Jump to content
SAU Community

Recommended Posts

So Ive been having some dramas with my fuel system.

Ive got an 044 and a surge tank in the boot with a walbro in the tank as a lift pump.

The other day I was driving and all of a sudden the car turns off.

I noticed that I couldnt hear the fuel pump priming, so I bypassed the relay and wired the 044 to direct power and it was enough to get me home.

Had a fiddle around and I ended up figuring out that the fuel pump fuse had blown, so I put another fuse in....(i pulled out a 15a and all I had was a 25a so I put that in)

Car started, I let it idle for about 5 mins while I packed up and all of a sudden it turns off again. Had a look and the new fuse had blown....

I thought maybe the fuel filter was blocked, so I took it out, gave it a clean, put it back in and started the car...

Let it idle while i packed up again, then as I walked around to the boot I noticed a strange noise.

It sounded like something was rattling away in my surge tank, but upon closer inspection I realised the noise was coming from my fuel pump... i let it go for a few mins and the noise just kept getting worse and worse so I just turned it off. Now I dont know what to do....

Link to comment
https://www.sau.com.au/forums/topic/414295-fuel-pump-dramas/
Share on other sites

What gauge wire are you using ?

I have 2x 044 attached to a surge

1x 040 as lift pump

All direct wired on 3 separate relays

044 have a high amp draw you need to get your maths skills on make sure wire and fuse's are up too the task

ok so I figured out that the noisy 044 was just due to the fact that the lift pump wasnt working and the surge was emptying out.

I had a walbro 255 as a lift pump but im wondering if I should try something different. I would like something that isnt going to die in E85, but is the new walbro e85 pump too big to use as a lift pump?

ok so I figured out that the noisy 044 was just due to the fact that the lift pump wasnt working and the surge was emptying out.

I had a walbro 255 as a lift pump but im wondering if I should try something different. I would like something that isnt going to die in E85, but is the new walbro e85 pump too big to use as a lift pump?

Not sure if e85 safe but I'm running a 040 as lift pump on a flex fuel setup

Create an account or sign in to comment

You need to be a member in order to leave a comment

Create an account

Sign up for a new account in our community. It's easy!

Register a new account

Sign in

Already have an account? Sign in here.

Sign In Now


  • Similar Content

  • Latest Posts

    • How do you propose I cable tie this: To something securely? Is it really just a case of finding a couple of holes and ziptying it there so it never goes flying or starts dangling around, more or less? Then run a 1/8 BSP Female to [hose adapter of choice?/AN?] and then the opposing fitting at the bush-into-oil-block end? being the hose-into-realistically likely a 1/8 BSPT male) Is this going to provide any real benefit over using a stainless/steel 1/4 to 1/8 BSPT reducing bush? I am making the assumption the OEM sender is BSPT not BSPP/BSP
    • I fashioned a ramp out of a couple of pieces of 140x35 lumber, to get the bumper up slightly, and then one of these is what I use
    • I wouldn't worry about dissimilar metal corrosion, should you just buy/make a steel replacement. There will be thread tape and sealant compound between the metals. The few little spots where they touch each other will be deep inside the joint, unable to get wet. And the alloy block is much much larger than a small steel fitting, so there is plenty of "sacrificial" capacity there. Any bush you put in there will be dissimilar anyway. Either steel or brass. Maybe stainless. All of them are different to the other parts in the chain. But what I said above still applies.
    • You are all good then, I didn't realise the port was in a part you can (have!) remove. Just pull the broken part out, clean it and the threads should be fine. Yes, the whole point about remote mounting is it takes almost all of the vibration out via the flexible hose. You just need a convenient chassis point and a cable tie or 3.
    • ..this is the current state of that port. I appreciate the info help (and the link to the Earls thing @Duncan). Though going by that it seems like 1/4 then BSP'ing it and using a bush may work. I don't know where I'd be remote mounting the pressure sender... to... exactly. I assume the idea here is that any vibration is taken up by the semiflexible/flexible hose itself instead of it leveraging against the block directly. I want to believe a stronger, steel bush/adapter would work, but I don't know if that is engineeringly sound or just wishful thinking given the stupendous implications of a leak/failure in this spot. What are the real world risks of dissimilar metals here? It's a 6061 Aluminum block, and I'm talking brass or steel or SS adapters/things.
×
×
  • Create New...