Jump to content
SAU Community

Recommended Posts

hey fellas

just got my gtr back the other week and im having dramas

iv replaced the standard turbos with 2530s and what the car is doing is when crusing in some times 4th but mainly 5th gear at 3000rpm u start to put ur foot down to acelerate to keep up with trafic as the boost starts to rise and engin revs reach 3000rpm the turbos start surging like fighting each other pushing air back and forth in to the air flow meters cauing it to dump a shit load of fuel u can put ur foot flat to the floor and it keeps on doing it the car doesnt go any where and this problem only occurs when crusing but under full throttle in lower gears its fine car produces 275 rwk i have other mods which include

power fc

sard 700cc inj

air filter piping kit

hks filters

hks pump

greddy inlet plenum

plazmaman cooler

hks cam gears ( still set to 0 deg)

standard afm's

hks reg

tommie fuel rail

hks dumps

hks exaust

5 inch cat

sard single bov

car is running 14 psi boost

if any one knows of this problem or has incountered it before your help would be greatly appreciated

regards

anthony

Link to comment
https://www.sau.com.au/forums/topic/120755-gtr-hks-2530s-problem/
Share on other sites

its known as compressor chuffing or shuffling

do a search on it, its been covered before

the custom air filter piping kit is the likely cause of the issue

also the stock bovs will be much better than the single sard, throw that in the bin.

try with the stock bovs connected and see if the problem still occurs

a quick elmination would be to take off the pods and piping kit for the pods and just drive around the block with the airflow meters opened mouthed. see if it occurs, if it does, then its the removal of stock bovs.

if the problem goes away its likely the pods / piping kit may be the gremlin

what did they do exactly? on the certain load points where it wold surge, was it a timing or inj change?

Can't give you a definate answer on that one, suffice to say the car was a little frustrating to drive beforehand and smooth as factory after. Give Croydon's a call and chat to Jim about it, as im sure he could explain what he did to the tune to overcome it.

you need to make the piping the same length from each turbo to the airflow meters.

but thats abit tricky.

also having a balance pipe joining the two intakes together helps aswell.

and yes no bov woks as quickly as the stockers . there sweet :thumbsup:

you need to make the piping the same length from each turbo to the airflow meters.

but thats abit tricky.

also having a balance pipe joining the two intakes together helps aswell.

and yes no bov woks as quickly as the stockers . there sweet :thumbsup:

Yes we have a balance pipe between the two intakes but it was there all the time, the two intakes are of different length. He almost tuned the shuffle out of the GT-RS turbo's now fitted and is confident of having it sorted once we put the balance pipe between the two exhaust manifolds.

Yes we have a balance pipe between the two intakes but it was there all the time, the two intakes are of different length. He almost tuned the shuffle out of the GT-RS turbo's now fitted and is confident of having it sorted once we put the balance pipe between the two exhaust manifolds.

So your adding the balance pipe now. Will be good to see the Diff

Create an account or sign in to comment

You need to be a member in order to leave a comment

Create an account

Sign up for a new account in our community. It's easy!

Register a new account

Sign in

Already have an account? Sign in here.

Sign In Now


  • Similar Content

  • Latest Posts

    • Maybe they'll look to do a bunch of presales to help inject some cash fast for their financial issues...
    • Does it also misfire equally when revving?   Josh is very correct in what you should do. The coilpack harness wiring loom itself is a known problem due to its age and the number of heat cycles it has gone through. Throwing parts at a vehicle to diagnose the issue isn't a smart or good way to do it. Secondly, you may have a bad coil pack, you pop replacements in, they fix that issue, but messing with the harness breaks it, so the issue persists. So now you think "well it wasn't the coil packs" and have to continue chasing your tail, potentially swapping back in your shit coil packs and returning the good ones (yes, I've seen people do this because 'it wasn't the problem' and they want to save money). And suddenly, you've got two issues with the same symptoms...   Diagnose, don't use the spare parts shotgun.
    • Well the articals keep saying a Q50s (Skyline in Japan) with a new Manual gearbox. I like the talk about the new looks with the round tail lights. I hope they bring back the retro look like they did with the Z
    • Off the back of feedback we have decided to mix up this next Motorkhana at Avalon to have some targeted skills practice for beginners to advanced. Saturday 6th September 2025 8:30am Capped 26 entries Standard Entry Fee: $89 Members Entry Fee: $55 (SAU Victoria Only) Entries Close: Friday 5th February  Where: 55 beach road Avalon. https://maps.app.goo.gl/HNUE3EuNue3sJxh38 Entries: Limited to 26 entrants (Passengers allowed over the age of 14 with a signed disclaimer and same safety gear) Disclaimer: Download  Please electronically sign and email to [email protected] or print and hand in and Driver Sign In. To compete in this event you will require A valid  AASA General Speed licence or (Day license via the AASA Website for $50) MA Licenses are no longer accepted by AASA https://aasa.com.au/  A helmet, long sleeve clothing and a 1KG mounted fire extinguisher recommended (But not Mandatory). Further details within Supp Regs on the enty link. Entry Link > https://www.sauvic.com.au/entry/deca/20250906 You can bring and have a passenger in the car but they need to comply to the same safety and clothing as driver. Bring your car and get to battle others, win, lose or draw. I can guarantee you will have lots of fun. Any questions email [email protected] Entry List: 1.Anna S 2. Luke S 3. Jesse Givens-Lamb 4. Luca Stamatescu 5. Madeleine Stamatescu    
    • Wanna rewrite all of that in, say, 2 or 3 separate sentences, so that we can read it?
×
×
  • Create New...