Jump to content
SAU Community

Recommended Posts

Hey all,

Had my RB25 exhaust manifold repaired recently (broken stud) and a boost leak resolved.

But with the boost cranked to about 8-9psi i find there's no 'kick' and less response when i floor it. It used to launch hard before, but since the boost leak began and even after repair, the power has not returned.

My mechanic said i need to fix my timing. I.E. get an ECU retune/piggyback/PFC?

If it helps, my boost gauge under-reads at idle. It used to sit on -0.5 BAR all the time, but since then it's always sagged less than that. Even AFTER the repairs.

Any recommendations here?

Cheers :)

Link to comment
https://www.sau.com.au/forums/topic/199494-lazy-r33/
Share on other sites

"Had my RB25 exhaust manifold repaired recently (broken stud) and a boost leak resolved."

"My mechanic said i need to fix my timing. I.E. get an ECU retune/piggyback/PFC?"

Howdy R338OY,

Even someone with the most basic mechanical logic would be scratching their head at what your mechanic has suggested!

You told us that it went in for a basic stud replacement and to resolve a boost leak, however prior to this the car performed well. Now the stud is repaired but the car doesn't "go". All the mechanic can suggest is that if you want it to go again, you have to alter your timing and buy a replacement ECU!?????

Here are two suggestions for a start:

1/ NEVER go back to this mechanic.

2/ Let us know what area you live in and someone from the forums could suggest a REAL mechanic in the vicinity that can quickly diagnose your car and get it sorted once and for all.

I can't see, based on the repairs you had done, how the problems you were experiencing have anything to do with a fault in your ECU or your timing, otherwise your car would never have driven properly in the first place. Besides, the repairs you had done would have been accomplished without the need to touch either the ECU or timing.

The first thing that springs to mind from my limited knowledge together with the explanation you've given, is that there could potentially be a vacuum problem. If this fool has accidentally disconnected/crimped/blocked a vacuum line as a result of his fooling around, it could be messing with your wastegate actuation or the ECU could be responding to a lack of vacuum elsewhere and its interpretation of this could inadvertantly be causing the poor performance.

Have someone who knows what they're doing check out all of your vacuum lines first. It could potentially be the quickest, easiest and cheapest fix. If this isn't the problem, then work through the basics as there would be a simple explanation for this and it should be directly related to the repairs that were performed. By fixing the stud, the mechanic may have had to remove the entire manifold, which of course has the turbo and exhaust attached. If he has reassembed this incorrectly or forgotten to reattach something, the car could perform poorly as you would expect.

Don't look at anything else until you've checked these BASICS first (vacuum lines, sensor connections, mechanical connections..etc).

Hope that this has been of some help.

Cheers, Mike

Link to comment
https://www.sau.com.au/forums/topic/199494-lazy-r33/#findComment-3555733
Share on other sites

Thanks for the responses fellas.

Yes i'm no expert, but i always thought the wastegate/actuator had an issue with building boost pressure. That's just the feel i get from driving it. It makes full boost but is lazy from low RPM's, i.e. it used to 'launch' when i floored it, now it's not that responsive. I can feel the lack of pressure from mid-->high RPM's too so it's obviously a small percentage of power being lost, but affects overall performance.

I'm sure it's not a complex problem. I'm going to have someone diagnose the issue, and someone who knows what they're talking about :devil: .

Cheers

Link to comment
https://www.sau.com.au/forums/topic/199494-lazy-r33/#findComment-3556022
Share on other sites

hey guys im new to driving skylines as i have bought my first just recently (r33 gtst s1). the one thing i need to do is replace the exhaust manifold, but i need some advice as i dont want mine to lose power after some mechanic plays with it.

1st question is should i go all out and get an aftermarket manifold such as a hks one or just replace it with stock?

2nd question is could any1 give me an idea of how to replace it myslef?

thanks in advance!

ps... good luck with fixing the problem R3380Y

Link to comment
https://www.sau.com.au/forums/topic/199494-lazy-r33/#findComment-3556197
Share on other sites

hey guys im new to driving skylines as i have bought my first just recently (r33 gtst s1). the one thing i need to do is replace the exhaust manifold, but i need some advice as i dont want mine to lose power after some mechanic plays with it.

1st question is should i go all out and get an aftermarket manifold such as a hks one or just replace it with stock?

2nd question is could any1 give me an idea of how to replace it myslef?

thanks in advance!

ps... good luck with fixing the problem R3380Y

IMO you need a mechanic to replace it if you're not experienced. The mechanic took pics of mine and there's all these wierd studs to move, and you need to know how to remove the turbo, plus intercooler piping, without damaging anything. Plus if you do up the manifold studs too tight they can break off and you're screwed again.

From what i know the stock manifold is top stuff for being stock, and you won't need an expensive HKS one unless you want to A) Run massive boost B) Install something lighter. It's effective and solid.

r33boy, maybe check the tension in the wastegate actuator.

How do i check it? Thanks for the advice.

Link to comment
https://www.sau.com.au/forums/topic/199494-lazy-r33/#findComment-3556774
Share on other sites

I would disconnect the wastegate arm from the flap pivot on the exhaust housing, you need to check 2 things, the preload(how far you have to pull the "arm " out of the wastgate can to hook it on) it should be about 2mm. The other thing to check is the tension of the spring in the wastegate can, pull the arm away from the can, you should be able to move it 12-15mm but it should be quite hard to do so. Some other potontial problems with the wastegate can be a badly cracked exhaust housing/wastegate flap or a wastgate flap not seating properly, all these problems will cause slow boost build.

Link to comment
https://www.sau.com.au/forums/topic/199494-lazy-r33/#findComment-3556800
Share on other sites

lol you need a mechanic to take a turbo off and intercooler piping what a joke

The dude i replied to just bought his Skyline. Not everyone is as expertly experienced as you mate so, like i did, give out sensible advice that will help other drivers maintain their cars.

I would disconnect the wastegate arm from the flap pivot on the exhaust housing, you need to check 2 things, the preload(how far you have to pull the "arm " out of the wastgate can to hook it on) it should be about 2mm. The other thing to check is the tension of the spring in the wastegate can, pull the arm away from the can, you should be able to move it 12-15mm but it should be quite hard to do so. Some other potontial problems with the wastegate can be a badly cracked exhaust housing/wastegate flap or a wastgate flap not seating properly, all these problems will cause slow boost build.

Thanks for the explanation, i'm going to investigate it asap and forever bury this problem! :D

Link to comment
https://www.sau.com.au/forums/topic/199494-lazy-r33/#findComment-3556835
Share on other sites

hey guys im new to driving skylines as i have bought my first just recently (r33 gtst s1). the one thing i need to do is replace the exhaust manifold, but i need some advice as i dont want mine to lose power after some mechanic plays with it.

1st question is should i go all out and get an aftermarket manifold such as a hks one or just replace it with stock?

2nd question is could any1 give me an idea of how to replace it myslef?

thanks in advance!

ps... good luck with fixing the problem R3380Y

use a stock manifold making sure it aint cracked and change it yourself, its not that hard.

locate manifold and remove. replace manifold, if your worried about breaking studs use a torque wrench ($50). just be gentle don't use to much force on anything.

Make sure you are careful undoing the manifold as this is when you are more likely to break studs. use alot of wd40 when engine is cold and do a couple of time over 30mins to let it soak in before undoing the manifold...

you will learn alot and feel good when you finish and if you stuff up or studs break you will learn more... all good...

Link to comment
https://www.sau.com.au/forums/topic/199494-lazy-r33/#findComment-3556845
Share on other sites

you will learn alot and feel good when you finish and if you stuff up or studs break you will learn more... all good...

Don't break the studs. If you're that unlucky you'll have to get the stud drilled out (as was done to mine) and there aren't many thread-drillers in Sydney. If you need a contact for someone to drill a broken stud i have a number you can call.

A fresh manifold gave me a massive improvement to building boost.

Link to comment
https://www.sau.com.au/forums/topic/199494-lazy-r33/#findComment-3557424
Share on other sites

Create an account or sign in to comment

You need to be a member in order to leave a comment

Create an account

Sign up for a new account in our community. It's easy!

Register a new account

Sign in

Already have an account? Sign in here.

Sign In Now


  • Similar Content

  • Latest Posts

    • I did end up getting it sorted, as GTSBoy said, there was a corroded connection and wire that needed to be replaced. I ended up taking out the light assembly, giving everything a good clean and re-soldered the old joints, and it came out good.
    • Wow, thanks for your help guys 🙏. I really appreciate it. Thanks @Rezz, if i fail finding any new or used, full or partial set of original Stage carpets i will come back to you for sure 😉 Explenation is right there, i just missed it 🤦‍♂️. Thanks for pointing out. @soviet_merlin in the meantime, I received a reply from nengun, and i quote: "Thanks for your message and interest in Nengun. KG4900 is for the full set of floor mats, while KG4911 is only the Driver's Floor Mat. FR, RH means Front Right Hand Side. All the Full Set options are now discontinued. However, the Driver's Floor Mat options are still available according to the latest information available to us. We do not know what the differences would be, but if you only want the one mat, we can certainly see what we can find out for you". Interesting. It seems they still have some "new old stock" that Duncan mentioned 🤔. I wonder if they can provide any photos......And i also just realized that amayama have G4900 sets. I'm tempted too. 
    • Any update on this one? did you manage to get it fixed?    i'm having the same issue with my r34 and i believe its to do with the smart entry (keyless) control module but cant be sure without forking out to get a replacement  
    • So this being my first contribution to the SAU forums, I'd like to present and show how I had to solve probably one of the most annoying fixes on any car I've owned: replacing a speedometer (or "speedo") sensor on my newly acquired Series 1 Stagea 260RS Autech Version. I'm simply documenting how I went about to fix this issue, and as I understand it is relatively rare to happen to this generation of cars, it is a gigantic PITA so I hope this helps serve as reference to anyone else who may encounter this issue. NOTE: Although I say this is meant for the 260RS, because the gearbox/drivetrain is shared with the R33 GTR with the 5-speed manual, the application should be exactly the same. Background So after driving my new-to-me Stagea for about 1500km, one night while driving home the speedometer and odometer suddenly stopped working. No clunking noise, no indication something was broken, the speedometer would just stop reading anything and the odometer stopped going up. This is a huge worry for me, because my car is relatively low mileage (only 45k km when purchased) so although I plan to own the car for a long time, a mismatched odometer reading would be hugely detrimental to resale should the day come to sell the car. Thankfully this only occurred a mile or two from home so it wasn't extremely significant. Also, the OCD part of me would be extremely irked if the numbers that showed on my dash doesn't match the actual ageing of the car. Diagnosing I had been in communication with the well renown GTR shop in the USA, U.P.garage up near University Point in Washington state. After some back and forth they said it could be one of two things: 1) The speedometer sensor that goes into the transfer case is broken 2) The actual cluster has a component that went kaput. They said this is common in older Nissan gauge clusters and that would indicate a rebuild is necessary. As I tried to figure out if it was problem #1, I resolved problem #2 by sending my cluster over to Relentless Motorsports in Dallas, TX, whom is local to me and does cluster and ECU rebuilds. He is a one man operation who meticulously replaces every chip, resistor, capacitor, and electronic component on the PCB's on a wide variety of classic and modern cars. His specialty is Lexus and Toyota, but he came highly recommended by Erik of U.P.garage since he does the rebuilds for them on GTR clusters.  For those that don't know, on R32 and R33 GTR gearboxes, the speedometer sensor is mounted in the transfer case and is purely an analog mini "generator" (opposite of an alternator essentially). Based on the speed the sensor spins it generates an AC sine wave voltage up to 5V, and sends that via two wires up to the cluster which then interprets it via the speedometer dial. The signal does NOT go to the ECU first, the wiring goes to the cluster first then the ECU after (or so I'm told).  Problems/Roadblocks I first removed the part from the car on the underside of the transfer case (drain your transfer case fluid/ATF first, guess who found out that the hard way?), and noted the transfer case fluid was EXTREMELY black, most likely never changed on my car. When attempting to turn the gears it felt extremely gritty, as if something was binding the shaft from rotating properly. I got absolutely no voltage reading out of the sensor no matter how fast I turned the shaft. After having to reflow the solder on my AFM sensors based on another SAU guide here, I attempted to disassemble the silicone seal on the back of the sensor to see what happened inside the sensor; turns out, it basically disintegrated itself. Wonderful. Not only had the electrical components destroyed themselves, the magnetic portion on what I thought was on the shaft also chipped and was broken. Solution So solution: find a spare part right? Wrong. Nissan has long discontinued the proper sensor part number 32702-21U19, and it is no longer obtainable either through Nissan NSA or Nissan Japan. I was SOL without proper speed or mileage readings unless I figured out a way to replace this sensor. After tons of Googling and searching on SAU, I found that there IS however a sensor that looks almost exactly like the R33/260RS one: a sensor meant for the R33/R34 GTT and GTS-T with the 5 speed manual. The part number was 25010-21U00, and the body, plug, and shaft all looked exactly the same. The gear was different at the end, but knowing the sensor's gear is held on with a circlip, I figured I could just order the part and swap the gears. Cue me ordering a new part from JustJap down in Kirrawee, NSW, then waiting almost 3 weeks for shipping and customs clearing. The part finally arrives and what did I find? The freaking shaft lengths don't match. $&%* I discussed with Erik how to proceed, and figuring that I basically destroyed the sensor trying to get the shaft out of the damaged sensor from my car. we deemed it too dangerous to try and attempt to swap shafts to the correct length. I had to find a local CNC machinist to help me cut and notch down the shaft. After tons of frantic calling on a Friday afternoon, I managed to get hold of someone and he said he'd be able to do it over half a week. I sent him photos and had him take measurements to match not only the correct length and notch fitment, but also a groove to machine out to hold the retentive circlip. And the end result? *chef's kiss* Perfect. Since I didn't have pliers with me when I picked up the items, I tested the old gear and circlip on. Perfect fit. After that it was simply swapping out the plug bracket to the new sensor, mount it on the transfer case, refill with ATF/Nissan Matic Fluid D, then test out function. Thankfully with the rebuilt cluster and the new sensor, both the speedometer and odometer and now working properly!   And there you have it. About 5-6 weeks of headaches wrapped up in a 15 minute photo essay. As I was told it is rare for sensors of this generation to die so dramatically, but you never know what could go wrong with a 25+ year old car. I HOPE that no one else has to go through this problem like I did, so with my take on a solution I hope it helps others who may encounter this issue in the future. For the TL;DR: 1) Sensor breaks. 2) Find a replacement GTT/GTS-T sensor. 3) Find a CNC machinist to have you cut it down to proper specs. 4) Reinstall then pray to the JDM gods.   Hope this guide/story helps anyone else encountering this problem!
    • So this being my first contribution to the SAU forums, I'd like to present and show how I had to solve probably one of the most annoying fixes on any car I've owned: replacing a speedometer (or "speedo") sensor on my newly acquired Series 1 Stagea 260RS Autech Version. I'm simply documenting how I went about to fix this issue, and as I understand it is relatively rare to happen to this generation of cars, it is a gigantic PITA so I hope this helps serve as reference to anyone else who may encounter this issue. NOTE: Although I say this is meant for the 260RS, because the gearbox/drivetrain is shared with the R33 GTR with the 5-speed manual, the application should be exactly the same. Background So after driving my new-to-me Stagea for about 1500km, one night while driving home the speedometer and odometer suddenly stopped working. No clunking noise, no indication something was broken, the speedometer would just stop reading anything and the odometer stopped going up. This is a huge worry for me, because my car is relatively low mileage (only 45k km when purchased) so although I plan to own the car for a long time, a mismatched odometer reading would be hugely detrimental to resale should the day come to sell the car. Thankfully this only occurred a mile or two from home so it wasn't extremely significant. Also, the OCD part of me would be extremely irked if the numbers that showed on my dash doesn't match the actual ageing of the car. Diagnosing I had been in communication with the well renown GTR shop in the USA, U.P.garage up near University Point in Washington state. After some back and forth they said it could be one of two things: 1) The speedometer sensor that goes into the transfer case is broken 2) The actual cluster has a component that went kaput. They said this is common in older Nissan gauge clusters and that would indicate a rebuild is necessary. As I tried to figure out if it was problem #1, I resolved problem #2 by sending my cluster over to Relentless Motorsports in Dallas, TX, whom is local to me and does cluster and ECU rebuilds. He is a one man operation who meticulously replaces every chip, resistor, capacitor, and electronic component on the PCB's on a wide variety of classic and modern cars. His specialty is Lexus and Toyota, but he came highly recommended by Erik of U.P.garage since he does the rebuilds for them on GTR clusters.  For those that don't know, on R32 and R33 GTR gearboxes, the speedometer sensor is mounted in the transfer case and is purely an analog mini "generator" (opposite of an alternator essentially). Based on the speed the sensor spins it generates an AC sine wave voltage up to 5V, and sends that via two wires up to the cluster which then interprets it via the speedometer dial. The signal does NOT go to the ECU first, the wiring goes to the cluster first then the ECU after (or so I'm told).  Problems/Roadblocks I first removed the part from the car on the underside of the transfer case (drain your transfer case fluid/ATF first, guess who found out that the hard way?), and noted the transfer case fluid was EXTREMELY black, most likely never changed on my car. When attempting to turn the gears it felt extremely gritty, as if shttps://imgur.com/6TQCG3xomething was binding the shaft from rotating properly. After having to reflow the solder on my AFM sensors based on another SAU guide here, I attempted to disassemble the silicone seal on the back of the sensor to see what happened inside the sensor; turns out, it basically disintegrated itself. Wonderful. Not only had the electrical components destroyed themselves, the magnetic portion on what I thought was on the shaft also chipped and was broken. Solution So solution: find a spare part right? Wrong. Nissan has long discontinued the proper sensor part number 32702-21U19, and it is no longer obtainable either through Nissan NSA or Nissan Japan. I was SOL without proper speed or mileage readings unless I figured out a way to replace this sensor. After tons of Googling and searching on SAU, I found that there IS however a sensor that looks almost exactly like the R33/260RS one: a sensor meant for the R33/R34 GTT and GTS-T with the 5 speed manual. The part number was 25010-21U00, and the body, plug, and shaft all looked exactly the same. The gear was different at the end, but knowing the sensor's gear is held on with a circlip, I figured I could just order the part and swap the gears. Cue me ordering a new part from JustJap down in Kirrawee, NSW, then waiting almost 3 weeks for shipping and customs clearing. The part finally arrives and what did I find? The freaking shaft lengths don't match. $&%* I discussed with Erik how to proceed, and figuring that I basically destroyed the sensor trying to get the shaft out of the damaged sensor from my car. we deemed it too dangerous to try and attempt to swap shafts to the correct length. I had to find a local CNC machinist to help me cut and notch down the shaft. After tons of frantic calling on a Friday afternoon, I managed to get hold of someone and he said he'd be able to do it over half a week. I sent him photos and had him take measurements to match not only the correct length and notch fitment, but also a groove to machine out to hold the retentive circlip. And the end result? *chef's kiss* Perfect. Since I didn't have pliers with me when I picked up the items, I tested the old gear and circlip on. Perfect fit. After that it was simply swapping out the plug bracket to the new sensor, mount it on the transfer case, refill with ATF/Nissan Matic Fluid D, then test out function. Thankfully with the rebuilt cluster and the new sensor, both the speedometer and odometer and now working properly!   And there you have it. About 5-6 weeks of headaches wrapped up in a 15 minute photo essay. As I was told it is rare for sensors of this generation to die so dramatically, but you never know what could go wrong with a 25+ year old car. I HOPE that no one else has to go through this problem like I did, so with my take on a solution I hope it helps others who may encounter this issue in the future. For the TL;DR: 1) Sensor breaks. 2) Find a replacement GTT/GTS-T sensor. 3) Find a CNC machinist to have you cut it down to proper specs. 4) Reinstall then pray to the JDM gods.   Hope this guide/story helps anyone else encountering this problem!
×
×
  • Create New...