Jump to content
SAU Community

Recommended Posts

I have a HKS cast low mount exhaust manifold and hks t300s turbo that i'm trying to fit on my RB20DET at the moment but seem to be having trouble. The turbo is fouling on the engine mount.

Has anyone else used a setup like this on an RB20? The setup originally came from an RB25DET in an R32 (BHDaves car) so i assumed i should have been able to put it on without too many dramas?

I was trying to put the turbo and manifold in as one piece to make things easier, do i have to put the manifold on and then bolt the turbo up? It didn't seem like that would have made it any easier but i dunno... :)

Link to comment
https://www.sau.com.au/forums/topic/257741-hks-low-mount-mainfold-and-turbo/
Share on other sites

Yeah... physically the turbo is around the same size as a 3576r i think...

So when you say dremel... am i just dremelling the parts of engine mount that are in the way? How much has to be cut out?

dremel been there done that twice now with hks cast manifolds

must be decent sized turbo i.e to4r etc

the front housing is about the same size as my 35r's .70

Do you just dremel the useless looking alloy bit or the actual mount? looks like its gonna be a task putting some piping on the 4" intake where its sitting..

Depends what mounts he was using, i know RB25 and RB26 mounts are interchangable, but not actually the same as my RB26 now sits very low in my engine bay using 26 mounts as opposed to my RB25 using 25 mounts

Maybe its a sign you shouldnt put a T300 on a RB20? :)

The engine side mount itself only needed a couple of taps with a hammer to clear the housing. The rubber bit needed the heat shield (?) removed and there's a fairly chunky bit of metal that wraps around from the base up the side that doesn't attach to anything, that has to be ground off. And on the cross member side just grind/bash away until it clears.

I used rb20 mounts

And you do need to install the turbo on the car unfortunately, though i did figure out when a stud stripped on the turbo/manifold flange that if i undid the engine mounts and lifted the engine up and toward the drivers side there was just enough room to get it out while bolted together and back in too, but not an easy task.

The comp housing was in about the best position to clear the manifold and have room to get the outlet pipe connected. If you rotate it too much you'll run into issues with melting silicone or the other way hitting body work.

Send me a pm, I can give you a couple of photos, they aren't great as i had a camera phone in bad light but may help. I can take some new photos of the cross member butchery and the engine mount with bend too.

Cheers

Dave

RB25, HKS cast low mount with a GT3076 WG and I had to grind away the heat sheild and part of the metal that the rubber mount is bounded to. You can't get away without doing it unless you have an RB30, then the extra 38mm lifts the turbo up enough to clear it.

I used a 4" angle grinder with a s/s cutting blade [they are super thin 1-1.5mm]. I finished it off with a sanding disc on the 4". Make sure you cover everything up real good because rubber and filings dust goes everywhere. Blow it all down when your finished [if you have a compressor].

Don't be fooled into thinking that you have to cut the side away, its more towards the passenger rear than the side.

Create an account or sign in to comment

You need to be a member in order to leave a comment

Create an account

Sign up for a new account in our community. It's easy!

Register a new account

Sign in

Already have an account? Sign in here.

Sign In Now


  • Similar Content

  • Latest Posts

    • Did this end up working? Did you take some pictures?
    • And finally, the front lower mount. It was doubly weird. Firstly, the lower mount is held in with a bracket that has 3 bolts (it also acts as the steering lock stop), and then a nut on the shock lower mount itself. So, remove the 3x 14mm head bolts , then the 17mm nut that holds the shock in. From there, you can't actually remove the shock from the lower mount bolt (took me a while to work that out....) Sadly I don't have a pic of the other side, but the swaybar mounts to the same bolt that holds the shock in. You need to push that swaybar mount/bolt back so the shock can be pulled out past the lower control arm.  In this pic you can see the bolt partly pushed back, but it had to go further than that to release the shock. Once the shock is out, putting the new one in is "reverse of disassembly". Put the top of the shock through at least one hole and put a nut on loosely to hold it in place. Put the lower end in place and push the swaybar mount / shock bolt back in place, then loosely attach the other 2 top nuts. Bolt the bracket back in place with the 14mm head bolts and finally put the nut onto the lower bolt. Done....you have new suspension on your v37!
    • And now to the front.  No pics of the 3 nuts holding the front struts on, they are easy to spot. Undo 2 and leave the closest one on loosely. Underneath we have to deal with the wiring again, but this time its worse because the plug is behind the guard liner. You'll have to decide how much of the guard liner to remove, I undid the lower liner's top, inside and lower clips, but didn't pull it full off the guard. Same issue undoing the plug as at the rear, you need to firmly push the release clip from below while equally firmly gripping the plug body and pulling it out of  the socket. I used my fancy electrical disconnect pliers to get in there There is also one clip for the wiring, unlike at the rear I could not get behind it so just had to lever it up and out.....not in great condition to re-use in future.
    • Onto the rear lower shock mount. It's worth starting with a decent degrease to remove 10+ years of road grime, and perhaps also spray a penetrating oil on the shock lower nut. Don't forget to include the shock wiring and plug in the clean.... Deal with the wiring first; you need to release 2 clips where the wiring goes into the bracket (use long nose pliers behind the bracket to compress the clip so you can reuse it), and the rubber mount slides out, then release the plug.  I found it very hard to unplug, from underneath you can compress the tab with a screwdriver or similar, and gently but firmly pull the plug out of the socket (regular pliers may help but don't put too much pressure on the plastic. The lower mount is straightforward, 17mm nut and you can pull the shock out. As I wasn't putting a standard shock back in, I gave the car side wiring socket a generous gob of dialectric grease to keep crap out in the future. Putting the new shock in is straightforward, feed it into at least 1 of the bolt holes at the top and reach around to put a nut on it to hold it up. Then put on the other 2 top nuts loosely and put the shock onto the lower mounting bolt (you may need to lift the hub a little if the new shock is shorter). Tighten the lower nut and 3 upper nuts and you are done. In my case the BC Racing shocks came assembled for the fronts, but the rears needed to re-use the factory strut tops. For that you need spring compressors to take the pressure off the top nut (they are compressed enough when the spring can move between the top and bottom spring seats. Then a 17mm ring spanner to undo the nut while using an 8mm open spanner to stop the shaft turning (or, if you are really lucky you might get it off with a rattle gun).
    • You will now be able to lift the parcel shelf trim enough to get to the shock cover bolts; if you need to full remove the parcel shelf trim for some reason you also remove the escutcheons around the rear seat release and you will have to unplug the high stop light wiring from the boot. Next up is removal of the bracket; 6 nuts and a bolt Good news, you've finally got to the strut top! Remove the dust cover and the 3 shock mount nuts (perhaps leave 1 on lightly for now....) Same on the other side, but easier now you've done it all before
×
×
  • Create New...