Jump to content
SAU Community

Recommended Posts

psybic, some more food for thought:

"You have to remember there were the best minds in the world work on these systems in F1 for over 10 years and in that time no one ever though to fit the BOV for all of its performance and reliability benefits."

here is another one from Garrett

"Garrett do not necessarily have a stand on BOVs, personally I have not seen an issue with a turbo due to not having a blow off valve but they seem to be a good device"

Pretty vague, no evidence of failure - and that is from the manufacturer of the turbos - when they have to give warranty, wouldnt they add ANY clause they could to give them an excuse not to have to pay a claim? make it conditional that if a turbo fails without bov fitted that its not their responsibility - big company, specialise in turbos and spend many millions on developement. Just doesnt add up.

I had a friend who fitted a turbosmart bov, it started lifting under boost, had to be shimmed up, still kept lifting, he just counldnt stop it from lifting under boost. This causes turbo overspeeding, how long does for example the R33 stock turbo last when you start overpeeding it? It would hardly add to its reliability.

So who is it that is pushing the great virtues of a BOV? The manufacturers of the bovs think they are important, yet where is their conclusive testing or evidence - they dont have any.

To me, it seems like the arguement for bovs is greatly comprised of urban legend or myth, perpetuated by the manufacturers of bovs and the likes of hot 4s magazine - with very little supporting evidence.

  • Replies 144
  • Created
  • Last Reply

Top Posters In This Topic

oh, just had to add this one:

For those that think long term reliability is a non issue in a race car (as they replace turbos all the time) show me any car that does more work than a LeMans 24hr racer and I will show you a chimp that Michael Jackson has not slept with.

With regards to the LeMans 24 hr cars though. Thats a good point, but what boost level does the GT Class (name the year...they change so often) have to run, remembering that they have to run with a restrictor in place.

Does this change things???...i dont know, hang on i posted a bunch of crap about GT cars a few years ago...off i go to see if i can find it:)

umm Garret would sell/rebuild more turbos if their reliability was slightly compromised by people not running BOVs at all........lol

its seriously not their problem and they know it

in terms of le mans, reliability is compromised in racing for speed untill it influences a cars ability to finish as quickly as it can

yes, they do, its called a warranty

Lemans, a compromise of reliability? a 24 hour race designed to push cars to their limits of reliability isnt about reliability? Where is the reliability being compromised? Its only compromised when they dont finish.

yes, they do, its called a warranty  

Lemans, a compromise of reliability?  a 24 hour race designed to push cars to their limits of reliability isnt about reliability?  Where is the reliability being compromised? Its only compromised when they dont finish.

I have been hanging off posting on the relevancy of a purpose built race engine, purpose built exhaust, inlet, restrictor limited, boost constrained, 900 kg car that has a 6 speed pneumatic gearbox. The chassis itself was designed to fit around the engine, so there were no installation compromises either. For heavens sake, they change the turbo specifications and gearbox ratios depending on whether they are running at LeMans or Daytona.

If I had their budget I could probably afford to have everything exactly matched and wouldn't need a BOV either. But I don't, I have a production based engine with an off the shelf manifold that has to fit inside a production engine bay, with production gear ratios and it has to be driven to work everyday and live on the circuit occasionally. Not one ciruit, but 5 different circuits.

It makes about as much sense as the 1980's F1 comparison, which is not farkin much. I was there in Adelaide and saw Senna drive the Lotus, it had heaps of lag and piss poor throttle response compared to the the N/A cars that were all over it in the corners. I will always remember Colin Chapman's philosophy, "an F1 car is over engineered if it lasts the slow down lap after the end of the race". The concept was EVERYTHING on the car should fail the instant it cross the finish line. Otherwise it was too heavy and excessively engineered. :chairshot

I have seen an ex F1 turbo, a friend of mine owns one, the thing is huge, weighs about 30 kgs and has all sorts of exotic materials used in its construction, all the 'ums, titanium, magnesium, berilium etc. I am not suprised it didn't need a BOV to make it through 2 hours of racing, the thing would survive an atomic bomb.

Time marches on, F1 cars have power steering, imagine what CC would have said to an engineer who suggested putting power steering on a Lotus F1 car in the 80's. :werd:

I have had enough of the purpose built race car stuff:cheers:

For those that think long term reliability is a non issue in a race car (as they replace turbos all the time) show me any car that does more work than a LeMans 24hr racer and I will show you a chimp that Michael Jackson has not slept with.

Why would they use a 30 kg turbo, if one half the wieght with a bov would do the job?

I dont see how its relevant to what works best.

Try speeding your car which has a 800 HP like the drag racers that stress their turbo(which is much bigger) and see what happens to it. I've seen one that got his turbine turbo cracked.

Racers get to service almost every race. Whether or not it improves the performance that im not sure. But they definitely get to change their turbo from time to time.

I realize one thing that wasnt mention in this thread. Do you possibly think a turbo wouldnt wear off? Why wasnt temperature involved in this issue?

Here's a classic test for the doubtful. Grab an electric fan (the turbine) block the outlet and see what happens.....you'll hear the fan actually speed up, NOT slow down.

I think this is ridiculous.

Why not try using a blower and let high temp intake blow it in while you cover it.

From what i know, most "street" racers gets a Bov and their comments was that it improved their performance.

If you didnt mod your car too high, then the standard bov is just good enough but i certainly disagree that Bov is a wank if you are planning to push your car to the limits in an economical way.

Off topic but this is a funny discussion:)

A Le Mans / Daytona car would not be running the maximum allowable boost pressure for the whole race.

My guess is this would be for fuel economy as well as reliability. Many of the cars still have turbo failures in the race, thing is they are a 2-5 mintue fix on these purpose built race cars...where competitors are bouncing off one another, running out of fuel, breaking gearboxes, getting flats around the back of the track etc.

Sure they dont design them to fail, but with the manner in which they are mounted a turbo failure would be seen as almost an acceptable failure, probably more so then a flat tyre.

So if the category rules allow them to run 2.0 bar, then its possible they could be running as little as 14-16psi for much of the race, only using more boost when strategy dictates. The GT1 cars would have only been allowed tp run a max of 1.0bar certain years

To simply say hey, GT cars etc at Le Mans is perhaps forgetting the bigger picture, that is if they dont run BOVs. And from memory of footage i have of a Le Mans winning GT1, it doesnt sound as though it runs BOVs, but cant be sure. I know the EB110S did:)

Other thing is many of the Le Mans cars ran plain bearing turbos with no water cooling, hello IHI and KKK turbos. They did the job, but yeh there are just so many variables when trying to compare race cars to road cars.

http://www.skylinesaustralia.com/forums/sh...ead.php?t=31650

From the above thread you can see that depending on class they competed in some Le Mans cars didnt run all that much boost :D

LOL...this aint a BOV thread anymore:)

And sorry one more thing, these cars running expensive specialty turbos with thicker shafts, titanium wheels, sometimes anti-lag etc. They are typically twin configurations running on modest capacity engines with close ratio boxes so always have the right gear etc etc.

So not saying anyones wrong or right, just sasying these things all play a part and perhaps take away from the Le Mans /F1 cars dont use BOVs, as perhaps there is more to it:confused:..........:D

Its like saying that an ex Indycar Holset/Allied Signal turbo is the same as on a generic truck/road cars.

I think this is ridiculous.

Why not try using a blower and let high temp intake blow it in while you cover it.

From what i know, most "street" racers gets a Bov and their comments was that it improved their performance.

If you didnt mod your car too high, then the standard bov is just good enough but i certainly disagree that Bov is a wank if you are planning to push your car to the limits in an economical way.

rediculous? it proves a point, but maybe you cant see that, fair enough.

So you base your performance beliefes on 'street racers', nice, enjoy your bov, and your neons.

So how many performance build ups have you done? hmm, fark all I guess. And you will probably never have one if you base your theories on 'street racers' nice move.

Roy, its interesting, some do use bovs, some dont - perhaps sponsorship has something to do with it? Proven perfromance, NO, there is no proof - but many examples where turbos, and performance dont seem to suffer witout one. Many examples of manufacturers that remove bovs on their performance, dedicated track cars.

Holset/Allied Signal, aka Garrett, did you see the garrett comment on bovs posted earlier? obviously (understandably) they are at the cutting edge of turbo technology.

interesting, seen photos of indi cars, using what 'looks' like standard tial wastegates - they do have pop off valves, to limit boost, but not bovs.

I just cant get passed the fact that cutting edge, such as indi cars, where technology is tested and refined, yet no bov, and they (garrett) cant say there is a need for one - vs ( as runn3r points out ) 'street racers' and bov companies who swear they are essential for optimum performance and reliability.

Where, for gods sake is the evidence?

rediculous? it proves a point, but maybe you cant see that, fair enough.

So you base your performance beliefes on 'street racers', nice, enjoy your bov, and your neons.

So how many performance build ups have you done?  hmm, fark all I guess.  And you will probably never have one if you base your theories on 'street racers' nice move.

Roy, its interesting, some do use bovs, some dont - perhaps sponsorship has something to do with it?  Proven perfromance, NO, there is no proof - but many examples where turbos, and performance dont seem to suffer witout one.  Many examples of manufacturers that remove bovs on their performance, dedicated track cars.

I run a cheap ass BOV on my SIL80 , but ill be removing it soon..

Ill test it how it differs from running one, and i even use a std AFM ...

Should go the same, if not better :elaugh:

Where, for gods sake is the evidence?

Mod your car up, tune it till its gets 800hp. Don need any fancy stuff, just ya standard bov. Try boosting your turbo to the limits for a couple of weeks.

We will be happy to hear the test and ill be happy to hear it from you.

Or maybe if you arent about to ruin your turbo yet, try an after market bov and see the performance.

Take a video and you will be the first tester and we all would be very thankful.

-end-

Information about F1 Engines go to

http://f1technical.net/article4.html

Where, for gods sake is the evidence?

Mod your car up,  tune it till its gets 800hp. Don need any fancy stuff, just ya standard bov. Try boosting your turbo to the limits for a couple of weeks.  

We will be happy to hear the test and ill be happy to hear it from you.

Or maybe if you arent about to ruin your turbo yet, try an after market bov and see the performance.  

Take a video and you will be the first tester and we all would be very thankful.

-end-

Information about F1 Engines go to

http://f1technical.net/article4.html

Too bad its already been done by RICE RACING, but not with 800bhp unfortunetly..

This time Twin GT3540R's where used on a Highly ported and tuned 13B engine.

Making over 1000BHP with minimal lag for a big circuit.

NO BOV's where used.. heh.. who give's a crap.. if you spent your money on a BOV or what not, thats your fault.

Create an account or sign in to comment

You need to be a member in order to leave a comment

Create an account

Sign up for a new account in our community. It's easy!

Register a new account

Sign in

Already have an account? Sign in here.

Sign In Now



  • Similar Content

  • Latest Posts

    • So this being my first contribution to the SAU forums, I'd like to present and show how I had to solve probably one of the most annoying fixes on any car I've owned: replacing a speedometer (or "speedo") sensor on my newly acquired Series 1 Stagea 260RS Autech Version. I'm simply documenting how I went about to fix this issue, and as I understand it is relatively rare to happen to this generation of cars, it is a gigantic PITA so I hope this helps serve as reference to anyone else who may encounter this issue. NOTE: Although I say this is meant for the 260RS, because the gearbox/drivetrain is shared with the R33 GTR with the 5-speed manual, the application should be exactly the same. Background So after driving my new-to-me Stagea for about 1500km, one night while driving home the speedometer and odometer suddenly stopped working. No clunking noise, no indication something was broken, the speedometer would just stop reading anything and the odometer stopped going up. This is a huge worry for me, because my car is relatively low mileage (only 45k km when purchased) so although I plan to own the car for a long time, a mismatched odometer reading would be hugely detrimental to resale should the day come to sell the car. Thankfully this only occurred a mile or two from home so it wasn't extremely significant. Also, the OCD part of me would be extremely irked if the numbers that showed on my dash doesn't match the actual ageing of the car. Diagnosing I had been in communication with the well renown GTR shop in the USA, U.P.garage up near University Point in Washington state. After some back and forth they said it could be one of two things: 1) The speedometer sensor that goes into the transfer case is broken 2) The actual cluster has a component that went kaput. They said this is common in older Nissan gauge clusters and that would indicate a rebuild is necessary. As I tried to figure out if it was problem #1, I resolved problem #2 by sending my cluster over to Relentless Motorsports in Dallas, TX, whom is local to me and does cluster and ECU rebuilds. He is a one man operation who meticulously replaces every chip, resistor, capacitor, and electronic component on the PCB's on a wide variety of classic and modern cars. His specialty is Lexus and Toyota, but he came highly recommended by Erik of U.P.garage since he does the rebuilds for them on GTR clusters.  For those that don't know, on R32 and R33 GTR gearboxes, the speedometer sensor is mounted in the transfer case and is purely an analog mini "generator" (opposite of an alternator essentially). Based on the speed the sensor spins it generates an AC sine wave voltage up to 5V, and sends that via two wires up to the cluster which then interprets it via the speedometer dial. The signal does NOT go to the ECU first, the wiring goes to the cluster first then the ECU after (or so I'm told).  Problems/Roadblocks I first removed the part from the car on the underside of the transfer case (drain your transfer case fluid/ATF first, guess who found out that the hard way?), and noted the transfer case fluid was EXTREMELY black, most likely never changed on my car. When attempting to turn the gears it felt extremely gritty, as if something was binding the shaft from rotating properly. I got absolutely no voltage reading out of the sensor no matter how fast I turned the shaft. After having to reflow the solder on my AFM sensors based on another SAU guide here, I attempted to disassemble the silicone seal on the back of the sensor to see what happened inside the sensor; turns out, it basically disintegrated itself. Wonderful. Not only had the electrical components destroyed themselves, the magnetic portion on what I thought was on the shaft also chipped and was broken. Solution So solution: find a spare part right? Wrong. Nissan has long discontinued the proper sensor part number 32702-21U19, and it is no longer obtainable either through Nissan NSA or Nissan Japan. I was SOL without proper speed or mileage readings unless I figured out a way to replace this sensor. After tons of Googling and searching on SAU, I found that there IS however a sensor that looks almost exactly like the R33/260RS one: a sensor meant for the R33/R34 GTT and GTS-T with the 5 speed manual. The part number was 25010-21U00, and the body, plug, and shaft all looked exactly the same. The gear was different at the end, but knowing the sensor's gear is held on with a circlip, I figured I could just order the part and swap the gears. Cue me ordering a new part from JustJap down in Kirrawee, NSW, then waiting almost 3 weeks for shipping and customs clearing. The part finally arrives and what did I find? The freaking shaft lengths don't match. $&%* I discussed with Erik how to proceed, and figuring that I basically destroyed the sensor trying to get the shaft out of the damaged sensor from my car. we deemed it too dangerous to try and attempt to swap shafts to the correct length. I had to find a local CNC machinist to help me cut and notch down the shaft. After tons of frantic calling on a Friday afternoon, I managed to get hold of someone and he said he'd be able to do it over half a week. I sent him photos and had him take measurements to match not only the correct length and notch fitment, but also a groove to machine out to hold the retentive circlip. And the end result? *chef's kiss* Perfect. Since I didn't have pliers with me when I picked up the items, I tested the old gear and circlip on. Perfect fit. After that it was simply swapping out the plug bracket to the new sensor, mount it on the transfer case, refill with ATF/Nissan Matic Fluid D, then test out function. Thankfully with the rebuilt cluster and the new sensor, both the speedometer and odometer and now working properly!   And there you have it. About 5-6 weeks of headaches wrapped up in a 15 minute photo essay. As I was told it is rare for sensors of this generation to die so dramatically, but you never know what could go wrong with a 25+ year old car. I HOPE that no one else has to go through this problem like I did, so with my take on a solution I hope it helps others who may encounter this issue in the future. For the TL;DR: 1) Sensor breaks. 2) Find a replacement GTT/GTS-T sensor. 3) Find a CNC machinist to have you cut it down to proper specs. 4) Reinstall then pray to the JDM gods.   Hope this guide/story helps anyone else encountering this problem!
    • So this being my first contribution to the SAU forums, I'd like to present and show how I had to solve probably one of the most annoying fixes on any car I've owned: replacing a speedometer (or "speedo") sensor on my newly acquired Series 1 Stagea 260RS Autech Version. I'm simply documenting how I went about to fix this issue, and as I understand it is relatively rare to happen to this generation of cars, it is a gigantic PITA so I hope this helps serve as reference to anyone else who may encounter this issue. NOTE: Although I say this is meant for the 260RS, because the gearbox/drivetrain is shared with the R33 GTR with the 5-speed manual, the application should be exactly the same. Background So after driving my new-to-me Stagea for about 1500km, one night while driving home the speedometer and odometer suddenly stopped working. No clunking noise, no indication something was broken, the speedometer would just stop reading anything and the odometer stopped going up. This is a huge worry for me, because my car is relatively low mileage (only 45k km when purchased) so although I plan to own the car for a long time, a mismatched odometer reading would be hugely detrimental to resale should the day come to sell the car. Thankfully this only occurred a mile or two from home so it wasn't extremely significant. Also, the OCD part of me would be extremely irked if the numbers that showed on my dash doesn't match the actual ageing of the car. Diagnosing I had been in communication with the well renown GTR shop in the USA, U.P.garage up near University Point in Washington state. After some back and forth they said it could be one of two things: 1) The speedometer sensor that goes into the transfer case is broken 2) The actual cluster has a component that went kaput. They said this is common in older Nissan gauge clusters and that would indicate a rebuild is necessary. As I tried to figure out if it was problem #1, I resolved problem #2 by sending my cluster over to Relentless Motorsports in Dallas, TX, whom is local to me and does cluster and ECU rebuilds. He is a one man operation who meticulously replaces every chip, resistor, capacitor, and electronic component on the PCB's on a wide variety of classic and modern cars. His specialty is Lexus and Toyota, but he came highly recommended by Erik of U.P.garage since he does the rebuilds for them on GTR clusters.  For those that don't know, on R32 and R33 GTR gearboxes, the speedometer sensor is mounted in the transfer case and is purely an analog mini "generator" (opposite of an alternator essentially). Based on the speed the sensor spins it generates an AC sine wave voltage up to 5V, and sends that via two wires up to the cluster which then interprets it via the speedometer dial. The signal does NOT go to the ECU first, the wiring goes to the cluster first then the ECU after (or so I'm told).  Problems/Roadblocks I first removed the part from the car on the underside of the transfer case (drain your transfer case fluid/ATF first, guess who found out that the hard way?), and noted the transfer case fluid was EXTREMELY black, most likely never changed on my car. When attempting to turn the gears it felt extremely gritty, as if shttps://imgur.com/6TQCG3xomething was binding the shaft from rotating properly. After having to reflow the solder on my AFM sensors based on another SAU guide here, I attempted to disassemble the silicone seal on the back of the sensor to see what happened inside the sensor; turns out, it basically disintegrated itself. Wonderful. Not only had the electrical components destroyed themselves, the magnetic portion on what I thought was on the shaft also chipped and was broken. Solution So solution: find a spare part right? Wrong. Nissan has long discontinued the proper sensor part number 32702-21U19, and it is no longer obtainable either through Nissan NSA or Nissan Japan. I was SOL without proper speed or mileage readings unless I figured out a way to replace this sensor. After tons of Googling and searching on SAU, I found that there IS however a sensor that looks almost exactly like the R33/260RS one: a sensor meant for the R33/R34 GTT and GTS-T with the 5 speed manual. The part number was 25010-21U00, and the body, plug, and shaft all looked exactly the same. The gear was different at the end, but knowing the sensor's gear is held on with a circlip, I figured I could just order the part and swap the gears. Cue me ordering a new part from JustJap down in Kirrawee, NSW, then waiting almost 3 weeks for shipping and customs clearing. The part finally arrives and what did I find? The freaking shaft lengths don't match. $&%* I discussed with Erik how to proceed, and figuring that I basically destroyed the sensor trying to get the shaft out of the damaged sensor from my car. we deemed it too dangerous to try and attempt to swap shafts to the correct length. I had to find a local CNC machinist to help me cut and notch down the shaft. After tons of frantic calling on a Friday afternoon, I managed to get hold of someone and he said he'd be able to do it over half a week. I sent him photos and had him take measurements to match not only the correct length and notch fitment, but also a groove to machine out to hold the retentive circlip. And the end result? *chef's kiss* Perfect. Since I didn't have pliers with me when I picked up the items, I tested the old gear and circlip on. Perfect fit. After that it was simply swapping out the plug bracket to the new sensor, mount it on the transfer case, refill with ATF/Nissan Matic Fluid D, then test out function. Thankfully with the rebuilt cluster and the new sensor, both the speedometer and odometer and now working properly!   And there you have it. About 5-6 weeks of headaches wrapped up in a 15 minute photo essay. As I was told it is rare for sensors of this generation to die so dramatically, but you never know what could go wrong with a 25+ year old car. I HOPE that no one else has to go through this problem like I did, so with my take on a solution I hope it helps others who may encounter this issue in the future. For the TL;DR: 1) Sensor breaks. 2) Find a replacement GTT/GTS-T sensor. 3) Find a CNC machinist to have you cut it down to proper specs. 4) Reinstall then pray to the JDM gods.   Hope this guide/story helps anyone else encountering this problem!
    • perhaps i should have mentioned, I plugged the unit in before i handed over to the electronics repair shop to see what damaged had been caused and the unit worked (ac controls, rear demister etc) bar the lights behind the lcd. i would assume that the diode was only to control lighting and didnt harm anything else i got the unit back from the electronics repair shop and all is well (to a point). The lights are back on and ac controls are working. im still paranoid as i beleive the repairer just put in any zener diode he could find and admitted asking chatgpt if its compatible   i do however have another issue... sometimes when i turn the ignition on, the climate control unit now goes through a diagnostics procedure which normally occurs when you disconnect and reconnect but this may be due to the below   to top everything off, and feel free to shoot me as im just about to do it myself anyway, while i was checking the newly repaired board by plugging in the climate control unit bare without the housing, i believe i may have shorted it on the headunit surround. Climate control unit still works but now the keyless entry doesnt work along with the dome light not turning on when you open the door. to add to this tricky situation, when you start the car and remove the key ( i have a turbo timer so car remains on) the keyless entry works. the dome light also works when you switch to the on position. fuses were checked and all ok ive deduced that the short somehow has messed with the smart entry control module as that is what controls the keyless entry and dome light on door opening   you guys wouldnt happen to have any experience with that topic lmao... im only laughing as its all i can do right now my self diagnosed adhd always gets me in a situation as i have no patience and want to get everything done in shortest amount of time as possible often ignoring crucial steps such as disconnecting battery when stuffing around with electronics or even placing a simple rag over the metallic headunit surround when placing a live pcb board on top of it   FML
    • Bit of a pity we don't have good images of the back/front of the PCB ~ that said, I found a YT vid of a teardown to replace dicky clock switches, and got enough of a glimpse to realize this PCB is the front-end to a connected to what I'll call PCBA, and as such this is all digital on this PCB..ergo, battery voltage probably doesn't make an appearance here ; that is, I'd expect them to do something on PCBA wrt power conditioning for the adjustment/display/switch PCB.... ....given what's transpired..ie; some permutation of 12vdc on a 5vdc with or without correct polarity...would explain why the zener said "no" and exploded. The transistor Q5 (M33) is likely to be a digital switching transistor...that is, package has builtin bias resistors to ensure it saturates as soon as base threshold voltage is reached (minimal rise/fall time)....and wrt the question 'what else could've fried?' ....well, I know there's an MCU on this board (display, I/O at a guess), and you hope they isolated it from this scenario...I got my crayons out, it looks a bit like this...   ...not a lot to see, or rather, everything you'd like to see disappears down a via to the other side...base drive for the transistor comes from somewhere else, what this transistor is switching is somewhere else...but the zener circuit is exclusive to all this ~ it's providing a set voltage (current limited by the 1K3 resistor R19)...and disappears somewhere else down the via I marked V out ; if the errant voltage 'jumped' the diode in the millisecond before it exploded, whatever that V out via feeds may have seen a spike... ....I'll just imagine that Q5 was switched off at the time, thus no damage should've been done....but whatever that zener feeds has to be checked... HTH
×
×
  • Create New...