Jump to content
SAU Community

Recommended Posts

  • Replies 40
  • Created
  • Last Reply

Top Posters In This Topic

Originally posted by hks-s14

XRW - what happened to the 34?  Blow an engine?

It has spat the motor as most know, the failure atm seems likely to have been caused by the lack luster machining that was done on the block, and a few others at the time until the lack of quality in the machine work was discovered, anoyingly it blew just before the motor was going to be pulled out, checked, and the problem with the poor machining work, if it was there, resolved, (owner wanted to go for a last few runs at the drags before he went home for a holiday).

It should be back in action shortly, the other problem with it is the stock gearbox, and the 99% chance it will fail shortly due to the power output of the motor, a dog box is the owners next purchase, and that will take somewhere between 8-12 weeks to get one made within oz, and a few weeks to source a unit from japan, and given the hasles the stock box gave when it ran 11.1, itd be better to have a box that will work cleanly so as to make a full power pass worth while of getting kicked out, itd be anoying to see it go just under 10.99 and not do a run near its full capabilities, which is somewhere down to a very low ten and possibly on a perfect run, a high 9..

Originally posted by Strich9ine

Explain to me then why you "get to drive it" ?

The owner isn't that confident with going flat out, and doesn't feel he has the ability to make the car do what it can do just yet..

That and hes a bit of a voyer and likes to watch it in action going in a straight line i guess..

Originally posted by Steve-SST

Should have been properly inspected when assembled.

When it went together there wasn't the time to spend a few hours checking all the measurements, not with the 2ic of JUN waiting there to tune it, and as the machinist gave his word that the machining would be spot on, it was trusted he did his job properly..

The same comment could be made about adjusting timing with a ratchet, and not bothering to check with a timing light to see the original timing and the new adjustment, but i won't point that out will I..

Originally posted by hks-s14

Bad machining hey... bugger.  So what was machined badly that made the engine pop?

Must be an expensive exercise...do speedworks get insurance for that kind of stuff or can claim it against who did the machining?

Excessive ovalation of the bore, outside of the allowable tolerances, causing blow by and excessive piston slap..

and the car is being repaired at no cost to the owner and the matter being taken up witht he machinist, along with the other work that he did which has failed..

I have moved the CAS without a timing light plenty of times. After a while you get an idea of where the thing should be based on the engine response. I can't use the timing marks anyway, I've gone right past them.

Steve-sst, you obviously tune the right way. Use response/power and engine knock to determine optimum timing. The timing light doesn't tell you jack! It tells you what the timing 'is' not if it's too much or not enough.

Originally posted by rev210

I have moved the CAS without a timing light plenty of times. After a while you get an idea of where the thing should be based on the engine response. I can't use the timing marks anyway, I've gone right past them.  

Steve-sst, you obviously tune the right way. Use response/power and engine knock to determine optimum timing. The timing light doesn't tell you jack! It tells you what the timing 'is' not if it's too much or not enough.

Rev, and your original reference point is?..

its good practice to check before and after where you have started, its all well and good to move it, but what if you wind on some 10+ degree's of advance without knowing it and suddenly get detonation, its a bit hard to go back to where you began if you didn't check it..

power and response may be better, but at what cost if it starts pinging because theres to much advance..

XRW,

I've had a timing gun on my car before, made a mark on the CAS.I know the position so well I don't even need to look at the mark.

I don't need the timing light as a refference.

If I over advance I will pick that up long before I get a ping, thanks to the knock sensor. The CAS is where I make the mark for refference/starting point. The timing light can be used to make experimental adjustments in increments in the same way as rotating the CAS.

There is an ideal spot for timing that doesn't ping and gives extra response, I don't need to use a timing light on my car right now to do that.

How do you think you improve timing performance with just a timing gun, you would certainly agree with me that it can't tell you anything important as far as thats concerned. What you need is the engine knock and some sort of power reading to determine if you are advanced too far or not far enough.

Perhaps we just misunderstood each other. I appologise if I am stating the obvious to you to get the point across.

On Pauls GTS we chased peak HP and torque at each load

point while tuning then when finished I do a power run and

then advance the timing with the Wolf then retard it and see

where we gain and lose and then set the perfect ign map.

Nissan CAS only fit one way and are very consistant and as

I see many every week you can judge the advance at a glance.

Who cares where the timing was when you have the Dyno

to test the result any way.

and the car is being repaired at no cost to the owner and the matter being taken up witht he machinist, along with the other work that he did which has failed..

Ohhh so not a once off incident. Hopefully you won't be using that machining shop anymore. Unbelieveable that they can stuff up that much when it comes to something as simple as machining.

Originally posted by rev210

XRW,

If I over advance I will pick that up long before I get a ping, thanks to the knock sensor. The CAS is where I make the mark for refference/starting point. The timing light can be used to make experimental adjustments in increments in the same way as rotating the CAS.

There is an ideal spot for timing that doesn't ping and gives extra response, I don't need to use a timing light on my car right now to do that.  

I understand you exactly where you comming from, my main point being that every car is different, and a twist on the CAS can result in anything from 1-2 degree's to 10-15 degree's of advance in one foul swoop, given the nissan ecu in stock form will detect the knock long before it becomes a large ping, but this will only result in a loss of power not a gain..

im just a fan of checking simple things like that, and as you said it, every car will have a nice point where it gets good power and response, but won't put the engine in the danger zone of detonating and knocking causing the ecu to knock everything back down..

main point being that unless as you have, done it a thousand time on the same car, checking first then gradually moving things around until it seems spot on, then checking again to see where eveything is set, is smarter than unbolting, twisting, and having no idea if you just wound in 5 deg of advance, or 15..

Originally posted by hks-s14

Ohhh so not a once off incident.  Hopefully you won't be using that machining shop anymore.  Unbelieveable that they can stuff up that much when it comes to something as simple as machining.

Well yeah, the other motors that failed where sr20's owned by the guys at speedworks and not as in the case of the 34, a customer car, and basically the same problem, bores to out of round and incorectly tapered, but in this case, these sr20's had liners installed to handle the extra power demands, and due to the nature of the liner being interferance fit, and the bore holding the liner not providing the right amount of interferance, the liner moves around, breaks the seal with the head gasket, and water get into the bore..

they've since changed machinist and are religiously checking every bore that comes in now for ovality and taper, anoyingly in the case of the 34, every other measurement got checked, eg bearing cap crush ring gap etc etc, the only thing not check was the ovality and taper of the bore, something im sure 90% of motor builders wouldn't check as the assumption is that the machinist has done his job right..

whats the saying, assumtion is the mother of all stuffups..

Dude,

I've heard 50 micron being bandied about as the figure that the bores were out - that isnt going to kill a motor if its 50 micron bigger than it needs to be - only if its 50 mic smaller...Besides which 50 micron is that small that it would almost go through a fuel filter and be burnt in fuel.

The problem to me sounds like the car was tuned too keen too quickly, but hey what do I know about tuning a car - I'm not Japanese.

Dont knock CAS knocking - it works alright for us and SST, and I cant remember a car that we've tuned going bang at the drags.

Jash

Guest
This topic is now closed to further replies.



  • Similar Content

  • Latest Posts

    • Surely somebody has one in VIC. Have you asked at any shops?  Is this the yearly inspection or did you get a canary?
    • This is where I share pain with you, @Duncan. The move to change so many cooling system pieces to plastic is a killer! Plastic end tanks and a few plastic hose flanges on my car's fail after so little time.  Curious about the need for a bigger rad, is that just for long sessions in the summer or because the car generally needs more cooling?
    • So, that is it! It is a pretty expensive process with the ATF costing 50-100 per 5 litres, and a mechanic will probably charge plenty because they don't want to do it. Still, considering how dirty my fluid was at 120,000klm I think it would be worth doing more like every 80,000 to keep the trans happy, they are very expensive to replace. The job is not that hard if you have the specialist tools so you can save a bit of money and do it yourself!
    • OK, onto filling. So I don't really have any pics, but will describe the process as best I can. The USDM workshop manual also covers it from TM-285 onwards. First, make sure the drain plug (17mm) is snug. Not too tight yet because it is coming off again. Note it does have a copper washer that you could replace or anneal (heat up with a blow torch) to seal nicely. Remove the fill plug, which has an inhex (I think it was 6mm but didn't check). Then, screw in the fill fitting, making sure it has a suitable o-ring (mine came without but I think it is meant to be supplied). It is important that you only screw it in hand tight. I didn't get a good pic of it, but the fill plug leads to a tube about 70mm long inside the transmission. This sets the factory level for fluid in the trans (above the join line for the pan!) and will take about 3l to fill. You then need to connect your fluid pump to the fitting via a hose, and pump in whatever amount of fluid you removed (maybe 3 litres, in my case 7 litres). If you put in more than 3l, it will spill out when you remove the fitting, so do quickly and with a drain pan underneath. Once you have pumped in the required amount of clean ATF, you start the engine and run it for 3 minutes to let the fluid circulate. Don't run it longer and if possible check the fluid temp is under 40oC (Ecutek shows Auto Trans Fluid temp now, or you could use an infrared temp gun on the bottom of the pan). The manual stresses the bit about fluid temperature because it expands when hot an might result in an underfil. So from here, the factory manual says to do the "spill and fill" again, and I did. That is, put an oil pan under the drain plug and undo it with a 17mm spanner, then watch your expensive fluid fall back out again, you should get about 3 litres.  Then, put the drain plug back in, pump 3 litres back in through the fill plug with the fitting and pump, disconnect the fill fitting and replace the fill plug, start the car and run for another 3 minutes (making sure the temp is still under 40oC). The manual then asks for a 3rd "spill and fill" just like above. I also did that and so had put 13l in by now.  This time they want you to keep the engine running and run the transmission through R and D (I hope the wheels are still off the ground!) for a while, and allow the trans temp to get to 40oC, then engine off. Finally, back under the car and undo the fill plug to let the overfill drain out; it will stop running when fluid is at the top of the levelling tube. According to the factory, that is job done! Post that, I reconnected the fill fitting and pumped in an extra 0.5l. AMS says 1.5l overfill is safe, but I started with less to see how it goes, I will add another 1.0 litres later if I'm still not happy with the hot shifts.
    • OK, so regardless of whether you did Step 1 - Spill Step 2 - Trans pan removal Step 3 - TCM removal we are on to the clean and refill. First, have a good look at the oil pan. While you might see dirty oil and some carbony build up (I did), what you don't want to see is any metal particles on the magnets, or sparkles in the oil (thankfully not). Give it all a good clean, particularly the magnets, and put the new gasket on if you have one (or, just cross your fingers) Replacement of the Valve body (if you removed it) is the "reverse of assembly". Thread the electrical socket back up through the trans case, hold the valve body up and put in the bolts you removed, with the correct lengths in the correct locations Torque for the bolts in 8Nm only so I hope you have that torque wrench handy (it feels really loose). Plug the output speed sensor back in and clip the wiring into the 2 clips, replace the spring clip on the TCM socket and plug it back into the car loom. For the pan, the workshop manual states the following order: Again, the torque is 8Nm only.
×
×
  • Create New...