Jump to content
SAU Community

Recommended Posts

I'll start off with mods:

RB20DET

R33 S1 Turbo (R32 actuator)

JJR FMIC

GFB Stealth FX BOV

POD

When I was running my standard R32 turbo, FMIC and POD, on my boost gauge it would read 10psi with standard BOV. Once I fitted the GFB one, boost rose to 12psi all the way to redline.

Now that I have fitted the R33 turbo with R32 acuator (no boost controller whatsoever) boost under full load at about 5-6000rpm hits a peak of 15psi.

I've tee'd the acuator hose into the hose that comes off the crossover pipe to the bov. It's about 30cm long and I've got a feeling this might be a cause rather then the standard r32 acuator as it wasn't a problem before??

Cheers.

Link to comment
https://www.sau.com.au/forums/topic/180595-r32-acuator/
Share on other sites

he has already said what causes it..

it's the extra long hose to the actuator.

if it was a short hose from the actuator to say the comp cover like the stock R32 turbo or even to the intercooler pipe near the turbo, boost will be around 11-12psi as per stock setup.

now go get a remap of the stock ECU.

I think CEFFIE on these forums should do this for a living.

he know's the RB20 well and can get some decent numbers form them.

free plug for CEFFIE

Link to comment
https://www.sau.com.au/forums/topic/180595-r32-acuator/#findComment-3283542
Share on other sites

it's not the culprit. Like I said, I have 120 cm of vac line between my actuator and the boost source. Runs 11 psi day in day out

We posted at almost the same time..

I think it has something to do with my BOV because checked clearances of the acuator before fitment. I'm going to put stock BOV on and see what reading i get.

Link to comment
https://www.sau.com.au/forums/topic/180595-r32-acuator/#findComment-3283823
Share on other sites

Definitely nothing to do with bov.

Everything to do with boost control. That being the boost source, actuator, the flapper and the dump. My bets are on the jjr dump fouling with the wastegate slightly.

The rb20 turbo's are known for falling over at high rev's; they drop boost.

The rb25 turbo's are just that little bit bigger on the compressor side so they require better wastegate flow to keep boost under wraps.

A bloke only the other week had the same issue with his split dump. It wasn't until he removed the dump that he realised the dump was indeed preventing the wastegate from opening fully.

Link to comment
https://www.sau.com.au/forums/topic/180595-r32-acuator/#findComment-3284174
Share on other sites

If you read my previous post, i dummy fitted the r33 turbo with r32 acuator to the dump prior to installation and it didnt foul.

I even ran the dump on the standard rb20 turbo with rb20 acuator without and problems. Held 12psi the hole time.

Link to comment
https://www.sau.com.au/forums/topic/180595-r32-acuator/#findComment-3284447
Share on other sites

If you read my previous post, i dummy fitted the r33 turbo with r32 acuator to the dump prior to installation and it didnt foul.

I even ran the dump on the standard rb20 turbo with rb20 acuator without and problems. Held 12psi the hole time.

You said checked the clearances of the actuator. The actuator is not the wastegate :D

With regards to the rb20 turbo; smaller compressor; they are known for falling over at high rpm so its unlikely you would see it overboosting easily.

The rb25 turbo on the other hand is different kettle of fish, flowing more air making more power more air has to be bypassed.

I really think you should go back and have another look at the dump/wastegate.

Wire the wastegate completely open and see if it still makes boost up top.

Obviously it will be as laggy as shiet but up over 5500-6000rpm you will see it making some boost; how much boost 15psi? 6psi? If it still makes the 15psi then its 10000000% the dump fouling the wastegate. Even slightly fouling can cause problems.

Long runs of hose to the actuator creates issues with boost spike.

Link to comment
https://www.sau.com.au/forums/topic/180595-r32-acuator/#findComment-3284493
Share on other sites

Wire the wastegate completely open and see if it still makes boost up top.

Obviously it will be as laggy as shiet but up over 5500-6000rpm you will see it making some boost; how much boost 15psi? 6psi?

Ok I'll check this this arvo/tonight. Can I disconnect the actuator pipe and wire the flap open? Should I then see the regulated 10-12psi at 5-6000 rpm?

Link to comment
https://www.sau.com.au/forums/topic/180595-r32-acuator/#findComment-3285567
Share on other sites

Create an account or sign in to comment

You need to be a member in order to leave a comment

Create an account

Sign up for a new account in our community. It's easy!

Register a new account

Sign in

Already have an account? Sign in here.

Sign In Now


  • Similar Content

  • Latest Posts

    • And now to the front.  No pics of the 3 nuts holding the front struts on, they are easy to spot. Undo 2 and leave the closest one on loosely. Underneath we have to deal with the wiring again, but this time its worse because the plug is behind the guard liner. You'll have to decide how much of the guard liner to remove, I undid the lower liner's top, inside and lower clips, but didn't pull it full off the guard. Same issue undoing the plug as at the rear, you need to firmly push the release clip from below while equally firmly gripping the plug body and pulling it out of  the socket. I used my fancy electrical disconnect pliers to get in there There is also one clip for the wiring, unlike at the rear I could not get behind it so just had to lever it up and out.....not in great condition to re-use in future.
    • Onto the rear lower shock mount. It's worth starting with a decent degrease to remove 10+ years of road grime, and perhaps also spray a penetrating oil on the shock lower nut. Don't forget to include the shock wiring and plug in the clean.... Deal with the wiring first; you need to release 2 clips where the wiring goes into the bracket (use long nose pliers behind the bracket to compress the clip so you can reuse it), and the rubber mount slides out, then release the plug.  I found it very hard to unplug, from underneath you can compress the tab with a screwdriver or similar, and gently but firmly pull the plug out of the socket (regular pliers may help but don't put too much pressure on the plastic. The lower mount is straightforward, 17mm nut and you can pull the shock out. As I wasn't putting a standard shock back in, I gave the car side wiring socket a generous gob of dialectric grease to keep crap out in the future. Putting the new shock in is straightforward, feed it into at least 1 of the bolt holes at the top and reach around to put a nut on it to hold it up. Then put on the other 2 top nuts loosely and put the shock onto the lower mounting bolt (you may need to lift the hub a little if the new shock is shorter). Tighten the lower nut and 3 upper nuts and you are done.  
    • You will now be able to lift the parcel shelf trim enough to get to the shock cover bolts; if you need to full remove the parcel shelf trim for some reason you also remove the escutcheons around the rear seat release and you will have to unplug the high stop light wiring from the boot. Next up is removal of the bracket; 6 nuts and a bolt Good news, you've finally got to the strut top! Remove the dust cover and the 3 shock mount nuts (perhaps leave 1 on lightly for now....) Same on the other side, but easier now you've done it all before
    • OK, so a bunch of trim needs to come off to get to the rear shock top mounts. Once the seat is out of the way, the plastic trim needs to come off. Remove 2 clips at the top then slide the trim towards the centre of the car to clear the lower clip Next you need to be able to lift the parcel shelf, which means you need to remove the mid dark trim around the door, and then the upper light trim above the parcel shelf. The mid trim has a clip in the middle to remove first, then lift the lowest trim off the top of the mid trim (unclips). At the top there is a hidden clip on the inner side to release first by pulling inwards, then the main clip releases by pulling the top towards the front of the car. The door seal comes off with the trim, just put them aside. The the lighter upper trim, this is easy to break to top clips so take it carefully. There is a hidden clip towards the bottom and another in the middle to release first by pulling inwards. Once they are out, there are 3 clips along the rear windscreen side of the panel that are hard to get under. This is what the rear of the panel looks like to assist:
    • Yes. Autos typically work from the speed sensor on the pinion shaft of the diff. I also think that even if you have a proper speed sensor for the bog manual in the manual box, that the signal it outputs is not compatible with the auto dash anyway. You should consult that manual (the book, not the gearbox).
×
×
  • Create New...