Jump to content
SAU Community

Recommended Posts

Changing pumps in my Stagea. Does anyone know exactly what this "valve" purpose is? It looks to be 'incomplete' or damaged?

Pic:

post-48775-1250072704_thumb.jpg

Okay, the pic is a bit blurry, but its the best I can do this time of night.

Its right off the pump. I'm now fitting a Bosch pump and need to know if I can just get rid of this "valve"?

Anyone? :ninja:

Link to comment
https://www.sau.com.au/forums/topic/283115-fuel-pump-upgrade-question/
Share on other sites

sorry not sure....but if it helps when I fitted my walbro I just left that valve out with no problems. It might be an anti-drain back valve to hold pressure when ignition is off for faster priming....but thats just a guess

Worked out its a relief valve in case of blockage in the line. It does appear mine is faulty ... been having problems getting the FPR set right. Now I know why. I'll remove it and finish fitting my 040 tomorrow.

:ninja:

got the bosch 019 (exact same specs as 040)

fitted it a couple weeks back,will be pulling it out again soon to re-check wiring to make sure the rubber boot things are sweet and replace a line we hagged fitting it

their noisy little farkers too ruby

got a decent stereo in your stag?you'll need it!

yes its a pressure relief valve. if your fuel line becomes blocked or fuel cant leave the tank for any reason, it opens and released pressure so you dont destroy your fuel pump or blow up fuel lines.

its best to leave it there. if its faulty, replace it. simple as that!

their noisy little farkers too ruby

got a decent stereo in your stag?you'll need it!

JVC KW-AVX820 DVD head unit

Option Audio OA65R 6.5" kevlar cone pro series speakers and tweeters up front

Kenwood KAC-M845 2ch amp for the front speakers

Option Audio OA60C 6.0" kevlar cone pro series speakers at the rear

JVC 12" subwoofer and box

JVC KS-ZX3002 mono amp for sub

... and I'm usually jammin' Linkin Park and Rammstein for tunes.

Is that enough? :)

its best to leave it there. if its faulty, replace it. simple as that!

I've built many project cars (and project bikes) with upgraded fuel systems and I've never seen a valve like this before. Never had a problem with any "blockages" in the past.

If there is a blockage, the car won't run ... simple. Plus the fact the 040 is a noisy pump. Only an idiot would keep wanting to crank the car over, ignoring the noise of the straining fuel pump.

there ARE a lot of stupid people out there. ok maybe stupid is too harsh. lets say people that just dont know what that sound is.

i know if my wife was driving and she heard something different, she wouldnt really care... just as an example!

not everyone is attuned to their car like a lot of us are!

Oh yeah, Ruby, if you can work out how to get a constant 14.4v feed to your fuel pump (which is what a lot of workshops do), then do it. Duncan might be able to explain this, as he was there and involved when his was being replaced.

Can do.... the rewire was very helpful in the 32, not sure if it is such a problem in stag yet since they are new. But basically fuse and run a wire direct from battery to a 30A relay near the pump. Use the current power feed to the pump as the relay signal. Run out from the relay direct to the pump (keep large diameter as long as you can). Directly earth the other side of the pump to chassis.

In fact the detailed thread is here:http://www.skylinesaustralia.com/forums/Fuel-Pump-Direct-Feed-Rew-t91993.html&st=200#entry4605573

JVC KW-AVX820 DVD head unit

Option Audio OA65R 6.5" kevlar cone pro series speakers and tweeters up front

Kenwood KAC-M845 2ch amp for the front speakers

Option Audio OA60C 6.0" kevlar cone pro series speakers at the rear

JVC 12" subwoofer and box

JVC KS-ZX3002 mono amp for sub

... and I'm usually jammin' Linkin Park and Rammstein for tunes.

Is that enough? :D

i think that should do it roo,i often drive home from work without the stereo on,just listening to the noise pump,loud exhaust,squeeky subframe pineapples and the strange rattle in my vents below the windscreen

i love my car

i think that should do it roo,i often drive home from work without the stereo on,just listening to the noise pump,loud exhaust,squeeky subframe pineapples and the strange rattle in my vents below the windscreen

i love my car

hahaha

mine the damn mearcat pod rattles against the windscreen, drives me nuts.

I took the top of my tank, looked at where the pump was and put it all back together to do another day, i know i should do it, but CBF.

I replaced my stocker with a Walbro. There was a suggestion that it wasn't performing and someone lent me a GTR pump to try but it was not very different (was better though) so I swapped it back. I'm quite good at changing pumps now! (Tip - make sure you run down your tank to almost empty before changing pumps!)

If you have not already good idea to get full battery voltage to pump (tutorial in "how to" dept in Skyline section).

(Tip - make sure you run down your tank to almost empty before changing pumps!)

mine turned up in the post abit earlier than i expected,so id filled the tank full the night before,did it on a full tank.there nothing quite

like being elbow deep in fuel trying to unclip the farkin cradle

If you have not already good idea to get full battery voltage to pump (tutorial in "how to" dept in Skyline section).

will be doing this very shortly :(

Create an account or sign in to comment

You need to be a member in order to leave a comment

Create an account

Sign up for a new account in our community. It's easy!

Register a new account

Sign in

Already have an account? Sign in here.

Sign In Now


  • Similar Content

  • Latest Posts

    • Next on the to-do list was an oil and filter change. Nothing exciting to add here except the oil filter is in a really stupid place (facing the engine mount/subframe/steering rack). GReddy do a relocation kit which puts it towards the gearbox, I would have preferred towards the front but there's obviously a lot more stuff there. Something I'll have to look at for the next service perhaps. First time using Valvoline oil, although I can't see it being any different to most other brands Nice... The oil filter location... At least the subframe wont rust any time soon I picked up a genuine fuel filter, this is part of the fuel pump assembly inside the fuel tank. Access can be found underneath the rear seat, you'll see this triangular cover Remove the 3x plastic 10mm nuts and lift the cover up, pushing the rubber grommet through The yellow fuel line clips push out in opposite directions, remove these completely. The two moulded fuel lines can now pull upwards to disconnect, along with the wire electrical plug. There's 8x 8mm bolts that secure the black retaining ring. The fuel pump assembly is now ready to lift out. Be mindful of the fuel hose on the side, the hose clamp on mine was catching the hose preventing it from lifting up The fuel pump/filter has an upper and lower section held on by 4 pressure clips. These did take a little bit of force, it sounded like the plastic tabs were going to break but they didn't (don't worry!) The lower section helps mount the fuel pump, there's a circular rubber gasket/grommet/seal thing on the bottom where the sock is. Undo the hose clip on the short fuel hose on the side to disconnect it from the 3 way distribution pipe to be able to lift the upper half away. Don't forget to unplug the fuel pump too! There's a few rubber O rings that will need transferring to the new filter housing, I show these in the video at the bottom of this write up. Reassembly is the reverse Here's a photo of the new filter installed, you'll be able to see where the tabs are more clearing against the yellow OEM plastic Once the assembly is re-installed, I turned the engine over a few times to help build up fuel pressure. I did panic when the car stopped turning over but I could hear the fuel pump making a noise. It eventually started and has been fine since. Found my 'lucky' coin underneath the rear seat too The Youtube video can be seen here: https://www.youtube.com/watch?v=uLJ65pmQt44&t=6s
    • It was picked up on the MOT/Inspection that the offside front wheel bearing had excessive play along with the ball joint. It made sense to do both sides so I sourced a pair of spare IS200 hubs to do the swap. Unfortunately I don't have any photos of the strip down but here's a quick run down. On the back of the hub is a large circular dust cover, using a flat head screw driver and a mallet I prised it off. Underneath will reveal a 32mm hub nut (impact gun recommended). With the hub nut removed the ABS ring can be removed (I ended up using a magnetic pick up tool to help). Next up is to remove the stub axle, this was a little trickier due to limited tools. I tried a 3 leg puller but the gap between the hub and stub axle wasn't enough for the legs to get in and under. Next option was a lump hammer and someone pulling the stub axle at the same time. After a few heavy hits it released. The lower bearing race had seized itself onto the stub axle, which was fine because I was replacing them anyway. With the upper bearing race removed and the grease cleaned off they looked like this The left one looked pristine inside but gave us the most trouble. The right one had some surface rust but came apart in a single hit, figure that out?! I got a local garage to press the new wheel bearings in, reassemble was the opposite and didn't take long at all. Removing the hub itself was simple. Starting with removing the brake caliper, 2x 14mm bolts for the caliper slider and 2x 19mm? for the carrier > hub bolts. I used a cable tie to secure the caliper to the upper arm so it was out of the way, there's a 10mm bolt securing the ABS sensor on. With the brake disc removed from the hub next are the three castle nuts for the upper and lower ball joints and track rod end. Two of these had their own R clip and one split pin. A few hits with the hammer and they're released (I left the castle nuts on by a couple of turns), the track rod ends gave me the most grief and I may have nipped the boots (oops). Fitting is the reversal and is very quick and easy to do. The lower ball joints are held onto the hub by 2x 17mm bolts. The castle nut did increase in socket size to 22mm from memory (this may vary from supplier) The two front tyres weren't in great condition, so I had those replaced with some budget tyres for the time being. I'll be replacing the wheels and tyres in the future, this was to get me on the road without the worry of the police hassling me.
    • Yep, the closest base tune available was for the GTT, I went with that and made all the logical changes I could find to convert it to Naturally Aspirated. It will rev fine in Neutral to redline but it will be cutting nearly 50% fuel the whole way.  If I let it tune the fuel map to start with that much less fuel it wont run right and has a hard time applying corrections.  These 50% cuts are with a fuel map already about half of what the GTT tune had.  I was having a whole lot of bogging when applying any throttle but seem to have fixed that for no load situations with very aggressive transient throttle settings. I made the corrections to my injectors with data I found for them online, FBCJC100 flowing 306cc.  I'll have to look to see if I can find the Cam section. I have the Bosch 4.9 from Haltech. My manifold pressure when watching it live is always in -5.9 psi/inHg
    • Hi My Tokico BM50 Brake master cylinder has a leak from the hole between the two outlets (M10x1) for brake pipes, I have attached a photo. Can anyone tell me what that hole is and what has failed to allow brake fluid to escape from it, I have looked on line and asked questions on UK forums but can not find the answer, if anyone can enlighten me I would be most grateful.
    • It will be a software setting. I don't believe many on here ever used AEM. And they're now a discontinued product,that's really hard to find any easy answers on. If it were Link or Haltech, someone would be able to just send you a ECU file though.
×
×
  • Create New...