Jump to content
SAU Community

Recommended Posts

Hi all, so after a long twisted journey car has finally had a full tune and up and running. Just after some people more in the know what they think of power results, and the dyno printout. I'm a bit unsure about the power delivery over 4000rpm how its a bit up and down. I thought it should be smooth, and that this would be a tunning issue? ok so list of mods

Rebuilt 25det neo- arp rodbolts, metal shim headgasket, upgraded oil pump, heavier valve springs, new rings bearing etc, extended sump

Greddy style front face intake

660cc injectors

factory fuel rail

nismo regulator

nismo intank pump

greddy type r bov

3inch pipe to intercooler

Gtr style intercooler

3- 2.5-turbo intercooler pipework

Masterpower turbo .48 exhaust housing, .54 compressor (I think or .5)

sinco high rise manifold

turbo smart 40mm gate

full 3 inch exhaust, with venom 500 series cat, and adrenalinr high flow muffler

catch can, venting into intake pipe

4inch intake with k&N pod

the intention was to build a tidy responsive st package which I seem to have achieved. Tuning wise, the cam sensor was giving too sensitive reading at high rpm, so changed to a 24 tooth trigger wheel. But once fitted they only did 2 more power runs before pulling car off dyno. And the setup apparently reached it's peak at 16psi, and 432hp, saying the turbo was becoming a restriction or the exhaust. I'm confident the exhaust isn't the restriction, and knew the turbo was going to be the cars main limiting factor, but the supplier rated it to 20psi, and 450hp. So basically do you guys think numbers match the package, and are the dyno fluctuations a normal thing?

Link plug in ecu

post-52658-0-22006500-1390991718_thumb.jpg

Link to comment
https://www.sau.com.au/forums/topic/438401-unsure-on-25det-results/
Share on other sites

.I'd think the restriction and the fluctuations are both caused by that gate and rear housing...its too small and choking on its own exhaust gases ,when they cant get out the exhaust fast enough they back up into the motor.,.you would want a .6+ rear housing at least..and possibly a bigger gate to match...i think its done pretty well to squeeze 432hp through it...you can put a bigger housing on it and easily get the same results response wise with more top end...

450hp rating would be an engine rating no doubt ...which it has acheived quite easily, i doubt they expected it to be on a 2.5lt motor..maybe a 1.8 or 2lt...

By looking at the curve its not making much power for the setup or been responsive in todays standard.

Housings are tinny for this engine is, which makes compressor flow strongly relaying on the external gate. That would be making the turbine side red hot, probably starts to pin after a couple of dyno runs and it had to be pulled off the dyno.

It needs a much larger housings with more civilized wheel combinations.

THanks for input. Tuner didn't say anything about pinging, but wasn't making any more efficient power increases. This particular turbo does come with a .63 rear housing option, which I discussed with the seller at the time. He was good to deal with and seemed knowledgeable. He knew this was going on a 25det motor, and yes as stated probably correct, he would have been rating at motor which I hadn't thought about. Tuner recommended going to a garret turbo, which they claimed would push up to and a bit over 500hp.

Another much more cost effective option would be to change to the .63 exhaust housing with this turbo, and he said they're direct bolt in out options for the exhaust pipe. But do you think would be a worth while move, or is this not worth pushing any more? My original hope for setup was around 450-470 hp mark.

So going to turb specs from website,

compressor spec 54/77mm 49trim Forged CNC Aluminium,

centre housing MP350c, 360 Thrust, LI journals, Water cooled.

turbine spec 59/70mm 71trim 12Bld,

and finally the different ar options available T3 .48, .63, .7, .84, .94

Hope this makes sense to the technical savvy out there. Any opinions /thoughts appreciated

Create an account or sign in to comment

You need to be a member in order to leave a comment

Create an account

Sign up for a new account in our community. It's easy!

Register a new account

Sign in

Already have an account? Sign in here.

Sign In Now


  • Similar Content

  • Latest Posts

    • If as it's stalling, the fuel pressure rises, it's saying there's less vacuum in the intake manifold. This is pretty typical of an engine that is slowing down.   While typically is agree it sounds fuel related, it really sounds fuel/air mixture related. Since the whole system has been refurbished, including injectors, pump, etc, it's likely we've altered how well the system is delivering fuel. If someone before you has messed with the IACV because it needed fiddling with as the fuel system was dieing out, we need to readjust it back. Getting things back to factory spec everywhere, is what's going to help the entire system. So if it idles at 400rpm with no IACV, that needs raising. Getting factory air flow back to normal will help us get everything back in spec, and likely help chase down any other issues. Back on IACV, if the base idle (no IACV plugged in) is too far out, it's a lot harder for the ECU to control idle. The IACV duty cycle causes non linear variations in reality. When I've tuned the idle valves in the past, you need to keep it in a relatively narrow window on aftermarket ecus to stop them doing wild dances. It also means if your base idle is too low, the valve needs to open too much, and then the smallest % change ends up being a huge variation.
    • I guess one thing that might be wrong is the manifold pressure.  It is a constant -5.9 and never moves even under 100% throttle and load.  I would expect it to atleast go to 0 correct?  It's doing this with the OEM MAP as well as the ECU vacuum sensor. When trying to tune the base map under load the crosshairs only climb vertically with RPM, but always in the -5.9 column.
    • AHHHH gotchaa, I'll do that once I am home again. I tried doing the harness with the multimeter but it seems the car needed a jump, there was no power when it was in the "ON" position. Not sure if I should use car battery jump starter or if its because the stuff that has been disconnect the car just does send power.
    • As far as I can tell I have everything properly set in the Haltech software for engine size, injector data, all sensors seem to be reporting proper numbers.  If I change any injector details it doesnt run right.    Changing the base map is having the biggest change in response, im not sure how people are saying it doesnt really matter.  I'm guessing under normal conditions the ECU is able to self adjust and keep everything smooth.   Right now my best performance is happening by lowering the base map just enough to where the ECU us doing short term cut of about 45% to reach the target Lambda of 14.7.  That way when I start putting load on it still has high enough fuel map to not be so lean.  After 2500 rpm I raised the base map to what would be really rich at no load, but still helps with the lean spots on load.  I figure I don't have much reason to be above 2500rpm with no load.  When watching other videos it seems their target is reached much faster than mine.  Mine takes forever to adjust and reach the target. My next few days will be spent making sure timing is good, it was running fine before doing the ECU and DBW swap, but want to verify.  I'll also probably swap in the new injectors I bought as well as a walbro 255 pump.  
    • It would be different if the sealant hadn't started to peel up with gaps in the glue about ~6cm and bigger in some areas. I would much prefer not having to do the work take them off the car . However, the filler the owner put in the roof rack mount cavities has shrunk and begun to crack on the rail delete panels. I cant trust that to hold off moisture ingress especially where I live. Not only that but I have faded paint on as well as on either side of these panels, so they would need to come off to give the roofline a proper respray. My goal is to get in there and put a healthy amount of epoxy instead of panel filler/bog and potentially skin with carbon fiber. I have 2 spare rolls from an old motorcycle fairing project from a few years back and I think it'd be a nice touch on a black stag.  I've seen some threads where people replace their roof rack delete with a welded in sheet metal part. But has anyone re-worked the roof rails themselves? It seems like there is a lot of volume there to add in some threads and maybe a keyway for a quick(er) release roof rack system. Not afraid to mill something out if I have to. It would be cool to have a cross bar only setup. That way I can keep the sleek roofline that would accept a couple bolts to gain back that extra utility  3D print some snazzy covers to hide the threaded section to be thorough and keep things covered when not using the rack. 
×
×
  • Create New...