Jump to content
SAU Community

Gt35r Vs Garrett T04z - Discussion (just Post In This Thread To Create A Database)


Recommended Posts

  • 2 weeks later...

Hi all!

Thought I'd post my results in here to keep the intent of the thread going ;-)

The GT3582 is bolted up!

This is pretty much stage 1 out of about 3 so I'm happy that the car actually drives the way it does. The only things that have been changed from stock so far are:

- exhaust mani (offcourse)

- oil and water lines (braided)

- 2 into 1 air intake

- rising rate regulator

So yeah, no cams, no ecu and no fuel pressure mods (which are the next steps)

With out changing any of the timing or resetting the ECU etc, the car happily made 304hp at the rear on 15 pounds. Everything looked safe on the dyno computer but I do want to get a bigger pump and also a ECU asap!

So that's all good news, but there is some bad too. The car only runs well when you up it...it boosts very hard and pushes you back quite nicely when the turbine kicks in just after the 4300rpm mark however, the car runs a bit rough on idle and also when coasting around in 60km/h traffic. It's ever so slightly noticeable. It also has a fairly rough idle....not bad, but just a bit rougher than a normal GTR's idle.

So that's a GT3582 without any supporting mods. Stage 1 out of 3. It boosts hard, goes like a rocket but on the downside it's a bit rough when driven gently as a daily. The best way to describe it is, imagine the A/C kicking in and out continuously...lol!

Obviously there are many more dyno tunes involved with a PFC or something similar....but these are my "better than I thought" results for now. I never expected it to drive at all to be honest.

Well this was only a tune up to get the car out of the work shop. It was also done on a 2 wheel dyno and not even to full rpm range - just a quick squirt if you know what I mean. It will be getting a PFC and bigger pump this week which should see much better figures at the same level of boost. Then after that there should be better figures again with the cams but still running same boost.

Dunno about 300rwkw on a stock engine without any supporting mods lol! You realise how much that is?

This is simply the results of what happen when you slap a GT3582r onto a factory bog stock (except exhaust) RB26 that has 70,000km on it.

Maybe would have had better results with a set of N1's - they would work better with the factory tune and cams.

Also, it was insanely hot in the shed they done the dyno in - the car went a lot better during the night than it did during lunch when I picked it up.

But yeh mate, just sharing results. Very early results, for those who may be reading who too are considering a GT3582.

Oh, and I should also mention that I'm glad I didn't go for the T04z! Some say it's up to 800rpm laggier than a GT3582 - I don't know how you're meant to drive that!

Your better off holding out untill the thing is properly tuned before making any judgements. We did a similar thing with mine just to get it running and out of the workshop and the difference is day and night. I would recommend straight fit cams before the final tune to really wake it up.

btw I'd agree with cerbera, around 400hp at 1bar is about right.

Your better off holding out untill the thing is properly tuned before making any judgements. We did a similar thing with mine just to get it running and out of the workshop and the difference is day and night. I would recommend straight fit cams before the final tune to really wake it up.

btw I'd agree with cerbera, around 400hp at 1bar is about right.

Well the GT35 shifts a lot more air than the two stockies at the same pressure so there should be some more mumbo there once it's tuned properly. Right now it's 300hp at the rear so you think around 400hp would be more like it?

Maybe this 300hp is around the limit of the stock CAMs, ECU and fuel support combination? When you start replacing certain items the power should climb under the same boost.

Dcieve, did you have an aftermarket computer at that time or did you do exactly the same thing as me? ie. slap turbo on, check that mixtures are safe, and then drive off?

Also, should I be expecting 400rwhp in it's current state where everything is stock? Will the cams and ECU deliver this with 1 Bar? Or are you saying that once I put the cams in that then it will deliver the 400 at 1 bar? I think that's what you mean :P

Thanks for the replies by the way - this is pretty much the criticism I'm after to see if my money is getting well spent.

Well the GT35 shifts a lot more air than the two stockies at the same pressure so there should be some more mumbo there once it's tuned properly. Right now it's 300hp at the rear so you think around 400hp would be more like it?

Maybe this 300hp is around the limit of the stock CAMs, ECU and fuel support combination? When you start replacing certain items the power should climb under the same boost.

Dcieve, did you have an aftermarket computer at that time or did you do exactly the same thing as me? ie. slap turbo on, check that mixtures are safe, and then drive off?

Also, should I be expecting 400rwhp in it's current state where everything is stock? Will the cams and ECU deliver this with 1 Bar? Or are you saying that once I put the cams in that then it will deliver the 400 at 1 bar? I think that's what you mean :(

Thanks for the replies by the way - this is pretty much the criticism I'm after to see if my money is getting well spent.

cams, injectors and fuel pump will be good for 300rwkw but starting to run out of injector duty and pump flow, cams will still be fine well above this power...

seriously you should be getting a aftermarket computer and tune before you even think about making assumptions on performance!

no tune could cause a serious engine failure as well, get it tuned asap and dont thrash it before you do

Edited by Cerbera
cams, injectors and fuel pump will be good for 300rwkw but starting to run out of injector duty and pump flow, cams will still be fine well above this power...

seriously you should be getting a aftermarket computer and tune before you even think about making assumptions on performance!

no tune could cause a serious engine failure as well, get it tuned asap and dont thrash it before you do

No problem. My tuner has recommended PFC and pump as the immediate things that need doing. Currently I'm not even driving my car to work as it runs pretty rough in traffic. When you're on very light throttle it feels like the A/C is kicking in and out repetitively. So yes, the car's locked up till I can get the computer and tuning sessions.

VspecR33, I'm actually Tom mate...Tomek is another guy on here.

The car will be used for track work but also as a daily driver (to some extent). I'm hoping to get a shitbox to drive to work ;-)

VspecR33, I'm actually Tom mate...Tomek is another guy on here.

The car will be used for track work but also as a daily driver (to some extent). I'm hoping to get a shitbox to drive to work ;-)

Sorry i got lost in the thread somewhere there..

No problem. My tuner has recommended PFC and pump as the immediate things that need doing. Currently I'm not even driving my car to work as it runs pretty rough in traffic. When you're on very light throttle it feels like the A/C is kicking in and out repetitively. So yes, the car's locked up till I can get the computer and tuning sessions.

It shouldnt be detonating with a stock ecu, the risk is that it might be running lean. It will need 2-4 degrees more advance across the entire base map when on boost compared to a stock PFC base map, and it will tolerate about 1.5 degrees additional advance per 1000rpm after peak torque around the 5500 RPM mark because of reduced EGT's and colder air charge because of the more efficent turbo (compared to stock that is).

The rising rate reg will likely be making it too when on boost as well. While it sort of works now these can make the car a pain in the ass to tune when you get the PFC in there. Getting it to maintain a steady 12:1 afr can be nearly impossible from my experiences. They arent very linear in operation, and when you are running above 1 bar of boost your fuel pressures get eratic and very high. Consider 43.5psi base pressure + (manifold pressure x2). Fuel pressures approaching 80psi slow down fuel flow from the pump too, load it up and heat your fuel up a lot. You can run out of fuel flow in top end.

Your going to be much better off with some larger injectors and a standard regulator and larger pump. Add a fuel cooler on your return line before it returns to the tank too if your running an 044/040 pump.

Also, if you have cam gears try running 2 degrees advance on the intake and 4 degrees retard on the exhaust. You should see quite a diference in the response and top end. It workd really well on my 33 GTR.

Keep us informed with the progress. Its good seeing someone doing what many of us have wanted to try but due to lack of available information we havent been brave enough to take the plunge. Id have liked to see the 0.63 turbine version of the GT35 tried as well, to try and overcome the lazyness of the GT3582.

Cheers

Hey, thanks for your reply! This is the sorta info that I've been hoping for ;-)

Ok, so I'll be able to to a fair few timing adjustments when I have the PFC installed but right now, without adjustable cam gears, it would be a bit hard to do right? I've read that you can make the factory gears adjustable, but at a cost. There's nothing I can do now, or? (Bog stock remember)

Well I believe that he put the rising rate regulator in there to deal with the fuel at the high end of the tacho. With it's current level of tune (poor) you'd probably prefer to gave a safe/rich A/F mixture at the high end - at least it won't go kaboom then! He admitted that he hasn't dealt with GTR's as stock as mine before - most having at least 500rwhp when they rock up at his work shop. I don't think he's ever seen a fully stock engine bay like mine in a very long time.

So, for now I should be looking at:

- pump (which, apparantly is flowing a bit weak but not dangerously low)

- Power FC to get timing under control and to suit the more efficient turbine

- adjustable cam gears?

- bigger injectors so that there's room for tolerance (eg knock mode and so forth when they need to open up)

- take out rising rate regulator?

Cheers,

Tom

Since your going circuit racing, id suggest leaving the stock pump in the tank and have it fill a surge tank you can mount in your spare wheel well in the boot. Get a bosch 044 pump to be your main supply pump, and it will draw from the surge tank and return to the tank via a smal fuel cooler (like an alloy transmission fluid cooler.

Adjustable cam gears are definatly worth getting, short of getting a set of pon cams they are the cheapest option. Modifying stock ones is possible but its not as accurate and not tunable when your on the dyno so your stuck with the modified settings and thats it.

Larger injectors have nothing to do with knock. They are simply to flow more fuel. A set of 700cc would be ideal for starters.

For a track car that might see use on hot days you dont want to run your PFC knock at anything above 15. 10-15 would be a good value to aim for. You also want 12:1 AFR's for the entire map where on boost, except for top end (above 6000 rpm) at full load where id suggest 11.8:1 to help keep things a little safer/cooler.

Plug gaps at 0.8mm, not 1.1mm. Just to guarantee the spark wont blow out on the higher boost levels.

Definatly lose the rising rate reg. That will allow you to achieve a good tune. Like i said in the other post, they cause too eratic fuel pressures. The PFC maps are designed to work with correction values for larger injectors but do not factor in non-linear fuel pressure changes.

Talk to a few more tuners familiar witht the FC as well. Im surprised that someone that is "familiar with 500rwhp" cars has recommended a rising rate FPR, especially where up to 1.4-1.5 bar will be run.

With that setup id be surprised if you didnt easily break 450rwhp on a maxed out tune. If the knock is down low it will be relitavely safe too, the danger will be oil surge when its on the track so you will have to take it easy in cornering till you can fit restrictors and an external drain from the head... or just rebuild the engine completely.

VspecR33, I'm actually Tom mate...Tomek is another guy on here.

which started the thread ... :P

speaking of this thread, bottom end is complete, head is back ... 264 in 272 ex

Only finalising oil pump (got an N1, but afraid of using it) before the whole she-bang goes in.. should be able to update in a handful of weeks when motor is run-in and dyno-ed.

BTW 1.06 housing 35R on worked 26...

Tomek

interesting.. with you plans..

throw the rising rate fpr in the bin.. and put the stock one back on.

use a 044 intank. or better use the stock one to feed a surge tank with an 044.

ive used a 040 intank in the standard position in the tank and it cavitated its arse off. would not work once the fuel heated up.

id use a non air flow meter ecu such as a haltech plug in e11 etc etc.

you will need to get some 550cc injectors at a min.. 740's or 1000's would be better.

what ex housing did you use? and what ex manifold?

interesting.. with you plans..

throw the rising rate fpr in the bin.. and put the stock one back on.

use a 044 intank. or better use the stock one to feed a surge tank with an 044.

ive used a 040 intank in the standard position in the tank and it cavitated its arse off. would not work once the fuel heated up.

id use a non air flow meter ecu such as a haltech plug in e11 etc etc.

you will need to get some 550cc injectors at a min.. 740's or 1000's would be better.

what ex housing did you use? and what ex manifold?

T04GTR, I know....my plans seem quite interesting. I'm lucky that it has worked in stages like this.....ok, it may not be driving the best in traffic but it actually drives safely. Just a bit rough, but according to the dyno screen everything else is in safe areas. I hope to have it all going properly by April for a couple of Top Gear races. In the next two weeks it should be re-tuned with pump and cam gears to get it going smooth again and possibly spread the power out a little bit better. Come April, it should be safe to do some racing with it.

I ran the FPR issue past my tuner and he's aware of it. He says this one is quite good but he knows that some of them do spike up and down in fuel pressure as fair bit. I'll ask him about taking it off all together - especially for when the ecu goes in.

When you're saying I should use a 044 intank (which I have in my GTST) do you mean that it's also the 040 that cavitates? Or do you mean 044? The pump in my GTST done that after driving for a while - surged it's ass off! I'll have to check out the surge tank option with a fuel cooler.

Yep, my tuner has recommended 740cc injectors in an earlier quote - they'll go in soon.

The turbo has a .82 housing. I haven't paid exact attention to it - but it seams to kick in between 4500 and 4800. With some adjustable cam gears and ECU where would you be expecting it to kick in then? Would it be a little bit earlier? Remember mine is 2.6L too.

Thanks for your help guys - I'm trying to take it all on board.

The exhaust is a stainless one that cost around $1200.

Edited by tommis85
Since your going circuit racing, id suggest leaving the stock pump in the tank and have it fill a surge tank you can mount in your spare wheel well in the boot. Get a bosch 044 pump to be your main supply pump, and it will draw from the surge tank and return to the tank via a smal fuel cooler (like an alloy transmission fluid cooler.

Adjustable cam gears are definatly worth getting, short of getting a set of pon cams they are the cheapest option. Modifying stock ones is possible but its not as accurate and not tunable when your on the dyno so your stuck with the modified settings and thats it.

Larger injectors have nothing to do with knock. They are simply to flow more fuel. A set of 700cc would be ideal for starters.

For a track car that might see use on hot days you dont want to run your PFC knock at anything above 15. 10-15 would be a good value to aim for. You also want 12:1 AFR's for the entire map where on boost, except for top end (above 6000 rpm) at full load where id suggest 11.8:1 to help keep things a little safer/cooler.

Plug gaps at 0.8mm, not 1.1mm. Just to guarantee the spark wont blow out on the higher boost levels.

Definatly lose the rising rate reg. That will allow you to achieve a good tune. Like i said in the other post, they cause too eratic fuel pressures. The PFC maps are designed to work with correction values for larger injectors but do not factor in non-linear fuel pressure changes.

Talk to a few more tuners familiar witht the FC as well. Im surprised that someone that is "familiar with 500rwhp" cars has recommended a rising rate FPR, especially where up to 1.4-1.5 bar will be run.

With that setup id be surprised if you didnt easily break 450rwhp on a maxed out tune. If the knock is down low it will be relitavely safe too, the danger will be oil surge when its on the track so you will have to take it easy in cornering till you can fit restrictors and an external drain from the head... or just rebuild the engine completely.

Vspec R33, thanks for the info mate - very much appreciated as always. The thing is that I'm not on terribly big budget but nor do I want to take out a loan for the mods. I guess you see a lot of people who have these massive horsepower cars and a sh[t load of money and you wonder how the hell they do it. This is a bit of a reality check. Ideally you'd want to have it all on there at once but I've chosen to span it out over a couple of main stages that should see it complete by around April.

Stage 1: (completed)

Manifold, turbo, braided oil and water lines, fpr, 2 into 1 air intake pipes, turbo to intercooler pipe, stainless dump to 3" system, safe tune

Stage 2:

Fuel pump, adjustable cam gears and re-tune with retardation and advancement as per your recommendations (pump's not providing enough pressure and cam gears would make the car more stable for now)

Stage 3:

Haltec E11 or Power FC plus full tune up

Stage 4:

Intercooler, oil cooler, fuel cooler, splitfire coilpacks.......etc etc

Those are the stages. Obviously it would be most efficient to do them together as it would save money in re-tuning but seeing that it's a daily driver and I'm currently putting up with it's lumpyness (carefully) I have to get the work done progressively. I'm sure there are plenty of people on here in the same boat. Some may be lucky to have a second daily driver so that the project can be left in the garage.

Vspec R33, what do you think of them stages?

Create an account or sign in to comment

You need to be a member in order to leave a comment

Create an account

Sign up for a new account in our community. It's easy!

Register a new account

Sign in

Already have an account? Sign in here.

Sign In Now



  • Latest Posts

    • Wow, thanks for your help guys 🙏. I really appreciate it. Thanks @Rezz, if i fail finding any new or used, full or partial set of original Stage carpets i will come back to you for sure 😉 Explenation is right there, i just missed it 🤦‍♂️. Thanks for pointing out. @soviet_merlin in the meantime, I received a reply from nengun, and i quote: "Thanks for your message and interest in Nengun. KG4900 is for the full set of floor mats, while KG4911 is only the Driver's Floor Mat. FR, RH means Front Right Hand Side. All the Full Set options are now discontinued. However, the Driver's Floor Mat options are still available according to the latest information available to us. We do not know what the differences would be, but if you only want the one mat, we can certainly see what we can find out for you". Interesting. It seems they still have some "new old stock" that Duncan mentioned 🤔. I wonder if they can provide any photos......And i also just realized that amayama have G4900 sets. I'm tempted too. 
    • Any update on this one? did you manage to get it fixed?    i'm having the same issue with my r34 and i believe its to do with the smart entry (keyless) control module but cant be sure without forking out to get a replacement  
    • So this being my first contribution to the SAU forums, I'd like to present and show how I had to solve probably one of the most annoying fixes on any car I've owned: replacing a speedometer (or "speedo") sensor on my newly acquired Series 1 Stagea 260RS Autech Version. I'm simply documenting how I went about to fix this issue, and as I understand it is relatively rare to happen to this generation of cars, it is a gigantic PITA so I hope this helps serve as reference to anyone else who may encounter this issue. NOTE: Although I say this is meant for the 260RS, because the gearbox/drivetrain is shared with the R33 GTR with the 5-speed manual, the application should be exactly the same. Background So after driving my new-to-me Stagea for about 1500km, one night while driving home the speedometer and odometer suddenly stopped working. No clunking noise, no indication something was broken, the speedometer would just stop reading anything and the odometer stopped going up. This is a huge worry for me, because my car is relatively low mileage (only 45k km when purchased) so although I plan to own the car for a long time, a mismatched odometer reading would be hugely detrimental to resale should the day come to sell the car. Thankfully this only occurred a mile or two from home so it wasn't extremely significant. Also, the OCD part of me would be extremely irked if the numbers that showed on my dash doesn't match the actual ageing of the car. Diagnosing I had been in communication with the well renown GTR shop in the USA, U.P.garage up near University Point in Washington state. After some back and forth they said it could be one of two things: 1) The speedometer sensor that goes into the transfer case is broken 2) The actual cluster has a component that went kaput. They said this is common in older Nissan gauge clusters and that would indicate a rebuild is necessary. As I tried to figure out if it was problem #1, I resolved problem #2 by sending my cluster over to Relentless Motorsports in Dallas, TX, whom is local to me and does cluster and ECU rebuilds. He is a one man operation who meticulously replaces every chip, resistor, capacitor, and electronic component on the PCB's on a wide variety of classic and modern cars. His specialty is Lexus and Toyota, but he came highly recommended by Erik of U.P.garage since he does the rebuilds for them on GTR clusters.  For those that don't know, on R32 and R33 GTR gearboxes, the speedometer sensor is mounted in the transfer case and is purely an analog mini "generator" (opposite of an alternator essentially). Based on the speed the sensor spins it generates an AC sine wave voltage up to 5V, and sends that via two wires up to the cluster which then interprets it via the speedometer dial. The signal does NOT go to the ECU first, the wiring goes to the cluster first then the ECU after (or so I'm told).  Problems/Roadblocks I first removed the part from the car on the underside of the transfer case (drain your transfer case fluid/ATF first, guess who found out that the hard way?), and noted the transfer case fluid was EXTREMELY black, most likely never changed on my car. When attempting to turn the gears it felt extremely gritty, as if something was binding the shaft from rotating properly. I got absolutely no voltage reading out of the sensor no matter how fast I turned the shaft. After having to reflow the solder on my AFM sensors based on another SAU guide here, I attempted to disassemble the silicone seal on the back of the sensor to see what happened inside the sensor; turns out, it basically disintegrated itself. Wonderful. Not only had the electrical components destroyed themselves, the magnetic portion on what I thought was on the shaft also chipped and was broken. Solution So solution: find a spare part right? Wrong. Nissan has long discontinued the proper sensor part number 32702-21U19, and it is no longer obtainable either through Nissan NSA or Nissan Japan. I was SOL without proper speed or mileage readings unless I figured out a way to replace this sensor. After tons of Googling and searching on SAU, I found that there IS however a sensor that looks almost exactly like the R33/260RS one: a sensor meant for the R33/R34 GTT and GTS-T with the 5 speed manual. The part number was 25010-21U00, and the body, plug, and shaft all looked exactly the same. The gear was different at the end, but knowing the sensor's gear is held on with a circlip, I figured I could just order the part and swap the gears. Cue me ordering a new part from JustJap down in Kirrawee, NSW, then waiting almost 3 weeks for shipping and customs clearing. The part finally arrives and what did I find? The freaking shaft lengths don't match. $&%* I discussed with Erik how to proceed, and figuring that I basically destroyed the sensor trying to get the shaft out of the damaged sensor from my car. we deemed it too dangerous to try and attempt to swap shafts to the correct length. I had to find a local CNC machinist to help me cut and notch down the shaft. After tons of frantic calling on a Friday afternoon, I managed to get hold of someone and he said he'd be able to do it over half a week. I sent him photos and had him take measurements to match not only the correct length and notch fitment, but also a groove to machine out to hold the retentive circlip. And the end result? *chef's kiss* Perfect. Since I didn't have pliers with me when I picked up the items, I tested the old gear and circlip on. Perfect fit. After that it was simply swapping out the plug bracket to the new sensor, mount it on the transfer case, refill with ATF/Nissan Matic Fluid D, then test out function. Thankfully with the rebuilt cluster and the new sensor, both the speedometer and odometer and now working properly!   And there you have it. About 5-6 weeks of headaches wrapped up in a 15 minute photo essay. As I was told it is rare for sensors of this generation to die so dramatically, but you never know what could go wrong with a 25+ year old car. I HOPE that no one else has to go through this problem like I did, so with my take on a solution I hope it helps others who may encounter this issue in the future. For the TL;DR: 1) Sensor breaks. 2) Find a replacement GTT/GTS-T sensor. 3) Find a CNC machinist to have you cut it down to proper specs. 4) Reinstall then pray to the JDM gods.   Hope this guide/story helps anyone else encountering this problem!
    • So this being my first contribution to the SAU forums, I'd like to present and show how I had to solve probably one of the most annoying fixes on any car I've owned: replacing a speedometer (or "speedo") sensor on my newly acquired Series 1 Stagea 260RS Autech Version. I'm simply documenting how I went about to fix this issue, and as I understand it is relatively rare to happen to this generation of cars, it is a gigantic PITA so I hope this helps serve as reference to anyone else who may encounter this issue. NOTE: Although I say this is meant for the 260RS, because the gearbox/drivetrain is shared with the R33 GTR with the 5-speed manual, the application should be exactly the same. Background So after driving my new-to-me Stagea for about 1500km, one night while driving home the speedometer and odometer suddenly stopped working. No clunking noise, no indication something was broken, the speedometer would just stop reading anything and the odometer stopped going up. This is a huge worry for me, because my car is relatively low mileage (only 45k km when purchased) so although I plan to own the car for a long time, a mismatched odometer reading would be hugely detrimental to resale should the day come to sell the car. Thankfully this only occurred a mile or two from home so it wasn't extremely significant. Also, the OCD part of me would be extremely irked if the numbers that showed on my dash doesn't match the actual ageing of the car. Diagnosing I had been in communication with the well renown GTR shop in the USA, U.P.garage up near University Point in Washington state. After some back and forth they said it could be one of two things: 1) The speedometer sensor that goes into the transfer case is broken 2) The actual cluster has a component that went kaput. They said this is common in older Nissan gauge clusters and that would indicate a rebuild is necessary. As I tried to figure out if it was problem #1, I resolved problem #2 by sending my cluster over to Relentless Motorsports in Dallas, TX, whom is local to me and does cluster and ECU rebuilds. He is a one man operation who meticulously replaces every chip, resistor, capacitor, and electronic component on the PCB's on a wide variety of classic and modern cars. His specialty is Lexus and Toyota, but he came highly recommended by Erik of U.P.garage since he does the rebuilds for them on GTR clusters.  For those that don't know, on R32 and R33 GTR gearboxes, the speedometer sensor is mounted in the transfer case and is purely an analog mini "generator" (opposite of an alternator essentially). Based on the speed the sensor spins it generates an AC sine wave voltage up to 5V, and sends that via two wires up to the cluster which then interprets it via the speedometer dial. The signal does NOT go to the ECU first, the wiring goes to the cluster first then the ECU after (or so I'm told).  Problems/Roadblocks I first removed the part from the car on the underside of the transfer case (drain your transfer case fluid/ATF first, guess who found out that the hard way?), and noted the transfer case fluid was EXTREMELY black, most likely never changed on my car. When attempting to turn the gears it felt extremely gritty, as if shttps://imgur.com/6TQCG3xomething was binding the shaft from rotating properly. After having to reflow the solder on my AFM sensors based on another SAU guide here, I attempted to disassemble the silicone seal on the back of the sensor to see what happened inside the sensor; turns out, it basically disintegrated itself. Wonderful. Not only had the electrical components destroyed themselves, the magnetic portion on what I thought was on the shaft also chipped and was broken. Solution So solution: find a spare part right? Wrong. Nissan has long discontinued the proper sensor part number 32702-21U19, and it is no longer obtainable either through Nissan NSA or Nissan Japan. I was SOL without proper speed or mileage readings unless I figured out a way to replace this sensor. After tons of Googling and searching on SAU, I found that there IS however a sensor that looks almost exactly like the R33/260RS one: a sensor meant for the R33/R34 GTT and GTS-T with the 5 speed manual. The part number was 25010-21U00, and the body, plug, and shaft all looked exactly the same. The gear was different at the end, but knowing the sensor's gear is held on with a circlip, I figured I could just order the part and swap the gears. Cue me ordering a new part from JustJap down in Kirrawee, NSW, then waiting almost 3 weeks for shipping and customs clearing. The part finally arrives and what did I find? The freaking shaft lengths don't match. $&%* I discussed with Erik how to proceed, and figuring that I basically destroyed the sensor trying to get the shaft out of the damaged sensor from my car. we deemed it too dangerous to try and attempt to swap shafts to the correct length. I had to find a local CNC machinist to help me cut and notch down the shaft. After tons of frantic calling on a Friday afternoon, I managed to get hold of someone and he said he'd be able to do it over half a week. I sent him photos and had him take measurements to match not only the correct length and notch fitment, but also a groove to machine out to hold the retentive circlip. And the end result? *chef's kiss* Perfect. Since I didn't have pliers with me when I picked up the items, I tested the old gear and circlip on. Perfect fit. After that it was simply swapping out the plug bracket to the new sensor, mount it on the transfer case, refill with ATF/Nissan Matic Fluid D, then test out function. Thankfully with the rebuilt cluster and the new sensor, both the speedometer and odometer and now working properly!   And there you have it. About 5-6 weeks of headaches wrapped up in a 15 minute photo essay. As I was told it is rare for sensors of this generation to die so dramatically, but you never know what could go wrong with a 25+ year old car. I HOPE that no one else has to go through this problem like I did, so with my take on a solution I hope it helps others who may encounter this issue in the future. For the TL;DR: 1) Sensor breaks. 2) Find a replacement GTT/GTS-T sensor. 3) Find a CNC machinist to have you cut it down to proper specs. 4) Reinstall then pray to the JDM gods.   Hope this guide/story helps anyone else encountering this problem!
    • perhaps i should have mentioned, I plugged the unit in before i handed over to the electronics repair shop to see what damaged had been caused and the unit worked (ac controls, rear demister etc) bar the lights behind the lcd. i would assume that the diode was only to control lighting and didnt harm anything else i got the unit back from the electronics repair shop and all is well (to a point). The lights are back on and ac controls are working. im still paranoid as i beleive the repairer just put in any zener diode he could find and admitted asking chatgpt if its compatible   i do however have another issue... sometimes when i turn the ignition on, the climate control unit now goes through a diagnostics procedure which normally occurs when you disconnect and reconnect but this may be due to the below   to top everything off, and feel free to shoot me as im just about to do it myself anyway, while i was checking the newly repaired board by plugging in the climate control unit bare without the housing, i believe i may have shorted it on the headunit surround. Climate control unit still works but now the keyless entry doesnt work along with the dome light not turning on when you open the door. to add to this tricky situation, when you start the car and remove the key ( i have a turbo timer so car remains on) the keyless entry works. the dome light also works when you switch to the on position. fuses were checked and all ok ive deduced that the short somehow has messed with the smart entry control module as that is what controls the keyless entry and dome light on door opening   you guys wouldnt happen to have any experience with that topic lmao... im only laughing as its all i can do right now my self diagnosed adhd always gets me in a situation as i have no patience and want to get everything done in shortest amount of time as possible often ignoring crucial steps such as disconnecting battery when stuffing around with electronics or even placing a simple rag over the metallic headunit surround when placing a live pcb board on top of it   FML
×
×
  • Create New...