Jump to content
SAU Community

Recommended Posts

hi guys just wondering if anyones done it? apparently if you grind with masking tape around the edges you wont stuff the paint?

anywhere to get the triangles?

cheers

The duct is NACA duct

http://en.m.wikipedia.org/wiki/NACA_duct#mw-mf-search

I made one out of my factory steel bonnet on my old rx7 , simple to do

Make a template out of Mylar sticker film on a4 sheet print out make a few copies and confirm same dimensions

Cut one out very carefully

Stick on bonnet in location desired

Check 4 times for location

Trace arc on bonnet with exacto knife you need to cut all the way thru top layer of paint!! Except the front line on nose of the car ( if your quesy don't use knife yet use marker) try and fit between braces if possible

Check 4 times for aligned and underside issues

tape the arc edge just as close as you can to cut line a little water colour paint rubbed on a soft rag if you can't see the cut line

Once the tape is perfect , tape clean rags or towels around the bonnet and vent area the dust will fly everywhere and it's abrasive

A old blanket on the engine bay that is slightly damp to stop fires from sparks and abrasive cut off wheel dust

get Dremmel or similar with fibreglass cut off wheels ( a multitool would work too - vibrating deal but you better be accurate with it!)

Your going to cut all the lines except the front nose line !! cut with Dremel slowly using extreme care

Once cut it should flap loose but be attached on the nose part , carefully untape the flap

get a hair dryer or low heat gun

Warm the paint to about 45c on the flap

carefully and slowly bend the flap down into engine bay with fingers about 30mm

( could be sharp edges)

Now open the bonnet and warm the flap again

It should be kinda a shallow right angle not folded

now bend it with fingers from the bottom of the arc back towards the bonnet in back

The arc should now look like the NACA duct only no sides

trace the contour on some carbon fiber or glass 1 layer thick it should overhang by 5mm or so on each side

now take the bonnet off

flip over on something soft where you can work on it with epoxy stink

the two side strips will be epoxy built up a layer or two more once taped on in shape ( take into account drips etc and they can't be removed on paintwork !! )

once dry the tape can come off

the edge needs pie cut for curves and then tiger seal bonded on with care , dry a day

now cover underside with another layer of carbon or glass to hide merge of steel and carbon

Trim back of duct opening in your fav mesh to stop muppets dropping crap in your engine

the top should be damn near perfect paint wise , just a little touch up on edges and a buff out to shine back up and blend in the touch up

done

Looks perfect !! works awesome

Had mine 11yrs and it never broke loose or cracked the paint

wish I had documented it in photos dooh!!

So the finished product is steel bottom carbon or glass sides , glass sides will need black or your fav paint

I should make some out of carbon that just need cutout and bond lol

Blue painters tape

Dremel

Cut off wheels a few

Marker

Old blanket

Towels ( they can be washed and used again lol just don't let the wife catch you haha)

carbon weave of choice or glass

Paint of needed or black matte

mesh

exacto knife or luffa knife a good one you can push on without it falling to bits

epoxy

Tiger seal

Something to set bonnet on

A friend to help pull it off !!

a bucket load of faith and time don't rush !!

it's simple but must use care and measure 4 times and step back and look at it before cutting

If you cut braces you could be defected !!

When yanking tape off pull towards cut not away or it could rip paint off !!

if you need help with arc let me know

Mine was 30mm wide in front , about 150mm open wide

About 30mm tall opening

A flexible arc tool helps ( from drafting store or stationary shop) draw one side then fold paper to match exact arc on other side

Edited by Carbon 34

Can be done, ask terry, he did it to his black one.

Not sure if you can get away without painting.

I was weighing it up but waited for a genuine vsii one to pop up instead, and I got very lucky.

Anthony has a good memory :)

R34GTR194.jpg

It cost $45 + GST + Delivery > $62 from kenloweracing.com.au > air scoops > 3" NACA Duct

R34GTR204.jpg

It fits under the hole that's been cut into the bonnet > stuck there with epoxy so that paint won't crack due to expansion/contraction via heat/cold.

Hiya,

I just made sure the duct was positioned in the same position as on the V-Spec II & didn't worry about it until - that's right - someone asked the same Q as you.

Then I cut a neat fitting piece of Perspex to fit the slot on wet days - but I hardly ever had to use it.

Terry how does it go with water ingestion?

i assume it'll throw water onto the rear turbo?

Mine was in for 11 years in a snow zone and water was never issue , at speed the heat is so great and air flow speed so high into the inlet it vaporises even in down pours

and mine didn't run any mesh either

even parked the angle didn't allow much in

Terry think your way is a tiny bit easier haha

You can buy vents to drop in with carbon lip showing ( mostly r35 style) but look on USA sites

Create an account or sign in to comment

You need to be a member in order to leave a comment

Create an account

Sign up for a new account in our community. It's easy!

Register a new account

Sign in

Already have an account? Sign in here.

Sign In Now


  • Similar Content

  • Latest Posts

    • Drain it. I got official Matic D but you can get whatever is listed as Matic D compatible.
    • Thanks guys,  Yeah I should at least have them dynoed, at least then I know what I've got as a starting point.  The springs on these are hard as rocks. I vaguely remember Russman saying he was going to sell the shocks to me with the rocks fitted, as he was keeping the softer springs for his new setup.  I didn't click at the time but of course that was to let me know the shock/spring wouldn't be matched.  I also remember pricing up new springs around 2014-15, but, house, money etc. it never happened. So that was another reason to have them rebuilt. I have rebuilt the forks on many motorcycles so I think I could handle the seals on these easily enough, but getting the valving right would be a rabbit hole I cbf exploring.  Duncan, interesting to hear RP was tuning these back then. I might give them a call.  In the mean time I have been busy fitting sway bars. The Whiteline rear sway bar I purchased 15 years ago finally got fitted, along with the Whiteline front bar that showed up last week. Just waiting on new links for the front sway bar to finish that off.  And my spare set of advan AVS VS5's should be back from the powder coaters in a Pearl White finish sometime this week, with a set of Hankook RS4's lined up for fitting.  And then I just have all the suspension bushes to do. A comprehensive kit is on the way... Lots to do before the Ararat hill climb. Cheers guys 🍻   
    • Nice car! I’m glad folks in the US have gotten past the FnF and are buying real cool cars like the 260RS I was with a bunch of mates in Portland about a year ago and spotted a green Stagea (just a regular 2.5T AWD) parked about 2 blocks away and they were like “a what?” So I made a bet with them for a round of beers and said “ok one of you run down there and tell me if the steering wheel is on the correct side” 5 mins later the American comes trudging back up the hill and goes “he’s right guys. Ok what beer do you want?”
    • Should replace OR drop the tank, give it's good clean. Might be worth replacing that entire fuel level/pump/cradle thing with this: https://frenchysperformancegarage.com/products/fpg-s13-180sx-r32gtst-single-pump-hanger-kit-billet-hat-6-v3-fpg-089?gQT=2  
    • Thank you so much for the help
×
×
  • Create New...