Jump to content
SAU Community

Recommended Posts

the install went alright you need to trim the manifold heat shield, extend you cooler pipe make up and intake pipe and oil line is given and water lines blocked up and the dump pipe in regards to it buckling i put the extension inside the o ring and spot welded around it so was no buckling because its matches up perfect with the Oring on the turbo and dump it just doenst seal ive put sum exhuast sealant and a gasket and its worked fine. but the turbo itself is great a few minor things to modify but worth it rather than paying 4000 for a direct bolt

  • Replies 55
  • Created
  • Last Reply

Top Posters In This Topic

the install went alright you need to trim the manifold heat shield, extend you cooler pipe make up and intake pipe and oil line is given and water lines blocked up and the dump pipe in regards to it buckling i put the extension inside the o ring and spot welded around it so was no buckling because its matches up perfect with the Oring on the turbo and dump it just doenst seal ive put sum exhuast sealant and a gasket and its worked fine. but the turbo itself is great a few minor things to modify but worth it rather than paying 4000 for a direct bolt

sounds good!

can you please put up some pics when you get time?!?

sounds good!

can you please put up some pics when you get time?!?

Here are the pics for you if you have any other specific photos of the install you want just ask

21052009002.th.jpg

how the turbo fit in note the actuator realy close to the body so bracket had to be changed so it would come to the middle abit more also exxhust manifold heat shield trimmed

21052009003t.th.jpg

size of the turbo

30052009.th.jpg

custom cooler pipe 2inch to 2.5inch going from turbo to stock cooler pipe

30052009001.th.jpg

how the cooler pipe extension sat

31052009z.th.jpg

roughly how it would look like when put together prety well hidden

31052009004.th.jpg

intake pipe made up used a 90degree silicon elbow from the turbo then this 45 degree offcut clamped onto the elbow

31052009002.th.jpg

can you spot the boost controoler LOL

03062009p.th.jpg

how it looks in the end now

Edited by skline01999
errrrr its not 100% on the clamp. You can get stronger clamps but Its just made to hold, It can't seal up gaps.

Its when you weld the dump pipe into the O ring. They don't expand in the same sort of rate. So on the end the flat surface of the O ring becomes buckled under pressure as it cools down.

Normally to weld the O ring you need to divide it into small sections wait it cools down before moving on to next, Or machine the O ring flange flat before fitting it in the car.

i checked them both and they were 100% flat and true, we swap out the supplied clamps and the problem goes away.....

looks good man. do you have a pic with everything put back on (heat shield etc.)

does it look sorta stock?

I havnt put the turbo heat shielf bak on cause its kinda hard to fit it in theres not much room espiacly with the acutaor and all you would prob have to modify the origanal one cutting it down alot and bolting it to the exhust manifold heat shield but yeah apart from that looks stock espcially with stock airbox

nice pics, thanks for that!

do u have any of the dump pipe installed?!?

you should be able to get a v-clamp to suit from most turbo stores

just want to confirm the spec of turbo you used was it a TR43i with internal gate with 31mm hole? maybe hypergear can confirm?

nice pics, thanks for that!

do u have any of the dump pipe installed?!?

you should be able to get a v-clamp to suit from most turbo stores

just want to confirm the spec of turbo you used was it a TR43i with internal gate with 31mm hole? maybe hypergear can confirm?

Ill try get you a pic of the dump pipe installed but you basically get a 2.75inch Oring which you end up welding to your existing dumpipe then clamp it on. yeah its tr43I 500hp turbo IW and i think its 29mm

will be very interested to see well it holds/controls boost

plus how responsive and what power it makes, when u getting it tuned?

Well im losing my lincese in a few weeks so im gona save up do the injectors pump and afm then get remap ecu at dr drift and tuned. so ye a while

I managed to get my heat shield back on by bending it a little. I tried to take some pics but my camera is not playing nice at the moment.

Mine is going back to Status next week, getting the clutch and a new map done for my mammoth injectors so I will hopefully be pushing the high 200's then. I'll keep you all posted.

  • 3 weeks later...

Create an account or sign in to comment

You need to be a member in order to leave a comment

Create an account

Sign up for a new account in our community. It's easy!

Register a new account

Sign in

Already have an account? Sign in here.

Sign In Now



  • Similar Content

  • Latest Posts

    • Hi,  Just joined the forum so I could share my "fix" of this problem. Might be of use to someone. Had the same hunting at idle issue on my V36 with VQ35HR engine after swapping the engine because the original one got overheated.  While changing the engine I made the mistake of cleaning the throttle bodies and tried all the tricks i could find to do a throttle relearn with no luck. Gave in and took it to a shop and they couldn't sort it. Then took it to my local Nissan dealership and they couldn't get it to idle properly. They said I'd need to replace the throttle bodies and the ecu probably costing more than the car is worth. So I had the idea of replacing the carbon I cleaned out with a thin layer of super glue and it's back to normal idle now. Bit rough but saved the car from the wreckers 🤣
    • After my last update, I went ahead with cleaning and restoring the entire fuel system. This included removing the tank and cleaning it with the Beyond Balistics solution, power washing it multiple times, drying it thoroughly, rinsing with IPA, drying again with heat gun and compressed air. Also, cleaning out the lines, fuel rail, and replacing the fuel pump with an OEM-style one. During the cleaning process, I replaced several hoses - including the breather hose on the fuel tank, which turned out to be the cause of the earlier fuel leak. This is what the old fuel filter looked like: Fuel tank before cleaning: Dirty Fuel Tank.mp4   Fuel tank after cleaning (some staining remains): Clean Fuel Tank.mp4 Both the OEM 270cc and new DeatschWerks 550cc injectors were cleaned professionally by a shop. Before reassembling everything, I tested the fuel flow by running the pump output into a container at the fuel filter location - flow looked good. I then fitted the new fuel filter and reassembled the rest of the system. Fuel Flow Test.mp4 Test 1 - 550cc injectors Ran the new fuel pump with its supplied diagonal strainer (different from OEM’s flat strainer) and my 550cc injectors using the same resized-injector map I had successfully used before. At first, it idled roughly and stalled when I applied throttle. Checked the spark plugs and found that they were fouled with carbon (likely from the earlier overly rich running when the injectors were clogged). After cleaning the plugs, the car started fine. However, it would only idle for 30–60 seconds before stalling, and while driving it would feel like a “fuel cut” after a few seconds - though it wouldn’t fully stall. Test 2 – Strainer swap Suspecting the diagonal strainer might not be reaching the tank bottom, I swapped it for the original flat strainer and filled the tank with ~45L of fuel. The issue persisted exactly the same. Test 3 – OEM injectors To eliminate tuning variables, I reinstalled the OEM 270cc injectors and reverted to the original map. Cleaned the spark plugs again just in-case. The stalling and “fuel cut” still remained.   At this stage, I suspect an intermittent power or connection fault at the fuel pump hanger, caused during the cleaning process. This has led me to look into getting Frenchy’s fuel hanger and replacing the unit entirely. TL;DR: Cleaned and restored the fuel system (tank, lines, rail, pump). Tested 550cc injectors with the same resized-injector map as before, but the car stalls at idle and experiences what feels like “fuel cut” after a few seconds of driving. Swapped back to OEM injectors with original map to rule out tuning, but the issue persists. Now suspecting an intermittent power or connection fault at the fuel pump hanger, possibly cause by the cleaning process.  
    • For race cars, this is one part where I find having the roll cage bar having gone through a hole in the floor better than the build it up on a ledge inside... The Merc I help on, the main hoop ends are marked on the car, and the jack is marked... Jack goes under a few inches and lifts one whole side of the car up... Removes that fight for long slim jacks for race car duties!   My biggest issue for the daily drivers I work on, is my jacks don't go high enough. The jacks start out on a few blocks, jack it up, then start a second jack under it on more blocks, and then I can get an axle stand under it. My axle stands are presently in use, and are nearly fully extended. The car is sitting with barely more than a cm of clearance to get the wheel off the studs! Sarah's Kluger is the same, as it has an ungodly amount of droop available in the suspension and a distinct lack of good jacking points!
    • Happy? Yep, my to do list is getting shorter and shorter. Either this light approaching is the end of the tunnel, or I'm about to be hit by a train... Ha ha ha   Also, Duncan isn't that far out of town that you need to make a multi day drive out of it. 😛
×
×
  • Create New...