Jump to content
SAU Community

Recommended Posts

Hello all,

Just helping out my nephew with a problem he is having.

He has taken his car back to the workshop 3 times and still has a problem with overheating.

Can you unblock a radiator by flushing it?

Can you have a air blockage if the thing has not been bleed properly?

Is there any other sorts of things that can be causing this re-occuring problem?

Thanks in advance

:D

Link to comment
https://www.sau.com.au/forums/topic/139794-over-heating-on-gtr32/
Share on other sites

You can reverse flush your cooling system, id be getting the radiator professionally done by the proper people as they have special equipment for all that which wont damage the radiator.

Yes you can have a air pocket stuck in the cooling system, If any of the pipes are above the motor they can get an airpocket in them, you should gently push down on the pipe if its higher than the motor to make it level while the engine is running the pocket should bleed itself out with the radiator cap removed.

Could also be a faulty thermostat, radiator pressure cap umm thats all i can think of at the moment, possible water pump??? i guess if its ceased.... not too sure on that one.

Cap, air-pocket,thermo,or pump.....any more.

Surely water pumps can't cease?

yeh they can.

Check around the pump for signs of water leaking out.

Water gets out-air gets in!!

I had slight water usage just before destroying an engine due to a head gasket that had corroded thru from the water jacket to the combustion chamber.

Used a slight amount of water before going bang.

Good luck lets us know wat u find.

. Check radiator cap see if seal still good, only cost $10-20 for a new one.

. Check for signs of leakage from water pump.

. Pull radiator out, send it to a Radiator shop for removal of of tank and a good flush.

. When re-fill coolant, jack the car up a bit, runs heater at full blast, bleed coolant from the screw on the engine block.

. Check or test Thermal Stat.

. Still don't work, a leak down test will tell.

Cap, air-pocket,thermo,or pump.....any more.

Surely water pumps can't cease?

No, they SEIZE. (Well, I guess when they seize, they cease.)

But the Japs are famous for not using inhibitor in their cars, and the blades on the pump impeller corrode away - that's the more usual problem.

He has taken his car back to the workshop 3 times and still has a problem with overheating.

Can you unblock a radiator by flushing it?

I believe radiator shops take the tanks off the ends and clear out any blockage by simply pushing metal rods through the core. I havent got a std radiator in mine so i'm not sure whether they can have this treatment.

Also, to check the thermostat just put it in a sausepan of warm water on the stove with a thermometer and check that it opens at the right temperature (cant remember what that is tho).

Rgs,

Kot

lol yeah i really am a girl

and yeah with what mr kotter said i think from memory it could be around 50-60degrees, but check on that, beacuse i could be waay off

Thanks I will see if its the thermostate then.

;)

  • 3 weeks later...

Stock gtr thermostat opens at 76.5c Most engines thermostats open much later..

Elk: No, they SEIZE. (Well, I guess when they seize, they cease.)

LOL

Yeah ive seen plenty of them seize.

Id first be checking your overflow bottle level, if its low do a presure test on the system. If not run the engine and check that both lower and upper radiator hoses get hot meaning the thermostat has opened. leave the cap off during this period making sure there are no more air bubbles coming out before you put it back on..can take upto10 mins or more.. Give the engine a rev to help circulate the coolant and remove air pockets.. Once this is done then check to make sure your fan clutch is grabbing once hot enough. If he has overheated it bad enough there is a good chance you have screwed the head gasket too.. Possibly do a Co2 test to confirm.

Deren

Edited by Godzilla32

Create an account or sign in to comment

You need to be a member in order to leave a comment

Create an account

Sign up for a new account in our community. It's easy!

Register a new account

Sign in

Already have an account? Sign in here.

Sign In Now


  • Similar Content

  • Latest Posts

    • Thanks for all the replies fellas. Gonna finish putting it back together and see how it handles the set up. If it starts pinging it’ll be parked.
    • Well, I can recommend the partial AV system translation CD I ordered from Car Audio Workshop in NZ. Whilst it didn't address the date issue, it has conveniently translated on-screen menu items into English, and now allows the GPS-received time to be offset in hours rather than minutes, so I can display Eastern Australian time accurately ( and bump it by another hour when daylight savings starts ).
    • Yuh, if it's 45°C outside, my car is driving in it.
    • I'd be curious to hear more. Otherwise, have you driven a modern x-trail? I wonder how it compares. Here in Australia they are/were popular for rentals and fleet vehicles. I have been in some and my impression was they are bad. But, this may have been very different in the 2000s at a good trim level. Twenty years is plenty of time to make the model worse. I do very much agree with the 2 silver cars in the garage approach. But, not driving because it's too hot would not leave a lot of time in the year for many Australians. I don't think you need to worry too much unless the car has actual issues with overheating. 
    • Back again. I returned to Japan in Jul/Aug to spend time with the car on my birthday and remind myself what all the sacrifice and compromise is for. It happened to line up with the monthly morning meet in Okutama, which I have been wanting to go to for a long time. It's a unique event at a unique spot with really rare, interesting, and quirky cars. It's where all the oldheads and OGs gather. The nighttime scene at DKF certainly has its place and should be experienced if you're into cars, but there's too much bad attention and negativity around it now. IMO the better time is Sunday morning at DKF or Okutama; it's more chill and relaxed. I'm glad I was finally able to go, but not sure it's worth the drive from all the way from Nagoya immediately the day before, unless I was already staying in Tokyo for the days right before the meet, because you have to wake up quite early to make it in time. Funnily enough though I didn't drive the car all that much this trip because it was just too damn hot. While there were zero issues and running temps were nominal and the A/C was strong, RBs already run crazy hot as it is. Sure, it took it all like a champ but something about driving these cars in the ridiculous heat/humidity bothers me and makes me feel like I'm asking too much of it. I'm just me being weird and treating the car like a living thing with feelings; I'm mechanically sympathetic to a fault. Instead I was mainly driving something else around - a KX4(silver) 2001 X-Trail GT, that I acquired in May. There's a few different flavors to choose from with Xs, but visually it's the Nissan version of the Honda CR-V. Mechanically it's a whole different story as this, being the top-trim GT, has an SR20VET mated to a four-speed auto and full-time AWD! It was a very affordable buy in exceptional condition inside and out, with very low mileage...only 48k kms. Most likely it was owned by an older person who kept it garaged and well-maintained, so I'm really happy with how it all worked out. It literally needs zero attention at the moment, albeit except for some minor visual touch-ups. I wanted something quirky, interesting, and practical and for sure it handily delivers on all three of those aspects. I was immediately able to utilize the cargo and passenger capacity to its full extent. It's a lot of fun to drive and is quite punchy through 1st and 2nd. It's very unassuming -in the twisty bits it's a lot more composed than one would think at a glance- and it'll be even better once I get better tires on it(yes, it's an SUV but still a little boat-y for my liking). So...now I have two golden-era Nissans in silver. One sports car and one that does everything else; the perfect two-car solution I think👍 The rest of the trip...I was able to turn my stressed brain off and enjoy it, although I didn't quite get to do as much as I thought. I did some interesting things, met some interesting people, and happened into some interesting situations however, that's all for another post though only if people really want to know. Project-wise, I went back to Mine's again to discuss more plans and am hoping to wrap that up real soon; keep watching this space if that interests you. Additionally, while working in the tormenting sweatbox that is the warehouse, I was able to organize most of the myriad of parts that my friend is storing for me along with the cars, and the 34 has a nice little spot carved out for it: And since it can get so stupid hot in there, that made it all the more easy -after I was standing there looking at the car and said 'f**k it'- to finally remove all the damn gauges that have mostly been an eyesore all this time. Huzzah. The heat basically makes the adhesive backing on the gauge mounts more pliable to work with, so it was far less stressful getting this done. I didn't fully clean it up or chase the wiring though; that will happen once I have the car in closer possession. Another major reason to remove all that stuff is to give people less reasons to get in my car and steal s**t while it's being exported/imported when/if the time comes, which leads us to my next point... ...and that is even though it's time in Japan is technically almost up since it's a November car and the X would be coming in March, I'm still not entirely sure where my life and career is headed; I don't really know what the future looks like and where I'm going to end up. I feel there's a great deal of uncertainty with me and as a result of that, it feels like I'm at a crossroads moreso now than any point in my life thus far and there are some choices I need to make. Yes, I've had some years to consider things and prepare myself, however too much has happened in that time to maintain confidence and everything feels so up in the air; tenuous one might say. Simply put, there's just too much nonsense going on right now from multiple vectors. Admittedly, I'm struggling to stay in the game and keep my eyes on the prize. So much so in fact, that very recently I came the closest I ever have before to calling it quits outright; selling everything and moving on and not looking back. The astute among you will pick up on key subtext within this paragraph. In the meantime I've still managed to slowly acquire some final bits for the car, but it feels nice knowing there's not much left to get and I'm almost across that finish line; I have almost everything I'll ever want for my interpretation and expression on what it is I think an R34 should be. 'til later.
×
×
  • Create New...