Jump to content
SAU Community

Recommended Posts

Hiya all,

I'll be picking up a manual AWD box for the stagea this week sometime, together with all the additional bits I need for the swap. Just wondering if anyone has done this kind of swap before, and if they would have any suitable premises for such work. My house is under construction for a house extension, so there is no room for me to do it there ... and I think Tracy has banned me from doing such work at home :D

I'm no stranger to working on cars, but wouldn't mind a hand for ease of work and a speedy job ... plus its always best ofr another set of eyes to be going over the job. Not too keen on paying a workshop to do it ... but not keen on doing it alone ... so aiming for somewhere in the middle!

There's a carton of beer in it for any assistance. I'm keen to start (and finish) the swap not this weekend, but the next. 33 is sold, so the Stag is my daily.

;)

Link to comment
https://www.sau.com.au/forums/topic/297339-help-with-gearbox-swap/
Share on other sites

  • Replies 44
  • Created
  • Last Reply

Top Posters In This Topic

You'd be handy if you had an engine hoist :(

Should be picking up the box and bits tomorrow arvo ... then I can see how much trouble I've gotten myself into. :P

you after a engine crane ruby ? i have one here at home if ya need to borrow one

Hmm, I won't say no if you do have one. I'll hunt for a venue to do the swap, and if they do not have one handy I might just hit you up for it!

Figured I might just pull the engine and box out complete, swap boxes, double check bolt on bits on and around the engine, then put everything back in ... to eliminate the need for a hoist and multiple persons to hoist the box in place.

:huh:

the 5th and 6th of December? I can always come round to talk shit, and hand you spanners. Thats all ill be good for
Drop the engine and box out...

Far out! Not how I'd be doing it but shall be interesting. Perhaps someone can be there to take photos and note the process for another manual conversion SAUSA style?

I could help out, but i would only be good at those 2 things :down:, would like to come along anyway to see how its done, and to learn.

Far out! Not how I'd be doing it but shall be interesting. Perhaps someone can be there to take photos and note the process for another manual conversion SAUSA style?

I need to replace the gasket between the turbo and dump pipe anyway, and a few other things (CV boots etc) ... so its just easier to do it all in one hit and with the engine out. Just haven't done this amount of work in one go in over 5 years.

I'll be sure to take pics and notes along the way :down:

I bought the GTR box and Nismo clutch kit and Nismo flywheel for some of the coin ... plus I'm happy with the BBS rims for now >_<

Might have a workshop lined up with Lukey boy. During the week, I'll see who would like to lend a hand and we'll get a bbq happening ... thats if Luke doesn't mind the extra company.

:blink:

Okay its all set. I've arranged to use premises for the swap kindly provided by Luke in the North Plympton area.

Can I have some volunteers to help for a few hours, talk shit and drink some of my beer? I'll mostly need you to help remove the auto trans and then fit in the manual box ... prob 4 peeps all up!

:)

id give ya a hand Ruby but i have a feeling im gonna have my hands tied

with another certain car thats giving me hemorrhoids lol

Luke, any chance i may be able to borrow the cltuch alignment tool?

Create an account or sign in to comment

You need to be a member in order to leave a comment

Create an account

Sign up for a new account in our community. It's easy!

Register a new account

Sign in

Already have an account? Sign in here.

Sign In Now



  • Similar Content

  • Latest Posts

    • Did this end up working? Did you take some pictures?
    • And finally, the front lower mount. It was doubly weird. Firstly, the lower mount is held in with a bracket that has 3 bolts (it also acts as the steering lock stop), and then a nut on the shock lower mount itself. So, remove the 3x 14mm head bolts , then the 17mm nut that holds the shock in. From there, you can't actually remove the shock from the lower mount bolt (took me a while to work that out....) Sadly I don't have a pic of the other side, but the swaybar mounts to the same bolt that holds the shock in. You need to push that swaybar mount/bolt back so the shock can be pulled out past the lower control arm.  In this pic you can see the bolt partly pushed back, but it had to go further than that to release the shock. Once the shock is out, putting the new one in is "reverse of disassembly". Put the top of the shock through at least one hole and put a nut on loosely to hold it in place. Put the lower end in place and push the swaybar mount / shock bolt back in place, then loosely attach the other 2 top nuts. Bolt the bracket back in place with the 14mm head bolts and finally put the nut onto the lower bolt. Done....you have new suspension on your v37!
    • And now to the front.  No pics of the 3 nuts holding the front struts on, they are easy to spot. Undo 2 and leave the closest one on loosely. Underneath we have to deal with the wiring again, but this time its worse because the plug is behind the guard liner. You'll have to decide how much of the guard liner to remove, I undid the lower liner's top, inside and lower clips, but didn't pull it full off the guard. Same issue undoing the plug as at the rear, you need to firmly push the release clip from below while equally firmly gripping the plug body and pulling it out of  the socket. I used my fancy electrical disconnect pliers to get in there There is also one clip for the wiring, unlike at the rear I could not get behind it so just had to lever it up and out.....not in great condition to re-use in future.
    • Onto the rear lower shock mount. It's worth starting with a decent degrease to remove 10+ years of road grime, and perhaps also spray a penetrating oil on the shock lower nut. Don't forget to include the shock wiring and plug in the clean.... Deal with the wiring first; you need to release 2 clips where the wiring goes into the bracket (use long nose pliers behind the bracket to compress the clip so you can reuse it), and the rubber mount slides out, then release the plug.  I found it very hard to unplug, from underneath you can compress the tab with a screwdriver or similar, and gently but firmly pull the plug out of the socket (regular pliers may help but don't put too much pressure on the plastic. The lower mount is straightforward, 17mm nut and you can pull the shock out. As I wasn't putting a standard shock back in, I gave the car side wiring socket a generous gob of dialectric grease to keep crap out in the future. Putting the new shock in is straightforward, feed it into at least 1 of the bolt holes at the top and reach around to put a nut on it to hold it up. Then put on the other 2 top nuts loosely and put the shock onto the lower mounting bolt (you may need to lift the hub a little if the new shock is shorter). Tighten the lower nut and 3 upper nuts and you are done. In my case the BC Racing shocks came assembled for the fronts, but the rears needed to re-use the factory strut tops. For that you need spring compressors to take the pressure off the top nut (they are compressed enough when the spring can move between the top and bottom spring seats. Then a 17mm ring spanner to undo the nut while using an 8mm open spanner to stop the shaft turning (or, if you are really lucky you might get it off with a rattle gun).
    • You will now be able to lift the parcel shelf trim enough to get to the shock cover bolts; if you need to full remove the parcel shelf trim for some reason you also remove the escutcheons around the rear seat release and you will have to unplug the high stop light wiring from the boot. Next up is removal of the bracket; 6 nuts and a bolt Good news, you've finally got to the strut top! Remove the dust cover and the 3 shock mount nuts (perhaps leave 1 on lightly for now....) Same on the other side, but easier now you've done it all before
×
×
  • Create New...