Jump to content
SAU Community

Recommended Posts

How do you get around the air flow cut ? is the ecu remapped at all? like one of those jap ones?

good work... will you do mine for $150 ? :(

I have an interesting theory on the air flow cut...That is that the air flow cut only operates at around 4000rpm...so if the airflow is under the threshold at 4000 rpm (or whatever the rpm setpoint is), but then increases after that, the ECU doesn't react. ie the airflow cut is only actively monitoring airflow at one point in the rev range...

So if you had a boost vs rpm curve where the boost is under the airflow cut limit at 4000 rpm but then increases after 4000 rpm you effectively bypass the airflow cut...I discovered this accidently one time when I had a boost spiking problem. I was using a cheapshit chinese t3/t4 and the hole in the turbine housing for the WG was too small...This was causing the boost to keep increasing becuase the WG could not bleed off enough exhaust...(Now I use a genuine Garrett GT3076R)

Now what I found was that when the boost would spike up to about 1.3 bar in the 6000-7000 rpm range and I would still not hit airflow cut??...When I fixed the boost spike problem and ended up with a lot flatter boost control I would hit airflow cut quite severley (at about 4000rpm lose 100% power) even at 1.1 bar...As soon as dropped off the boost to 0.9bar there was no problem at 4000rpm or any other rpm point.

In thinking about the airflow cut and what it is meant to achieve, I thought this makes sense...The standard ECU is designed with safety feartures to protect against detonating the engine due to bad fuel and or other component failures...A very common mode of failure is WG actuator failing to open due to disconnection of hose, damage to the hose or WG jamming closed...With standard turbo setup full boost is achieved at say 3000rpm and can really spike up to high boosts very quickly. The air flow cut 'I think' is designed to protect the engine should this factory boost control fail. I dont think it is a protection against people putting doing heaps of mods...As soon as obvious mods are done the factory warranty is voided and it is no longer Nissans problem...

So based on this a smaller turbo is more likely to create an airflow cut problem than a bigger turbo would. Ie Turbo lag from large turbo helps you get past or underneath the airflow cut at 4000rpm... ie smaller turbos make peak boost right at the point where air flow is active and large turbos dont...

Now what I have done is use about 4deg retard on exhaust to change the spool characteric of the turbo...ie taken out a bit of mid range efficiency so that the airflow at 4000rpm doesn;t exceed the airflow cut parameter. Then above 4000rpm it all starts to work..

  • Replies 82
  • Created
  • Last Reply

Top Posters In This Topic

just a quick question, where abouts do you buy them steel straps that u use to hold your heat wrap on?

The straps are called Panduit straps...They are the same straps that they use for CV boots sometimes.... Not that you would but they would be nearly good enough for IC piping..I have a tool that tensions them as well...Tool is worth about $300 though...

They are awesome and I have never had one let go...

So based on this a smaller turbo is more likely to create an airflow cut problem than a bigger turbo would. Ie Turbo lag from large turbo helps you get past or underneath the airflow cut at 4000rpm... ie smaller turbos make peak boost right at the point where air flow is active and large turbos dont...

Boost pressure and airflow are not necessarily directly related. There are a lot of other factors including the compressor size that will have a large impact on how much air will pass through the AFM. A smaller compressor will have lesser flow capability, all else constant, than a larger compressor. So assuming the AFM measures air flow, and Nissan's ECU is programmed to not like high flow values, the bigger turbo will create more problems.

The ECU actively monitors the voltage output from the AFM throughout the operating range of the engine and uses it to ...well..run the engine. It doesn't guess how much fuel is needed to get programmed air fuel ratios.

Edited by govich
that is so damn bollocksing coool man!!! i been thinking about doing a mod like this for years now, except i was going to run a cat on it and run it all the way to the rear of the car to try and make it legal.

'cept, if you weren't on the gate a whole heap, the cat wouldn't get up to temperature and work properly anyway

Boost pressure and airflow are not necessarily directly related. There are a lot of other factors including the compressor size that will have a large impact on how much air will pass through the AFM. A smaller compressor will have lesser flow capability, all else constant, than a larger compressor. So assuming the AFM measures air flow, and Nissan's ECU is programmed to not like high flow values, the bigger turbo will create more problems.

The ECU actively monitors the voltage output from the AFM throughout the operating range of the engine and uses it to ...well..run the engine. It doesn't guess how much fuel is needed to get programmed air fuel ratios.

At constant boost presssure, air flow into the engine will increase with increasing engine rpm...The reason I refer to boost pressure is that the control regime for the turbo is based on boost pressure and not airflow..ie a boost pressure feedback regime is used as opposed to airflow feedback to control WG

Anyway what I am saying is that Nissan's ECU airflow cut is only active at around 4000rpm... It is definitely not active above 6500rpm because this is the region where I get a constant 5.12V airflow signal right up to rev limit...I am actually saturating the air flow input (more commonly referred to by some as maxing out)...5.12V corresponds to the maximum voltage that the Nissan ECU's A-D convertor will register....Now at this point in time the ECU is on its air flow upper limit but the engine is still pulling hard...ie no ignition cut or anything...Therefore airflow cut in the 6500-7000rpm range is not active and my guess is that it is active around 4000rpm only...

All that said I look forward to the day I dont have to play tricks and games with the stock ECU and make some real kW :domokun:

Anyway what I am saying is that Nissan's ECU airflow cut is only active at around 4000rpm... It is definitely not active above 6500rpm because this is the region where I get a constant 5.12V airflow signal right up to rev limit...I am actually saturating the air flow input (more commonly referred to by some as maxing out)...5.12V corresponds to the maximum voltage that the Nissan ECU's A-D convertor will register....Now at this point in time the ECU is on its air flow upper limit but the engine is still pulling hard...ie no ignition cut or anything...Therefore airflow cut in the 6500-7000rpm range is not active and my guess is that it is active around 4000rpm only..

Fair enough.

Perhaps it's got something to do with NVCS? The ECU could be programmed to limit the amount of airflow into the engine with the advanced timing on the inlet cam. NVCS is active until 4500rpm i believe. Purely speculating but it could make sense.. That or it maps timing vs airflow or similar and doesn't like going past whatever value.

Edited by govich

yeah i did notice that it only happens at 4000rpm... that must be a massive lag monster you have there :banana:

But still thats good that you have gotten around the problem.

Not interested in plumbing up my screamer? :) I love the work you did to yours.. that is awesome

Edited by Guilt-Toy
yeah i did notice that it only happens at 4000rpm... that must be a massive lag monster you have there :D

But still thats good that you have gotten around the problem.

Not interested in plumbing up my screamer? ;) I love the work you did to yours.. that is awesome

Nah I wouldn't say that my car is laggy at all. When I got it was stock and yes it is laggy compared to stock..The boost starts to come on relatively early (say 3000 rpm) but does not acheive its set point until above 4000rpm. Dont forget I said earlier that I retard the exhaust cam timing by about 4deg...This makes the engine less efficient in the mid rpm range and more efficient in the upper rpm range...If I run stock cam timing I can hit airflow cut easier even at lower boost so I am cheating in way. I am effectively detuning the car around 4000 rpm to get under the air flow cut... I cant wait to get aftermarket ECU so I dont have to do this...I already have some 660cc Siemens injectors and a fuel rail made up...Also have brand spankin new Z32 afm sitting on the shelf right to go...Even has the spare plug...

As far as plumbing up your screamer I would be happy to do it but then my gf would then start screaming at me...I've spent so much time on my own car at the moment and not with her... I spent 10 hours doing my one.

I actually got the muffler from Wallsend muffler service..He sortof knows me and knew what I was doing so if you go in there I am sure he would help you out...Just tell him the guy with the Black Skyline sent you...He also has some 2nd hand mandrel bends and heaps of other bit and pieces pretty cheap. I always go to him first for stuff..Use my photos if you want..

Btw I think I know a mate of yours...Grant with the silver GTSt 4 door. He had a drive of my car at this party we went to..He is related to my neighbour...small world...

yeah grants a good mate of mine, i tuned his car for him a few times..

I am hireing a Dyno in newcastle tomorrow so if you wanted to come along I can do some power runs for you for $40...

Send me a PM if i dont get back to you get a hold of grant, he can give you my details.

Nah I wouldn't say that my car is laggy at all. When I got it was stock and yes it is laggy compared to stock..The boost starts to come on relatively early (say 3000 rpm) but does not acheive its set point until above 4000rpm. Dont forget I said earlier that I retard the exhaust cam timing by about 4deg...This makes the engine less efficient in the mid rpm range and more efficient in the upper rpm range...If I run stock cam timing I can hit airflow cut easier even at lower boost so I am cheating in way. I am effectively detuning the car around 4000 rpm to get under the air flow cut... I cant wait to get aftermarket ECU so I dont have to do this...I already have some 660cc Siemens injectors and a fuel rail made up...Also have brand spankin new Z32 afm sitting on the shelf right to go...Even has the spare plug...

As far as plumbing up your screamer I would be happy to do it but then my gf would then start screaming at me...I've spent so much time on my own car at the moment and not with her... I spent 10 hours doing my one.

I actually got the muffler from Wallsend muffler service..He sortof knows me and knew what I was doing so if you go in there I am sure he would help you out...Just tell him the guy with the Black Skyline sent you...He also has some 2nd hand mandrel bends and heaps of other bit and pieces pretty cheap. I always go to him first for stuff..Use my photos if you want..

Btw I think I know a mate of yours...Grant with the silver GTSt 4 door. He had a drive of my car at this party we went to..He is related to my neighbour...small world...

For those interested in what the Std ECU can do, Guilt-Toy did some Dyno power runs for me today and results are as follows:

Dyno Dynamics Dynamometer at TurboTechnics Cardiff...

Run 1. 230rwkW at 9psi with AFR = 12.1

Run 2. 265rwkW at 11psi with AFR = 12.2

Run 3. 278 rwkW at 13 psi with AFR = 12.5

Didnt attempt any more boost...I was already happy enough!!

On Run 2 and Run 3 there was a little bit of ignition breakdown due to stock plug gap (didn't have time to regap plugs) but apart from that it was all cool...No sign of airflow cut or anything else scary

And also no-one heard the screamer pipe!!!

Will post up charts once scanned as well as Nissan Consult data...

Thanks Guilt-toy!!! Power FC master!!! and soon to be Std ECU master!!!

Are you sure the ECU is internally standard? I'm a bit skeptical because noone seems to have come across this before..

Well I will check it but I doubt it has been modified...car was very stock and I mean very stock when I got it...in fact it had no mods at all...and no sign of mods that had been put back to stock..

Well I will check it but I doubt it has been modified...car was very stock and I mean very stock when I got it...in fact it had no mods at all...and no sign of mods that had been put back to stock..

Nice. I guess it just shows how little we really know about nissan's ecu.. It'll be interesting to see the printouts

You'd be surprised what the Japs get up to! My car was dead stock off the boat and reeled off 156rwkw. Upon installing the pfc i came across the Mines ecu that was hiding away in the kick panel! :D

Well when I first got the car I did all the standard basic mods and found the air flow cut very quickly...the ECU is definately Nissan because I use the Nissan consult software...I don't think other ECUs would work with the software....

AND..Please read my previous posts carefully...the airflow cut is still there but in knowing a little bit about how it works, I have gotten around it...

Create an account or sign in to comment

You need to be a member in order to leave a comment

Create an account

Sign up for a new account in our community. It's easy!

Register a new account

Sign in

Already have an account? Sign in here.

Sign In Now



  • Similar Content

  • Latest Posts

    • Well, apparently they do fit, however this wont be a problem if not because the car will be stationary while i do the suspension work. I was just going to use the 16's to roll the old girl around if I needed to. I just need to get the E90 back on the road first. Yes! I'm a believer! 🙌 So, I contacted them because the site kinda sucks and I was really confused about what I'd need. They put together a package for me and because I was spraying all the seat surfaces and not doing spot fixes I decided not to send them a headrest to colour match, I just used their colour on file (and it was spot on).  I got some heavy duty cleaner, 1L of colour, a small bottle of dye hardener and a small bottle of the dye top coat. I also got a spray gun as I needed a larger nozzle than the gun I had and it was only $40 extra. From memory the total was ~$450 ish. Its not cheap but the result is awesome. They did add repair bits and pieces to the quote originally and the cost came down significantly when I said I didn't need any repair products. I did it over a weekend. The only issues I had were my own; I forgot to mix the hardener into the dye two coats but I had enough dye for 2 more coats with the hardener. I also just used up all the dye because why not and i rushed the last coat which gave me some runs. Thankfully the runs are under the headrests. The gun pattern wasn't great, very round and would have been better if it was a line. It made it a little tricky to get consistent coverage and I think having done the extra coats probably helped conceal any coverage issues. I contacted them again a few months later so I could get our X5 done (who the f**k thought white leather was a good idea for a family car?!) and they said they had some training to do in Sydney and I could get a reduced rate on the leather fix in the X5 if I let them demo their product on our car. So I agreed. When I took Bec in the E39 to pick it up, I showed them the job I'd done in my car and they were all (students included) really impressed. Note that they said the runs I created could be fixed easily at the time with a brush or an air compressor gun. So, now with the two cars done I can absolutely recommend Colourlock.  I'll take pics of both interiors and create a new thread.
    • Power is fed to the ECU when the ignition switch is switched to IGN, at terminal 58. That same wire also connects to the ECCS relay to provide both the coil power and the contact side. When the ECU sees power at 58 it switches 16 to earth, which pulls the ECCS relay on, which feeds main power into the ECU and also to a bunch of other things. None of this is directly involved in the fuel pump - it just has to happen first. The ECU will pull terminal 18 to earth when it wants the fuel pump to run. This allows the fuel pump relay to pull in, which switches power on into the rest of the fuel pump control equipment. The fuel pump control regulator is controlled from terminal 104 on the ECU and is switched high or low depending on whether the ECU thinks the pump needs to run high or low. (I don't know which way around that is, and it really doesn't matter right now). The fuel pump control reg is really just a resistor that controls how the power through the pump goes to earth. Either straight to earth, or via the resistor. This part doesn't matter much to us today. The power to the fuel pump relay comes from one of the switched wires from the IGN switch and fusebox that is not shown off to the left of this page. That power runs the fuel pump relay coil and a number of other engine peripherals. Those peripherals don't really matter. All that matters is that there should be power available at the relay when the key is in the right position. At least - I think it's switched. If it's not switched, then power will be there all the time. Either way, if you don't have power there when you need it (ie, key on) then it won't work. The input-output switching side of the relay gains its power from a line similar (but not the same as) the one that feeds the ECU. SO I presume that is switched. Again, if there is not power there when you need it, then you have to look upstream. And... the upshot of all that? There is no "ground" at the fuel pump relay. Where you say: and say that pin 1 Black/Pink is ground, that is not true. The ECU trigger is AF73, is black/pink, and is the "ground". When the ECU says it is. The Blue/White wire is the "constant" 12V to power the relay's coil. And when I say "constant", I mean it may well only be on when the key is on. As I said above. So, when the ECU says not to be running the pump (which is any time after about 3s of switching on, with no crank signal or engine speed yet), then you should see 12V at both 1 and 2. Because the 12V will be all the way up to the ECU terminal 18, waiting to be switched to ground. When the ECU switches the fuel pump on, then AF73 should go to ~0V, having been switched to ground and the voltage drop now occurring over the relay coil. 3 & 5 are easy. 5 is the other "constant" 12V, that may or may not be constant but will very much want to be there when the key is on. Same as above. 3 goes to the pump. There should never be 12V visible at 3 unless the relay is pulled in. As to where the immobiliser might have been spliced into all this.... It will either have to be on wire AF70 or AF71, whichever is most accessible near the alarm. Given that all those wires run from the engine bay fusebox or the ECU, via the driver's area to the rear of the car, it could really be either. AF70 will be the same colour from the appropriate fuse all the way to the pump. If it has been cut and is dangling, you should be able to see that  in that area somewhere. Same with AF71.   You really should be able to force the pump to run. Just jump 12V onto AF72 and it should go. That will prove that the pump itself is willing to go along with you when you sort out the upstream. You really should be able to force the fuel pump relay on. Just short AF73 to earth when the key is on. If the pump runs, then the relay is fine, and all the power up to both inputs on the relay is fine. If it doesn't run (and given that you checked the relay itself actually works) then one or both of AF70 and AF71 are not bringing power to the game.
    • @PranK can you elaborate further on the Colorlock Dye? The website has a lot of options. I'm sure you've done all the research. I have old genuine leather seats that I have bought various refurbing creams and such, but never a dye. Any info on how long it lasts? Does it wash out? Is it a hassle? What product do I actually need? Am I just buying this kit and following the steps the page advises or something else? https://www.colourlockaustralia.com.au/colourlock-leather-repair-kit-dye.html
    • These going to fit over the big brakes? I'd be reeeeeeeeaaaall hesitant to believe so.
    • The leather work properly stunned me. Again, I am thankful that the leather was in such good condition. I'm not sure what the indent is at the top of the passenger seat. Like somebody was sitting in it with a golf ball between their shoulders. The wheels are more grey than silver now and missing a lot of gloss.  Here's one with nice silver wheels.
×
×
  • Create New...