Jump to content
SAU Community

Recommended Posts

The diagnostic computer is giving the above error on my R33 GTSt. Anyone have any idea what i should check to see if it's the problem?

Basically the symptoms are very rich, very rough running. It missfires heaps and struggles to idle. The plugs foul to the point where they are black and wet.

It happened after i took it in for a check up on the dyno so i'm not sure if it's something that just happened to fail or if it's something they have done. I took it back to them and they changed back what they did to the way it was (not much changed).

My car has a HKS FCON V, HKS VPC, and a HKS PFC-FCON.

It's got me buggered. I've tried another Crank Angle Sensor, i've put new spark plugs in. Could it be coil packs, or possible the PTU (the little thing that sits up the back of the engine that plugs into the coil pack loom).

Any tips would be good.

Link to comment
https://www.sau.com.au/forums/topic/41002-error-21-ignition-signal-problem/
Share on other sites

AFAIK the computer diagnostics only pick up short/open circuits or out of range signals. When the ECU detects an error in any of the systems it checks it enters a "safe" mode where the engine is only allowed to run with very conservative settings (ie rich, retarded timing, rev limited). The actual settings vary depending on the failure detected.

So the most obvious thing to look for is something that has been accidentaly left unplugged, which you have probably already done.

Next you need to start investigating individual components and their wiring. It could be something as simple as an earth that has been left off or a wire in the loom that has been broken somehow. It also could be something that has failed. Try playing swapsies with known good parts.

A multimeter and an engine manual are your friend.

yeah... i don't have an engine manual or a manual for the HKS computers. Oh well... i'm tipping that something has come loose under the foot well where the FCON V is sitting. The car ran perfectly fine before i dropped it off for a tune up. I've looked at all the things in the engine bay to make sure they are all plugged in correctly, such as the igniter, the coils, the CAS. We changed over the CAS to see if that was the problem, it wasn't. I've got a spare set of coil packs and an igniter here that i can check. All the injector plugs are on etc so the only logical thing to check is the dogs breakfast of wiring looms under the passenger dash/footwell

yeah i've pulled the battery out (flat from trying to start it on fouled plugs), so it will have the night to reset, tomorrow i'll try and start it again with clean plugs and a different Ignition Amplifier as well. Hopefully all will be ok.

well i started it an still no good. The guy who buggered it up had a Snap-On box that plugged into the port under the steering wheel. That's where i got the Error 21 from. I have a funny feeling that he's wiped the HKS computer of the tune that was in it so it's back to factory defaults.

Well i have changed everything except for the HKS computer. I've changed crank angle sensor, coil pack igniter module, i've tested all the coil packs (all 0.8 ohms), i've swapped over the factory computer with another one. So all that is left in the ignition circuit is the HKS FCON V, HKS VPC, and PFC-FCON and also the wiring loom. So either the HKS computer has crapped itself (or he fried it), or the wiring loom is damaged.

Starting to piss me off. I wish i knew what this other tuning place had done to it...

Andrew

Have you checked the power supply to the ignitor / coils? Or the relay for the coils?

Error 21 is raised when the ignition signal isn't generated. If it was a problem with CAS, it would be error 11.

Power is supplied to the coilpak, and the ECU earths the coil thru the ignotor to generate spark. Work out which wire is the power at the coilpak - if you pull the plug off and look into the plug, I think it will be the left-hand of the three pins in the plug.

Switch ignition to IGN / ON (not START), then measure voltage to earth (chassis / engine). It should be basically 12V.

If it's not 12V, I really have no idea WHERE the relay is located - it will be up to you to go exploring.

well after spending the whole day on it the mechanic found a few problems and in the end got it running. I'll post up what the problems were when i pick up the car and have a chat to him about it. I think it's going to cost me a hell of a lot though, so i'm not looking forward to the bill!!! And there is a bit more to do tomorrow, chuck it on the dyno and check the fuel ratios etc and just give it an all over check up to make sure everything is in check. At least my HKS computer isn't fried and the motor isn't blown!

so thanks to everyone that gave suggestions on what to check. I tell ya, this whole engine transplant saga has meant i know the RB25 almost backwards now and would be confident to do it again. Just a shame the couple of places i took it to to do the things i couldn't (check A/F ratios and pull out the old motor and drop in the new) did a pretty half assed job job. Oh well... disappointing but i spose once you find a good mechanic you need to stick with them!

Andrew

Yes... the car is all working!!! cost me $670 though... had some cracked wires to the computer. The igniter wasn't grounding properly, the vacuum hose to a map sensor was stuffed... so a few hours spent sorting it out but it's all fixed. Chucked it on the dyno and set the max boost, gave it a quick tune to make sure everything is in check and pulled a nice 222kw at the wheels at 0.68bar (9.8psi)... so i'm pretty happy. All i need to do now is bigger pump and i should be able to get it up to 1.1-1.2bar and have some good power!

Andy

Create an account or sign in to comment

You need to be a member in order to leave a comment

Create an account

Sign up for a new account in our community. It's easy!

Register a new account

Sign in

Already have an account? Sign in here.

Sign In Now


  • Similar Content

  • Latest Posts

    • I know why it happened and I’m embarrassed to say but I was testing the polarity of one of the led bulb to see which side was positive with a 12v battery and that’s when it decided to fry hoping I didn’t damage anything else
    • I came here to note that is a zener diode too base on the info there. Based on that, I'd also be suspicious that replacing it, and it's likely to do the same. A lot of use cases will see it used as either voltage protection, or to create a cheap but relatively stable fixed voltage supply. That would mean it has seen more voltage than it should, and has gone into voltage melt down. If there is something else in the circuit dumping out higher than it should voltages, that needs to be found too. It's quite likely they're trying to use the Zener to limit the voltage that is hitting through to the transistor beside it, so what ever goes to the zener is likely a signal, and they're using the transistor in that circuit to amplify it. Especially as it seems they've also got a capacitor across the zener. Looks like there is meant to be something "noisy" to that zener, and what ever it was, had a melt down. Looking at that picture, it also looks like there's some solder joints that really need redoing, and it might be worth having the whole board properly inspected.  Unfortunately, without being able to stick a multimeter on it, and start tracing it all out, I'm pretty much at a loss now to help. I don't even believe I have a climate control board from an R33 around here to pull apart and see if any of the circuit appears similar to give some ideas.
    • Nah - but you won't find anything on dismantling the seats in any such thing anyway.
    • Could be. Could also be that they sit around broken more. To be fair, you almost never see one driving around. I see more R chassis GTRs than the Renault ones.
    • Yeah. Nah. This is why I said My bold for my double emphasis. We're not talking about cars tuned to the edge of det here. We're talking about normal cars. Flame propagation speed and the amount of energy required to ignite the fuel are not significant factors when running at 1500-4000 rpm, and medium to light loads, like nearly every car on the road (except twin cab utes which are driven at 6k and 100% load all the time). There is no shortage of ignition energy available in any petrol engine. If there was, we'd all be in deep shit. The calorific value, on a volume basis, is significantly different, between 98 and 91, and that turns up immediately in consumption numbers. You can see the signal easily if you control for the other variables well enough, and/or collect enough stats. As to not seeing any benefit - we had a couple of EF and EL Falcons in the company fleet back in the late 90s and early 2000s. The EEC IV ECU in those things was particularly good at adding in timing as soon as knock headroom improved, which typically came from putting in some 95 or 98. The responsiveness and power improved noticeably, and the fuel consumption dropped considerably, just from going to 95. Less delta from there to 98 - almost not noticeable, compared to the big differences seen between 91 and 95. Way back in the day, when supermarkets first started selling fuel from their own stations, I did thousands of km in FNQ in a small Toyota. I can't remember if it was a Starlet or an early Yaris. Anyway - the supermarket servos were bringing in cheap fuel from Indonesia, and the other servos were still using locally refined gear. The fuel consumption was typically at least 5%, often as much as 8% worse on the Indo shit, presumably because they had a lot more oxygenated component in the brew, and were probably barely meeting the octane spec. Around the same time or maybe a bit later (like 25 years ago), I could tell the difference between Shell 98 and BP 98, and typically preferred to only use Shell then because the Skyline ran so much better on it. Years later I found the realtionship between them had swapped, as a consequence of yet more refinery closures. So I've only used BP 98 since. Although, I must say that I could not fault the odd tank of United 98 that I've run. It's probably the same stuff. It is also very important to remember that these findings are often dependent on region. With most of the refineries in Oz now dead, there's less variability in local stuff, and he majority of our fuels are not even refined here any more anyway. It probably depends more on which SE Asian refinery is currently cheapest to operate.
×
×
  • Create New...