Jump to content
SAU Community

Recommended Posts

if u r just pulling the old box out and replacing with a new its just straight forward . drop one out lift other up bolt on and way u go . if u r going to change the clutch at the same time then u have to line the clutch up , if u want to do that let me know and i'll post for u .as long as u know the basic stuff , undo tail shaft all bellhousing bolts including starter , slave , unplug wiring , take the gearstick out , i think that covers it as u have a push clutch it will come out no probs . r33 with pull clutch is a different story .

Link to comment
https://www.sau.com.au/forums/topic/24331-gearboxes/#findComment-519693
Share on other sites

thats what i said before if u want to pull the clutch out ( good idea while the box is down ) to inspect and maybe change it if half or more worn then u have to line it up so u can put the box back up .if u dont line it up the box will never go back .once u have the box down undo all the bolts that hold the clutch assembly and pull the clutch pressure plate off . have a look at the clutch plate for wear and if 1/2 worn u need to get a clutch kit ( new clutch plate , new or rebuild pressure plate , new thrust bearing and a new spiggot bush or bearing ( not sure if ur car has bush or bearing ). i would take the flywheel off and get it machined ( 30-40 $ ). install the spiggot then flywheel ( i always use locktite on the bolts ) then the pressure plate with clutch ( make sure u put the clutch plate the right way )use locktite on the pressure plate bolts . before u do the pressure plate tight u line up the spine of the clutch plate to make sure its in the middle its got to be spot on ( u can buy a tool to do that ) i have old g/box input shafts to line up my clutches . as long as its lining up when u lift the g/box up threre it will go in u just turn the box left to right a little so spline of the shaft doesnt hit the clutch spline and u r sweet .if it doesnt line up it wont go cause the pressure plate presses the clutch plate hard and it wont move . i hope it this helps u , by the way u r lucky it has a push clutch and not a pull one .

as for machining the flywheel have a look if it hasnt got burn marks ( if u drive like a grany it may not ) then dont worry but i always do it .

if got another clutch with the new box that u r instaling check it out if nearly new use it if not dont risk it . u can get a new clutch kit for u r car for 200 - 250 ( stock )

Link to comment
https://www.sau.com.au/forums/topic/24331-gearboxes/#findComment-520639
Share on other sites

Create an account or sign in to comment

You need to be a member in order to leave a comment

Create an account

Sign up for a new account in our community. It's easy!

Register a new account

Sign in

Already have an account? Sign in here.

Sign In Now


  • Similar Content

  • Latest Posts

    • The German place in Cabramatta was rock solid, fresh pretzel cooked to order back then. Then it went all quiet, after all the poker machines were removed, then I believe it closed for good. I did drive past the other week and noticed outdoor lighting a big screen, but no idea what is there now.  
    • Yeah I suspect even if you hold airmass per cycle/cylinder constant if you get too far away from stock you're still going to have problems running the factory tune within the bounds of the factory load scale. Cams, different displacement/rod ratio, etc. I'm just lucky that the GTIII-SS with wastegate boost + CA compliance cats is pretty much equivalent to stock turbos. When I have actual space I can finally get it tuned and modify the fuel system for flex fuel to 100% handle any detonation concerns when cranking the boost to whatever those dinky turbos can put out.
    • I would say no, why, because my daughter, who also lives in Goulburn, hasn't recommended us going there Pity, as we miss all the German joints around in Sydney, actually, the restaurants are the only thing I really miss about Sydney, and a special mention to Ishibanboshi at Bondi Junction, their Kara-age Don is heart cloggingly deliciousness (always added a special boiled egg...or 2) 😋 
    • Does that German restaurant still exist in the old place out the NW end of Goulburn? When I say "out the NW end of"...I am really being vague. It was 1997 when I was last there, and the only point of reference I can recall is that it was on the opposite side of the main drag from the big merino. And when I say "opposite side of the main drag", I don't mean "on the main drag". It was either a couple of streets back from there, or might have even been out in the sticks a bit further. Was an old farm building or mill or somesuch. And when I say "the big merino" I might actually be thinking of a completely different part of town, because I just looked on maps and the big bugger is not where I remembered him to be! The food was good, consisting largely of various German mystery-meat sausage/loaf things and kartofflen.
    • So while the second sentence is completely correct and the whole point of the conversation, the first sentence bears consideration. If this bloke is just hoping to throw big turbos on and drive it around, because there are no helpful facilities at all in his tropical paradise** then he likely has zero chance of even knowing what the TP is on the last column in the stock maps, let alone know whether the ECU is operating anywhere near it or past it. So the point is very very moot. And, per what I said before, at stock boost on those turbos, you may well be off the end of the map. **I'm just back from Vanuatu, so I know exactly what small Pacific nations can be like wrt paradise without requisite facilities. But it's not even that simple. I put a high flow on my car and had to drive it around without a proper tune because of the lack of opportunity*** to put the bigger AFM and injectors into it to allow it to be tuned. I had to turn the boost down to less than I had before, and back off the boost controller's ramp, because it was exploring parts of the map that it didn't drive in before, and really couldn't access for tuning on the dyno either, and so was pinging. It was still well within the last column, because when I first**** set up the Nistune on the Neo I rescaled all axes of the maps to give some more space to explore. ***Family dyno was broken ****This was 13 years ago, and the TIM thing wasn't a thing then and so TP would definitely grow when pushing past the stock tune's limits.
×
×
  • Create New...