Jump to content
SAU Community

Recommended Posts

Hello,

I installed my new Power FC last weekend(R32 GT-R), went for a drive, monitored everything, seemed ok, so I left it in for the week. Unfortunately it developed a miss by Thursday morning. The injection map is set too rich for town driving and as a result it fowled the spark plugs. Old ECU back in, quick burn out the highway sorted that.

Not really keen on driving 700kms to get my car tuned, since I live in the country, so I would like to have a go myself. I know that doesn't sound very wise, but I think I have a pretty good idea on what needs to be done.

I would like to know how everyone else messures their air:fuel ratios. I can use that to set up the injection map. It's not as simple as using the O2 sensors because they produce a varying voltage depending on what the ECU sets as the A:F ratio(closed loop).

Or I could messure the precise air flow and set it using that, but I need some idea on voltage tables so that I can compare the air flow meter voltage and set a corresponding injection value. For eg: if the MAF sensor reads 1 volt, that might equal 1kg of air so I would set the injection value on that load point of the map to X.

Could someone post up their own methods of tuning their cars, I know that there are a few people that claim they have done it. Let me know what else I need to do. Or if someone knows a member(I can't remember their names otherwise I might message them) could you put me in touch with them.

Link to comment
https://www.sau.com.au/forums/topic/197716-tuning-my-gt-r/
Share on other sites

you need a wideband sensor to measure af ratio - not a standard 02 sensor, they are narrow band which is slow and 0v to 1v

a wideband is nice and fast and 0v to 5v which is much more accurate and linear - around $400 ish

youll need some understanding of afr's, exhaust temps, ign timing, fuel injection, and general tuning

there is lots of documentation out there and some tools that can help - also be sure to note if you do it wrong or make a mistake you can kill the engine

so if you cant fork out the cash for rebuild or arent prepared to then you should reconsider - its a given risk, yes but a few wrong settings can be fatal

last but not least have a read of the powerfc faq to learn most of the common things and how to tune it

http://paulr33.sauvic.com.au/docs/powerfc-...powerfc-faq.htm

Link to comment
https://www.sau.com.au/forums/topic/197716-tuning-my-gt-r/#findComment-3534015
Share on other sites

Yeah thanks Paulr33.

I have read just about all of the FAQ before doing anthing, it's awsome, thanks heaps for it. I understand most of it. I know that too high combustion temps(too lean) and I'll melt a piston and other such stuff. I just finished a basic engine management course, so I learnt a fair bit on that sort stuff, timing, mixture etc, just don't know how to measure and set it all properly yet.

How do I use a wide band sensor and where can I get one?

Are there any other threads on the forum that you know of that might assist me?

And as a general rule, to set ignition timing, you would try to advance it as far as possible at all load points without producing too much knock, is that right?

And for injection it would be as close to 14.7:1, until exhaust temp(combustion temps) get too high and then richen it up a bit, so under the highest load points of the map? Also to provent knock.

Link to comment
https://www.sau.com.au/forums/topic/197716-tuning-my-gt-r/#findComment-3534026
Share on other sites

wideband sensors can be set up in a few different ways

you can have a temp sensor up the exhaust muffler (external) or you can install it in your dump pipe(s) next to the factory ones

you want the wideband sensor as close to the exhaust outlet for accruate representation so im not sure how u would do it on a gtr with twin dumps

perhaps somewhere near the cat or just after the cats it joins up? but somewhere there

then youll need a wideband guage or digital box - www.wb02.com.au has some good kits - techedge i believe is the one you are after

some are cheap and some are expensive with logging etc etc. if its your own car its probably best to install it in the dump pipes

the idea with ign timing is to run as much as possible but keep it under safe knocking or detonation levels

i basically kept upping the timing on mine until knock hovers around the 10 mark ish and leave it there

this gives the car a crisp & gives fantastic response but thats just for light cruise - i didnt do any high load ign tming - be careful with this (get a tuner to do it)

and youll need the dyno to ramp up 4th gear and touch the end of the map (180km+ area in 4th) so not suitable for the road

the afr's you can lean out on light cruise (make sure you disable 02 feedbackl while tuning) and again get a tuner to do max load afrs ( need dyno)

from memory my afrs on light cruise are somewhere near 15.5 to almost 16 i think - again too high and youll melt valves etc

Link to comment
https://www.sau.com.au/forums/topic/197716-tuning-my-gt-r/#findComment-3534035
Share on other sites

this is what i used when i did my car

as you can see its a temp wideband sensor

this might be more suitable

i dont see the need for a perm installed 02 sensor

http://paulr33.skylinesaustralia.com/photo...ar/IMGP1207.JPG

http://paulr33.skylinesaustralia.com/photo...ar/IMGP1208.JPG

http://paulr33.skylinesaustralia.com/photo...ar/IMGP1209.JPG

Link to comment
https://www.sau.com.au/forums/topic/197716-tuning-my-gt-r/#findComment-3534036
Share on other sites

Thanks Paul. I found your DIY tuning thread as well, having a read through it.

Why should the feedback on O2 sensors be disabled for tuning?

Perhaps we could start a table of MAF sensor voltage. It would make tuning so much easier, for anyone on the forum. Do get what I mean by my description in the topic post?

Link to comment
https://www.sau.com.au/forums/topic/197716-tuning-my-gt-r/#findComment-3534071
Share on other sites

cos if 02 feedback is on while you are tuning the FC will adjust and lean itself out to stoich or the 02 feedback co-efficient value in the FC

in theory - it will auto correct what you set on the INJ map in closed loop - so have it off to see the true numbers

Link to comment
https://www.sau.com.au/forums/topic/197716-tuning-my-gt-r/#findComment-3534095
Share on other sites

i got sick of people asking me what that thing is in my exaust pipe so it has its own home before the cat now.. much more accurate for low throttle imho

The techedge stuff www.wideband.com is the best you can get in australia in my opinion. buy one from there. the after sales SUPPORT is second to none.

this is what i used when i did my car

as you can see its a temp wideband sensor

this might be more suitable

i dont see the need for a perm installed 02 sensor

http://paulr33.skylinesaustralia.com/photo...ar/IMGP1207.JPG

http://paulr33.skylinesaustralia.com/photo...ar/IMGP1208.JPG

http://paulr33.skylinesaustralia.com/photo...ar/IMGP1209.JPG

Link to comment
https://www.sau.com.au/forums/topic/197716-tuning-my-gt-r/#findComment-3538342
Share on other sites

^^ i like the innovate gear http://www.innovatemotorsports.com/ ( i personally use a LM-1) from rocket industries as it has plenty of add-ons and the LC1 is cheap too >_<

and Guilt-Toy yeah your right in the tailpipe is no good for idle etc....

more info http://www.titanmotorsports.com/lmdiairame.html

Link to comment
https://www.sau.com.au/forums/topic/197716-tuning-my-gt-r/#findComment-3538730
Share on other sites

Another recommendation for the Innovate product.

I now have an LC1 with an XD16 gauge. Integrates very well with the Datalogit and is a permanent install install now with a single USB port for logging all information. The online manual is quite detailed in how to install and integrate with the Datalogit and the forum gives good advice for any problems (I had none and all worked first go).

Link to comment
https://www.sau.com.au/forums/topic/197716-tuning-my-gt-r/#findComment-3539241
Share on other sites

Thanks to all the others that left responses and recommendations. I might have to get on to you about some more info soon.

Some of that gear looks pretty hardcore serious. I want to get to that stage, but at this point I just have a standardish motor and that looks like a rather big jump with extra controllers and stuff. Bit over the top for a standard car, maybe a little to exy as well for now when I won't see that much gain.

Then again, if it's the absolute only way of tuning my PFC is guess I'll have to go that way. Is the same sort of gear the most tuner workshops use? Obviously the have tailpipe jobbies(portable styles).

Link to comment
https://www.sau.com.au/forums/topic/197716-tuning-my-gt-r/#findComment-3540295
Share on other sites

and Guilt-Toy yeah your right in the tailpipe is no good for idle etc....

more info http://www.titanmotorsports.com/lmdiairame.html

I find that in the tail pipe is okay for small exausts its only when you have it going into a massive cannon where it can give you lean readings on idle and soft cruise.

Thanks to all the others that left responses and recommendations. I might have to get on to you about some more info soon.

Some of that gear looks pretty hardcore serious. I want to get to that stage, but at this point I just have a standardish motor and that looks like a rather big jump with extra controllers and stuff. Bit over the top for a standard car, maybe a little to exy as well for now when I won't see that much gain.

Then again, if it's the absolute only way of tuning my PFC is guess I'll have to go that way. Is the same sort of gear the most tuner workshops use? Obviously the have tailpipe jobbies(portable styles).

I would honestly go for the wideband.com range with the green display (looks cool) Dyno workshops will have one attatched to their dyno and alot of them have a portable device to test the car with on the street as well.

I drive around with mine hooked up all the time and i allways watch it, it saved my engine once already as the fuel pump started to fail and i picked it up straight away because it was reading lean mixtures on boost so then i introduced the bosh 044 pump which fixed my fuel issue.

Its a good tool to have and it can be moved easily to other cars to check the afr's.. i got one before i got any other toy or device for my car once my engine was built because i was sick of hireing one.

Link to comment
https://www.sau.com.au/forums/topic/197716-tuning-my-gt-r/#findComment-3540754
Share on other sites

Thanks to all the others that left responses and recommendations. I might have to get on to you about some more info soon.

Some of that gear looks pretty hardcore serious. I want to get to that stage, but at this point I just have a standardish motor and that looks like a rather big jump with extra controllers and stuff. Bit over the top for a standard car, maybe a little to exy as well for now when I won't see that much gain.

Then again, if it's the absolute only way of tuning my PFC is guess I'll have to go that way. Is the same sort of gear the most tuner workshops use? Obviously the have tailpipe jobbies(portable styles).

A datalogit and simple wideband set-up really isn't that expensive and is pretty straight forward to setup. It also helps you fine tune areas of the maps that will never be seen under dyno conditions.

Drop me a PM next time you come up to Perth and I'll show you my setup.

Gav

Link to comment
https://www.sau.com.au/forums/topic/197716-tuning-my-gt-r/#findComment-3540955
Share on other sites

Create an account or sign in to comment

You need to be a member in order to leave a comment

Create an account

Sign up for a new account in our community. It's easy!

Register a new account

Sign in

Already have an account? Sign in here.

Sign In Now


  • Similar Content

  • Latest Posts

    • Wow, thanks for your help guys 🙏. I really appreciate it. Thanks @Rezz, if i fail finding any new or used, full or partial set of original Stage carpets i will come back to you for sure 😉 Explenation is right there, i just missed it 🤦‍♂️. Thanks for pointing out. @soviet_merlin in the meantime, I received a reply from nengun, and i quote: "Thanks for your message and interest in Nengun. KG4900 is for the full set of floor mats, while KG4911 is only the Driver's Floor Mat. FR, RH means Front Right Hand Side. All the Full Set options are now discontinued. However, the Driver's Floor Mat options are still available according to the latest information available to us. We do not know what the differences would be, but if you only want the one mat, we can certainly see what we can find out for you". Interesting. It seems they still have some "new old stock" that Duncan mentioned 🤔. I wonder if they can provide any photos......And i also just realized that amayama have G4900 sets. I'm tempted too. 
    • Any update on this one? did you manage to get it fixed?    i'm having the same issue with my r34 and i believe its to do with the smart entry (keyless) control module but cant be sure without forking out to get a replacement  
    • So this being my first contribution to the SAU forums, I'd like to present and show how I had to solve probably one of the most annoying fixes on any car I've owned: replacing a speedometer (or "speedo") sensor on my newly acquired Series 1 Stagea 260RS Autech Version. I'm simply documenting how I went about to fix this issue, and as I understand it is relatively rare to happen to this generation of cars, it is a gigantic PITA so I hope this helps serve as reference to anyone else who may encounter this issue. NOTE: Although I say this is meant for the 260RS, because the gearbox/drivetrain is shared with the R33 GTR with the 5-speed manual, the application should be exactly the same. Background So after driving my new-to-me Stagea for about 1500km, one night while driving home the speedometer and odometer suddenly stopped working. No clunking noise, no indication something was broken, the speedometer would just stop reading anything and the odometer stopped going up. This is a huge worry for me, because my car is relatively low mileage (only 45k km when purchased) so although I plan to own the car for a long time, a mismatched odometer reading would be hugely detrimental to resale should the day come to sell the car. Thankfully this only occurred a mile or two from home so it wasn't extremely significant. Also, the OCD part of me would be extremely irked if the numbers that showed on my dash doesn't match the actual ageing of the car. Diagnosing I had been in communication with the well renown GTR shop in the USA, U.P.garage up near University Point in Washington state. After some back and forth they said it could be one of two things: 1) The speedometer sensor that goes into the transfer case is broken 2) The actual cluster has a component that went kaput. They said this is common in older Nissan gauge clusters and that would indicate a rebuild is necessary. As I tried to figure out if it was problem #1, I resolved problem #2 by sending my cluster over to Relentless Motorsports in Dallas, TX, whom is local to me and does cluster and ECU rebuilds. He is a one man operation who meticulously replaces every chip, resistor, capacitor, and electronic component on the PCB's on a wide variety of classic and modern cars. His specialty is Lexus and Toyota, but he came highly recommended by Erik of U.P.garage since he does the rebuilds for them on GTR clusters.  For those that don't know, on R32 and R33 GTR gearboxes, the speedometer sensor is mounted in the transfer case and is purely an analog mini "generator" (opposite of an alternator essentially). Based on the speed the sensor spins it generates an AC sine wave voltage up to 5V, and sends that via two wires up to the cluster which then interprets it via the speedometer dial. The signal does NOT go to the ECU first, the wiring goes to the cluster first then the ECU after (or so I'm told).  Problems/Roadblocks I first removed the part from the car on the underside of the transfer case (drain your transfer case fluid/ATF first, guess who found out that the hard way?), and noted the transfer case fluid was EXTREMELY black, most likely never changed on my car. When attempting to turn the gears it felt extremely gritty, as if something was binding the shaft from rotating properly. I got absolutely no voltage reading out of the sensor no matter how fast I turned the shaft. After having to reflow the solder on my AFM sensors based on another SAU guide here, I attempted to disassemble the silicone seal on the back of the sensor to see what happened inside the sensor; turns out, it basically disintegrated itself. Wonderful. Not only had the electrical components destroyed themselves, the magnetic portion on what I thought was on the shaft also chipped and was broken. Solution So solution: find a spare part right? Wrong. Nissan has long discontinued the proper sensor part number 32702-21U19, and it is no longer obtainable either through Nissan NSA or Nissan Japan. I was SOL without proper speed or mileage readings unless I figured out a way to replace this sensor. After tons of Googling and searching on SAU, I found that there IS however a sensor that looks almost exactly like the R33/260RS one: a sensor meant for the R33/R34 GTT and GTS-T with the 5 speed manual. The part number was 25010-21U00, and the body, plug, and shaft all looked exactly the same. The gear was different at the end, but knowing the sensor's gear is held on with a circlip, I figured I could just order the part and swap the gears. Cue me ordering a new part from JustJap down in Kirrawee, NSW, then waiting almost 3 weeks for shipping and customs clearing. The part finally arrives and what did I find? The freaking shaft lengths don't match. $&%* I discussed with Erik how to proceed, and figuring that I basically destroyed the sensor trying to get the shaft out of the damaged sensor from my car. we deemed it too dangerous to try and attempt to swap shafts to the correct length. I had to find a local CNC machinist to help me cut and notch down the shaft. After tons of frantic calling on a Friday afternoon, I managed to get hold of someone and he said he'd be able to do it over half a week. I sent him photos and had him take measurements to match not only the correct length and notch fitment, but also a groove to machine out to hold the retentive circlip. And the end result? *chef's kiss* Perfect. Since I didn't have pliers with me when I picked up the items, I tested the old gear and circlip on. Perfect fit. After that it was simply swapping out the plug bracket to the new sensor, mount it on the transfer case, refill with ATF/Nissan Matic Fluid D, then test out function. Thankfully with the rebuilt cluster and the new sensor, both the speedometer and odometer and now working properly!   And there you have it. About 5-6 weeks of headaches wrapped up in a 15 minute photo essay. As I was told it is rare for sensors of this generation to die so dramatically, but you never know what could go wrong with a 25+ year old car. I HOPE that no one else has to go through this problem like I did, so with my take on a solution I hope it helps others who may encounter this issue in the future. For the TL;DR: 1) Sensor breaks. 2) Find a replacement GTT/GTS-T sensor. 3) Find a CNC machinist to have you cut it down to proper specs. 4) Reinstall then pray to the JDM gods.   Hope this guide/story helps anyone else encountering this problem!
    • So this being my first contribution to the SAU forums, I'd like to present and show how I had to solve probably one of the most annoying fixes on any car I've owned: replacing a speedometer (or "speedo") sensor on my newly acquired Series 1 Stagea 260RS Autech Version. I'm simply documenting how I went about to fix this issue, and as I understand it is relatively rare to happen to this generation of cars, it is a gigantic PITA so I hope this helps serve as reference to anyone else who may encounter this issue. NOTE: Although I say this is meant for the 260RS, because the gearbox/drivetrain is shared with the R33 GTR with the 5-speed manual, the application should be exactly the same. Background So after driving my new-to-me Stagea for about 1500km, one night while driving home the speedometer and odometer suddenly stopped working. No clunking noise, no indication something was broken, the speedometer would just stop reading anything and the odometer stopped going up. This is a huge worry for me, because my car is relatively low mileage (only 45k km when purchased) so although I plan to own the car for a long time, a mismatched odometer reading would be hugely detrimental to resale should the day come to sell the car. Thankfully this only occurred a mile or two from home so it wasn't extremely significant. Also, the OCD part of me would be extremely irked if the numbers that showed on my dash doesn't match the actual ageing of the car. Diagnosing I had been in communication with the well renown GTR shop in the USA, U.P.garage up near University Point in Washington state. After some back and forth they said it could be one of two things: 1) The speedometer sensor that goes into the transfer case is broken 2) The actual cluster has a component that went kaput. They said this is common in older Nissan gauge clusters and that would indicate a rebuild is necessary. As I tried to figure out if it was problem #1, I resolved problem #2 by sending my cluster over to Relentless Motorsports in Dallas, TX, whom is local to me and does cluster and ECU rebuilds. He is a one man operation who meticulously replaces every chip, resistor, capacitor, and electronic component on the PCB's on a wide variety of classic and modern cars. His specialty is Lexus and Toyota, but he came highly recommended by Erik of U.P.garage since he does the rebuilds for them on GTR clusters.  For those that don't know, on R32 and R33 GTR gearboxes, the speedometer sensor is mounted in the transfer case and is purely an analog mini "generator" (opposite of an alternator essentially). Based on the speed the sensor spins it generates an AC sine wave voltage up to 5V, and sends that via two wires up to the cluster which then interprets it via the speedometer dial. The signal does NOT go to the ECU first, the wiring goes to the cluster first then the ECU after (or so I'm told).  Problems/Roadblocks I first removed the part from the car on the underside of the transfer case (drain your transfer case fluid/ATF first, guess who found out that the hard way?), and noted the transfer case fluid was EXTREMELY black, most likely never changed on my car. When attempting to turn the gears it felt extremely gritty, as if shttps://imgur.com/6TQCG3xomething was binding the shaft from rotating properly. After having to reflow the solder on my AFM sensors based on another SAU guide here, I attempted to disassemble the silicone seal on the back of the sensor to see what happened inside the sensor; turns out, it basically disintegrated itself. Wonderful. Not only had the electrical components destroyed themselves, the magnetic portion on what I thought was on the shaft also chipped and was broken. Solution So solution: find a spare part right? Wrong. Nissan has long discontinued the proper sensor part number 32702-21U19, and it is no longer obtainable either through Nissan NSA or Nissan Japan. I was SOL without proper speed or mileage readings unless I figured out a way to replace this sensor. After tons of Googling and searching on SAU, I found that there IS however a sensor that looks almost exactly like the R33/260RS one: a sensor meant for the R33/R34 GTT and GTS-T with the 5 speed manual. The part number was 25010-21U00, and the body, plug, and shaft all looked exactly the same. The gear was different at the end, but knowing the sensor's gear is held on with a circlip, I figured I could just order the part and swap the gears. Cue me ordering a new part from JustJap down in Kirrawee, NSW, then waiting almost 3 weeks for shipping and customs clearing. The part finally arrives and what did I find? The freaking shaft lengths don't match. $&%* I discussed with Erik how to proceed, and figuring that I basically destroyed the sensor trying to get the shaft out of the damaged sensor from my car. we deemed it too dangerous to try and attempt to swap shafts to the correct length. I had to find a local CNC machinist to help me cut and notch down the shaft. After tons of frantic calling on a Friday afternoon, I managed to get hold of someone and he said he'd be able to do it over half a week. I sent him photos and had him take measurements to match not only the correct length and notch fitment, but also a groove to machine out to hold the retentive circlip. And the end result? *chef's kiss* Perfect. Since I didn't have pliers with me when I picked up the items, I tested the old gear and circlip on. Perfect fit. After that it was simply swapping out the plug bracket to the new sensor, mount it on the transfer case, refill with ATF/Nissan Matic Fluid D, then test out function. Thankfully with the rebuilt cluster and the new sensor, both the speedometer and odometer and now working properly!   And there you have it. About 5-6 weeks of headaches wrapped up in a 15 minute photo essay. As I was told it is rare for sensors of this generation to die so dramatically, but you never know what could go wrong with a 25+ year old car. I HOPE that no one else has to go through this problem like I did, so with my take on a solution I hope it helps others who may encounter this issue in the future. For the TL;DR: 1) Sensor breaks. 2) Find a replacement GTT/GTS-T sensor. 3) Find a CNC machinist to have you cut it down to proper specs. 4) Reinstall then pray to the JDM gods.   Hope this guide/story helps anyone else encountering this problem!
    • perhaps i should have mentioned, I plugged the unit in before i handed over to the electronics repair shop to see what damaged had been caused and the unit worked (ac controls, rear demister etc) bar the lights behind the lcd. i would assume that the diode was only to control lighting and didnt harm anything else i got the unit back from the electronics repair shop and all is well (to a point). The lights are back on and ac controls are working. im still paranoid as i beleive the repairer just put in any zener diode he could find and admitted asking chatgpt if its compatible   i do however have another issue... sometimes when i turn the ignition on, the climate control unit now goes through a diagnostics procedure which normally occurs when you disconnect and reconnect but this may be due to the below   to top everything off, and feel free to shoot me as im just about to do it myself anyway, while i was checking the newly repaired board by plugging in the climate control unit bare without the housing, i believe i may have shorted it on the headunit surround. Climate control unit still works but now the keyless entry doesnt work along with the dome light not turning on when you open the door. to add to this tricky situation, when you start the car and remove the key ( i have a turbo timer so car remains on) the keyless entry works. the dome light also works when you switch to the on position. fuses were checked and all ok ive deduced that the short somehow has messed with the smart entry control module as that is what controls the keyless entry and dome light on door opening   you guys wouldnt happen to have any experience with that topic lmao... im only laughing as its all i can do right now my self diagnosed adhd always gets me in a situation as i have no patience and want to get everything done in shortest amount of time as possible often ignoring crucial steps such as disconnecting battery when stuffing around with electronics or even placing a simple rag over the metallic headunit surround when placing a live pcb board on top of it   FML
×
×
  • Create New...