped considerably, just from going to 95. Less delta from there to 98 - almost not noticeable, compared to the big differences seen between 91 and 95. Way back in the day, when supermarkets first started selling fuel from their own stations, I did thousands of km in FNQ in a small Toyota. I can't remember if it was a Starlet or an early Yaris. Anyway - the supermarket servos were bringing in cheap fuel from Indonesia, and the other servos were still using locally refined gear. The fuel consumption was typically at least 5%, often as much as 8% worse on the Indo shit, presumably because they had a lot more oxygenated component in the brew, and were probably barely meeting the octane spec. Around the same time or maybe a bit later (like 25 years ago), I could tell the difference between Shell 98 and BP 98, and typically preferred to only use Shell then because the Skyline ran so much better on it. Years later I found the realtionship between them had swapped, as a consequence of yet more refinery closures. So I've only used BP 98 since. Although, I must say that I could not fault the odd tank of United 98 that I've run. It's probably the same stuff. It is also very important to remember that these findings are often dependent on region. With most of the refineries in Oz now dead, there's less variability in local stuff, and he majority of our fuels are not even refined here any more anyway. It probably depends more on which SE Asian refinery is currently cheapest to operate.
    • You don't have an R34 service manual for the body do you? Have found plenty for the engine and drivetrain but nothing else
×
×
  • Create New...