Jump to content
SAU Community

Recommended Posts

It's not far off. Waiting on a silicon hose for the oil drain and just have to finish off the head drain hose

Few little things then have to put the turbo and manifold on the old engine before it comes out to workout the wastegate placement and dump pipe but that shouldnt be a big deal :)

Who has got tyres fitted to wheels before (with you supplying the tyres)?

Ordered some new rears for my car today and will need someone to fit and balance them next week

Where do I got? Thinking Paget discount tyres or whatever there called might be the go but not 100% sure

Yep his whole garage is now a tyre shop/fitting shop haha it's hillarious.

Got my new gearbox clutch and flywheel fitted yesterday, car drives great. Clutch is so much lighter compared to the old HD exedy. It's making a little bit of a grind/rubbing sound when i engage it though, could just be wearing in but i'm getting leon to check over it again today and go from there. Happy with the results though!

Ok so i took the car back to Leon, he had a drive and he thinks it's the copper mix clutch. It makes a bit of a rubbing sound when the clutch is in changing gears. Just trying to find something on the internet with someone else having the same experience with this clutch

Pretty sure it's a pull type Cal. The noise appears when the clutch is fully engaged and changing gears. When the clutch is held in for about 3 seconds or more the noise stops. Yes there is a brand new throw out bearing in the car too. A couple of people i've spoken to think it's part of the wear in stage of a clutch, and the noise should dissapear after 500-1000km. I don't think the noise has anything to do with something not being installed correctly because everything is very smooth and no problems at all.

Yeah it could be just wear in. If your putting the clutch in and the noise disappears in 3 secs or so then whatever it is, is spinning with the gearbox so clutch plate would be

Email or call exedy and ask them if its worrying you

that's what Coz said from Conceptz. he said give it 500 miles then contact him again. I also asked him to contact the supplier for me, he's usually very helpful so i'll leave it for him to do for me. Is it possible the system wasn't bled correctly or something? there's brand new clutch fluid in there. I'm just trying to account for everything and narrow down to what the issue could be. Fingers crossed it's not a faulty clutch, Coz has never heard of this sound coming from the southbend clutch/flywheel setup. I guess time will tell!

This Power FC thing is doing my head in. My new one came the other day and I had time today to play around with it. It has the exact same issue. I'm hoping at least since I bought this new I can get some support from Apexi this time. I've tried just about everything I can think of now. Have emailed FC-Datalogit as well hoping that one of thier users has encountered the same issue

I might be heading for a Link at this rate, I'm not prepared to put up with the issue it has, as its annoying enough with the setup I have now, the lack of timing is gonna be worse with a bigger turbo and bigger cams.

Have yet another gauge to fit in my car somewhere now. Got my oil pressure gauge today. The sensor also doesnt fit in the block, both 1/8 threads but it looks like the sensor is NPT and the Block is BSPT. Went to pirtek for an adapter, and he couldnt find one and said just tap it out or put a spanner on it.... lol

finally after calling literally 9 different florists i've managed to get some ordered and delivered today.. let's just hope it actually gets to my mrs work before she leaves. shouldn't of left it til the last day though lol..

Create an account or sign in to comment

You need to be a member in order to leave a comment

Create an account

Sign up for a new account in our community. It's easy!

Register a new account

Sign in

Already have an account? Sign in here.

Sign In Now



  • Similar Content

  • Latest Posts

    • Next on the to-do list was an oil and filter change. Nothing exciting to add here except the oil filter is in a really stupid place (facing the engine mount/subframe/steering rack). GReddy do a relocation kit which puts it towards the gearbox, I would have preferred towards the front but there's obviously a lot more stuff there. Something I'll have to look at for the next service perhaps. First time using Valvoline oil, although I can't see it being any different to most other brands Nice... The oil filter location... At least the subframe wont rust any time soon I picked up a genuine fuel filter, this is part of the fuel pump assembly inside the fuel tank. Access can be found underneath the rear seat, you'll see this triangular cover Remove the 3x plastic 10mm nuts and lift the cover up, pushing the rubber grommet through The yellow fuel line clips push out in opposite directions, remove these completely. The two moulded fuel lines can now pull upwards to disconnect, along with the wire electrical plug. There's 8x 8mm bolts that secure the black retaining ring. The fuel pump assembly is now ready to lift out. Be mindful of the fuel hose on the side, the hose clamp on mine was catching the hose preventing it from lifting up The fuel pump/filter has an upper and lower section held on by 4 pressure clips. These did take a little bit of force, it sounded like the plastic tabs were going to break but they didn't (don't worry!) The lower section helps mount the fuel pump, there's a circular rubber gasket/grommet/seal thing on the bottom where the sock is. Undo the hose clip on the short fuel hose on the side to disconnect it from the 3 way distribution pipe to be able to lift the upper half away. Don't forget to unplug the fuel pump too! There's a few rubber O rings that will need transferring to the new filter housing, I show these in the video at the bottom of this write up. Reassembly is the reverse Here's a photo of the new filter installed, you'll be able to see where the tabs are more clearing against the yellow OEM plastic Once the assembly is re-installed, I turned the engine over a few times to help build up fuel pressure. I did panic when the car stopped turning over but I could hear the fuel pump making a noise. It eventually started and has been fine since. Found my 'lucky' coin underneath the rear seat too The Youtube video can be seen here: https://www.youtube.com/watch?v=uLJ65pmQt44&t=6s
    • It was picked up on the MOT/Inspection that the offside front wheel bearing had excessive play along with the ball joint. It made sense to do both sides so I sourced a pair of spare IS200 hubs to do the swap. Unfortunately I don't have any photos of the strip down but here's a quick run down. On the back of the hub is a large circular dust cover, using a flat head screw driver and a mallet I prised it off. Underneath will reveal a 32mm hub nut (impact gun recommended). With the hub nut removed the ABS ring can be removed (I ended up using a magnetic pick up tool to help). Next up is to remove the stub axle, this was a little trickier due to limited tools. I tried a 3 leg puller but the gap between the hub and stub axle wasn't enough for the legs to get in and under. Next option was a lump hammer and someone pulling the stub axle at the same time. After a few heavy hits it released. The lower bearing race had seized itself onto the stub axle, which was fine because I was replacing them anyway. With the upper bearing race removed and the grease cleaned off they looked like this The left one looked pristine inside but gave us the most trouble. The right one had some surface rust but came apart in a single hit, figure that out?! I got a local garage to press the new wheel bearings in, reassemble was the opposite and didn't take long at all. Removing the hub itself was simple. Starting with removing the brake caliper, 2x 14mm bolts for the caliper slider and 2x 19mm? for the carrier > hub bolts. I used a cable tie to secure the caliper to the upper arm so it was out of the way, there's a 10mm bolt securing the ABS sensor on. With the brake disc removed from the hub next are the three castle nuts for the upper and lower ball joints and track rod end. Two of these had their own R clip and one split pin. A few hits with the hammer and they're released (I left the castle nuts on by a couple of turns), the track rod ends gave me the most grief and I may have nipped the boots (oops). Fitting is the reversal and is very quick and easy to do. The lower ball joints are held onto the hub by 2x 17mm bolts. The castle nut did increase in socket size to 22mm from memory (this may vary from supplier) The two front tyres weren't in great condition, so I had those replaced with some budget tyres for the time being. I'll be replacing the wheels and tyres in the future, this was to get me on the road without the worry of the police hassling me.
    • Yep, the closest base tune available was for the GTT, I went with that and made all the logical changes I could find to convert it to Naturally Aspirated. It will rev fine in Neutral to redline but it will be cutting nearly 50% fuel the whole way.  If I let it tune the fuel map to start with that much less fuel it wont run right and has a hard time applying corrections.  These 50% cuts are with a fuel map already about half of what the GTT tune had.  I was having a whole lot of bogging when applying any throttle but seem to have fixed that for no load situations with very aggressive transient throttle settings. I made the corrections to my injectors with data I found for them online, FBCJC100 flowing 306cc.  I'll have to look to see if I can find the Cam section. I have the Bosch 4.9 from Haltech. My manifold pressure when watching it live is always in -5.9 psi/inHg
    • Hi My Tokico BM50 Brake master cylinder has a leak from the hole between the two outlets (M10x1) for brake pipes, I have attached a photo. Can anyone tell me what that hole is and what has failed to allow brake fluid to escape from it, I have looked on line and asked questions on UK forums but can not find the answer, if anyone can enlighten me I would be most grateful.
    • It will be a software setting. I don't believe many on here ever used AEM. And they're now a discontinued product,that's really hard to find any easy answers on. If it were Link or Haltech, someone would be able to just send you a ECU file though.
×
×
  • Create New...