Jump to content
SAU Community

Recommended Posts

First off; this is not a cruise, not a BBQ or even a dyno day... this is a workshop day or sorts, I just didn't know where else to post it so I guess Events would make sense...

INFORMATION:

A few of us were talking about painting brake calipers today and came to the conclusion that a group effort on all the cars would be a good idea. This way, we succeed together and fail together :) Hopefully all goes well and we all leave with shiny new brake calipers!

I'm just posting the details so anyone who is interested can join in the fun! The location may be out of the way for some, so it's entirely up to you. If we finish in good time we may do something after seeing it's a holiday and all :D

DATE:

Boxing Day; 26 December 2005 (will be confirmed)

TIME:

Looking at a 10am start to get through all the cars and have plenty of time for the paint to dry!

LOCATION:

After checking with my mum, she said it's ok to have it at her factory complex car park which has enough parking for 100 cars (across 4 levels), on dead flat surfaces.

Only condition is we keep the concrete clear of paint and I make sure everyone who turns up is known/trusted (for security reasons). She is not the only tennant there, other tennants include BMW, Porsche not 1 but 2 import workshops!

MAP:

Below is a map of the place where this will be held, I am happy to do a 9:00am meet at Chatswood for those who won't know the way.

map2.gif

map1.gif

EQUIPMENT:

As all the nearby workshops will be closed, and this is purely a car park - all tools and equipment will need to be brought along. If you have any of the following, please post up here and bring it with you on the day.

* Heavy Duty Car Jacks (will need two per car)

* Normal Car Jacks (will need four per car)

* Bricks x 4 (just in case not enough jacks)

* Newspaper (obvious)

* Masking Tape

* Wet + Dry Paper

* Any tools to remove your wheels (remember lock nut adaptors)

Paint will be provided by each person... you are responsible for getting this before you rock up on the day. There is a thread in here with the types of paints needed. A few other members and I are trying to organize a group buy for the paint but no promises, better have something prepared than to be sorry on the day.

That said, anyone who can get a discount on this paint please post up here :D We will love you for it!

I think that's it for now... will add more later if it comes up :)

EDIT: We might organize to have a bbq or something there too :P because all the shops and stuff are closed, food will be a bitch to find on the day; all depends on how many people turn up - we could all pitch in some food or bbq gear :)

RSVP LIST:

* satanic >>> Gold

* rukus >>> Gold

* Wink

* d00dz >>> Blue

* ecl

* Miss Turbo

* ranicx >>> Gold

Link to comment
https://www.sau.com.au/forums/topic/98856-sau-nsw-brake-caliper-day/
Share on other sites

  • Replies 120
  • Created
  • Last Reply

Top Posters In This Topic

Top Posters In This Topic

Posted Images

good idea mate. but a little advice. you only need 2 stands (or 4 if you want to do front and rear at the same time) per car and say 1 jack between 3 or 4. I would never work on a car that is not supported by proper stands. jacks have been known to bleed down, or simply fail. and landing on you, or even on bricks is not nice.

I would say get each person to bring 2 or 4 stands, and try and get 1 jack between 3 or 4 people.

have fun :)

Sorry mate, the date has to be around the public holiday period. It's only those dates when I can guarantee an empty car park and the place to ourselves.

With painting going on, I think it would be the best option right?

Guys another tip is use WOOD not bricks. Get some 4x4 or 4x2 wood pieces and chop them into 1ft long blocks. You will need about 4 per side. Bricks tend to break if the car lands on them hard and also tends to scratch the underside of the lower control arms.

Also KFC is around the corner (walking distance) so food may not be a problem.

Just got off the phone with Autobarn; the VHT Caliper Paints go for RRP $14.99 per can... the guy said we'd be able to get it for $13 per can assuming an order of 10-15 cans.

Colors are quite limited though;

Black

Orange

Blue

Red

Looks like d00dz is in luck :D

dang, gold was sounded good.. gold/chrome rims, gold calipers, would look nice

i think i have 4 car stands floating around in the garage somwhere. got a light/medium (i think) too.. it does leak a lil and not always go all the way up, so stands are a must.. wouldnt work with out stands anyway :D

where can i get this fancy gold paint stuff for calipers? :)

oh also, wet + dry paper? do ya mean wet and dry sand paper?

hey tight is good! .. (better then loose :lol:) .. lol

seriously though, y spend more money to get the same thing? the stock 4 piston calipers are good, i dont see the need to upgrade to brembos unless ya got serious power over what is stock

anyway, back on topic, ill be there stan if im able to find some of this gold paint :)

yep loose is not good haha

if uz are talking about the gold paint that i think u are... thats the way to go!

i rememba doing the r32 brakes with this other high temp spray... it used to pick up and stain grime and oily shit into it and would look black and greasy in a month time...

the gold one is awesome.




  • Similar Content

  • Latest Posts

    • Next on the to-do list was an oil and filter change. Nothing exciting to add here except the oil filter is in a really stupid place (facing the engine mount/subframe/steering rack). GReddy do a relocation kit which puts it towards the gearbox, I would have preferred towards the front but there's obviously a lot more stuff there. Something I'll have to look at for the next service perhaps. First time using Valvoline oil, although I can't see it being any different to most other brands Nice... The oil filter location... At least the subframe wont rust any time soon I picked up a genuine fuel filter, this is part of the fuel pump assembly inside the fuel tank. Access can be found underneath the rear seat, you'll see this triangular cover Remove the 3x plastic 10mm nuts and lift the cover up, pushing the rubber grommet through The yellow fuel line clips push out in opposite directions, remove these completely. The two moulded fuel lines can now pull upwards to disconnect, along with the wire electrical plug. There's 8x 8mm bolts that secure the black retaining ring. The fuel pump assembly is now ready to lift out. Be mindful of the fuel hose on the side, the hose clamp on mine was catching the hose preventing it from lifting up The fuel pump/filter has an upper and lower section held on by 4 pressure clips. These did take a little bit of force, it sounded like the plastic tabs were going to break but they didn't (don't worry!) The lower section helps mount the fuel pump, there's a circular rubber gasket/grommet/seal thing on the bottom where the sock is. Undo the hose clip on the short fuel hose on the side to disconnect it from the 3 way distribution pipe to be able to lift the upper half away. Don't forget to unplug the fuel pump too! There's a few rubber O rings that will need transferring to the new filter housing, I show these in the video at the bottom of this write up. Reassembly is the reverse Here's a photo of the new filter installed, you'll be able to see where the tabs are more clearing against the yellow OEM plastic Once the assembly is re-installed, I turned the engine over a few times to help build up fuel pressure. I did panic when the car stopped turning over but I could hear the fuel pump making a noise. It eventually started and has been fine since. Found my 'lucky' coin underneath the rear seat too The Youtube video can be seen here: https://www.youtube.com/watch?v=uLJ65pmQt44&t=6s
    • It was picked up on the MOT/Inspection that the offside front wheel bearing had excessive play along with the ball joint. It made sense to do both sides so I sourced a pair of spare IS200 hubs to do the swap. Unfortunately I don't have any photos of the strip down but here's a quick run down. On the back of the hub is a large circular dust cover, using a flat head screw driver and a mallet I prised it off. Underneath will reveal a 32mm hub nut (impact gun recommended). With the hub nut removed the ABS ring can be removed (I ended up using a magnetic pick up tool to help). Next up is to remove the stub axle, this was a little trickier due to limited tools. I tried a 3 leg puller but the gap between the hub and stub axle wasn't enough for the legs to get in and under. Next option was a lump hammer and someone pulling the stub axle at the same time. After a few heavy hits it released. The lower bearing race had seized itself onto the stub axle, which was fine because I was replacing them anyway. With the upper bearing race removed and the grease cleaned off they looked like this The left one looked pristine inside but gave us the most trouble. The right one had some surface rust but came apart in a single hit, figure that out?! I got a local garage to press the new wheel bearings in, reassemble was the opposite and didn't take long at all. Removing the hub itself was simple. Starting with removing the brake caliper, 2x 14mm bolts for the caliper slider and 2x 19mm? for the carrier > hub bolts. I used a cable tie to secure the caliper to the upper arm so it was out of the way, there's a 10mm bolt securing the ABS sensor on. With the brake disc removed from the hub next are the three castle nuts for the upper and lower ball joints and track rod end. Two of these had their own R clip and one split pin. A few hits with the hammer and they're released (I left the castle nuts on by a couple of turns), the track rod ends gave me the most grief and I may have nipped the boots (oops). Fitting is the reversal and is very quick and easy to do. The lower ball joints are held onto the hub by 2x 17mm bolts. The castle nut did increase in socket size to 22mm from memory (this may vary from supplier) The two front tyres weren't in great condition, so I had those replaced with some budget tyres for the time being. I'll be replacing the wheels and tyres in the future, this was to get me on the road without the worry of the police hassling me.
    • Yep, the closest base tune available was for the GTT, I went with that and made all the logical changes I could find to convert it to Naturally Aspirated. It will rev fine in Neutral to redline but it will be cutting nearly 50% fuel the whole way.  If I let it tune the fuel map to start with that much less fuel it wont run right and has a hard time applying corrections.  These 50% cuts are with a fuel map already about half of what the GTT tune had.  I was having a whole lot of bogging when applying any throttle but seem to have fixed that for no load situations with very aggressive transient throttle settings. I made the corrections to my injectors with data I found for them online, FBCJC100 flowing 306cc.  I'll have to look to see if I can find the Cam section. I have the Bosch 4.9 from Haltech. My manifold pressure when watching it live is always in -5.9 psi/inHg
    • Hi My Tokico BM50 Brake master cylinder has a leak from the hole between the two outlets (M10x1) for brake pipes, I have attached a photo. Can anyone tell me what that hole is and what has failed to allow brake fluid to escape from it, I have looked on line and asked questions on UK forums but can not find the answer, if anyone can enlighten me I would be most grateful.
    • It will be a software setting. I don't believe many on here ever used AEM. And they're now a discontinued product,that's really hard to find any easy answers on. If it were Link or Haltech, someone would be able to just send you a ECU file though.
×
×
  • Create New...