Jump to content
SAU Community

Recommended Posts

  • Replies 242
  • Created
  • Last Reply

Top Posters In This Topic

Guest Sim32

hey i just got my car, for a week it was fine, ran great.

but now the thing seem to do exactly what u guys have been describing. like stalling when u slow down at a lights..well not stalling just dipping real low, 100 + rpm then then just before cutting out the engine seems to regather itsself and go up again. But it fluctuates heaps, and just doesnt sit on a nice idle speed like it did. The car has stalled on me about 3 times..

starting to annoy me..

What is this ACC valve u speak of? and where is it? and how can u clean it??

also, do u have any pics of earthing the fuel pump?

cheers.

Sim32,

For RB20-25 motor

The AAC valve (Auxilliary Air Control Valve) is located at the back of the plenum chamber (inlet manifold) there is a maroon electrical plug (brittle) and a hose which need to be removed first then there is four ten millimeter bolts that also need to be removed before the whole assembly can be (careful if you want to use the orignal gasket again) removed from the car.

then there is two screws that hold the solenoid on, once this is removed the remaining assembly can be cleaned by useing carby cleaner (I used kero and a compressor to dry and clear any blockages) also make sure that the spring moves(smooth) and the valve works.

Reassemble in reverse order with a bit of sensor safe silicon with the original gasket(or you could make another one it depends on weather the gasket comes off in one piece) hope this helps!

It really is quite easy!

Stuttering might be spark plugs, have them gaped to 0.8mm this helps (platinum/iridium plugs also are a good choice for turbocharged engines)

MEGA

  • 2 weeks later...

hmm thats not the way I understand it works on an RB20.....

The ECU just looks to switch the power to the fuel pump via the relay so that:

*When the ignition is turned on, the pump is powered for 5 sec

*When the engine is cranking/running the pump is powered

I think that the ecu uses a signal from the AFM to determine when the engine is cranking/running. This means that in the event of an accident where the engine stops, the ecu will turn the fuel pump off - a safety feature.

The fuel pump control modulator also acts like a relay to control the voltage (and hence current) across the fuel pump by switching a resistor in and out. The resistor is located between the pump and earth and the switching is controlled by a signal from the ECU.

So if you earth the pump straight to the chassis it will always receive full voltage and therefore run at full capacity whenever the ecu wants the it to run. (You might as well also remove the control modulator and resistor because this effectively short circuits their operation)

If you short the relay then the modulator should still control the pump in the same way as before but you have just removed the functionality of the fuel cut safety feature.

I have any of this wrong someone please correct me.

Im having similar problems with my rb20det silvia. A mechanic friend adjusted an idle thing on the back of the manifold. It has improved but occasionally the idle drops and raises dramatically and when changing down gears sometimes it stalls. I have new iridium plugs, new vl turbo fuel pump. Do you think that maybe i need a regulator at all? This is really bugging me.

well after doing what brownie has told me is *wrong* i have not had a problem at all and im the envy of my mates with 32/33's as all have bad idles.

Thats only the way I understand the system operates.

If you want me to, I can post up a schematic of the fuel system and you can explain how it works.

Guest VuDuDoc
Originally posted by Nizmo32_Josh

no left the earth on the fuel pump alone and bypassed a relay

can you explain which spades are by passed? i look at the top and see the numbering on the relay but what is by passed?

and could it be that the pump is stuck in somewhat of an idle where pump output doesnt vary with accelertation/deceleration?

  • 1 month later...

Create an account or sign in to comment

You need to be a member in order to leave a comment

Create an account

Sign up for a new account in our community. It's easy!

Register a new account

Sign in

Already have an account? Sign in here.

Sign In Now



  • Similar Content

  • Latest Posts

    • Yup. You can get creative and make a sort of "bracket" with cable ties. Put 2 around the sender with a third passing underneath them strapped down against the sender. Then that third one is able to be passed through some hole at right angles to the orientation of the sender. Or some variation on the theme. Yes.... ummm, with caveats? I mean, the sender is BSP and you would likely have AN stuff on the hose, so yes, there would be the adapter you mention. But the block end will either be 1/8 NPT if that thread is still OK in there, or you can drill and tap it out to 1/4 BSP or NPT and use appropriate adapter there. As it stands, your mention of 1/8 BSPT male seems... wrong for the 1/8 NPT female it has to go into. The hose will be better, because even with the bush, the mass of the sender will be "hanging" off a hard threaded connection and will add some stress/strain to that. It might fail in the future. The hose eliminates almost all such risk - but adds in several more threaded connections to leak from! It really should be tapered, but it looks very long in that photo with no taper visible. If you have it in hand you should be able to see if it tapered or not. There technically is no possibility of a mechanical seal with a parallel male in a parallel female, so it is hard to believe that it is parallel male, but weirder things have happened. Maybe it's meant to seat on some surface when screwed in on the original installation? Anyway, at that thread size, parallel in parallel, with tape and goop, will seal just fine.
    • How do you propose I cable tie this: To something securely? Is it really just a case of finding a couple of holes and ziptying it there so it never goes flying or starts dangling around, more or less? Then run a 1/8 BSP Female to [hose adapter of choice?/AN?] and then the opposing fitting at the bush-into-oil-block end? being the hose-into-realistically likely a 1/8 BSPT male) Is this going to provide any real benefit over using a stainless/steel 1/4 to 1/8 BSPT reducing bush? I am making the assumption the OEM sender is BSPT not BSPP/BSP
    • I fashioned a ramp out of a couple of pieces of 140x35 lumber, to get the bumper up slightly, and then one of these is what I use
    • I wouldn't worry about dissimilar metal corrosion, should you just buy/make a steel replacement. There will be thread tape and sealant compound between the metals. The few little spots where they touch each other will be deep inside the joint, unable to get wet. And the alloy block is much much larger than a small steel fitting, so there is plenty of "sacrificial" capacity there. Any bush you put in there will be dissimilar anyway. Either steel or brass. Maybe stainless. All of them are different to the other parts in the chain. But what I said above still applies.
    • You are all good then, I didn't realise the port was in a part you can (have!) remove. Just pull the broken part out, clean it and the threads should be fine. Yes, the whole point about remote mounting is it takes almost all of the vibration out via the flexible hose. You just need a convenient chassis point and a cable tie or 3.
×
×
  • Create New...