Jump to content
SAU Community

Recommended Posts

Hey guys i was wondering if anyone has a basic DIY for changing the clutch and if they dont just some basic things to look out for. I have a feeling that my thrust bearing may need replacing but obviously to get to that i need to get to the clutch. So yea we did it on my sr20 before but that seemed alot easier than what this will be. anyways if you could help out i would appreciate it

oh its a rb25det from a s2 r33

Link to comment
https://www.sau.com.au/forums/topic/58320-diy-changing-clutch/
Share on other sites

It's really easy providing you've got a hoist (for g/box) and IS time consuming ..

Slightly more awkward than the SR as theres a little less room to work around the bell housing/bolts but .

Disconnect your battery

Start with the usual and remove the gearstick (circlip) then unbolt the prop shaft and have a catch can handy for all the box oil that will drain out of the rear, you might want to re-use this oil also.

Loosen the frontpipe off the exhaust system also which provides a little bit of leaverage to allow the engine to rock.

At this point I'd advise using your hoist under the gearbox to support the weight while you remove the bolts around the gearbox mount. Then slowly, lower the hoist which will allow easy access in undo-ing all the sensor wiring off the gearbox. Use a small flathead screwdriver for this as they can be very hard and brittle after many years in the land of nippon. :rolleyes:

At this point the hoist should be supporting the entirety of the weight apart from the bell housing. Undo all the bolts off the bell housing and push the starter motor aside.

There is limited room to actually wiggle the box out like I mentioned before so be careful with this and do not force it. You'll find that it'll be necessary to slightly roll the box around a few degrees to clear the starter motor housing of the firewall (on the bell housing as you probably know).

At this point the box should literally drop out slowly as you lower the hoist. Then simply roll the hoist back to remove the box completely and presto, it's done.

If you want any specifics let me know :P

hey jengi thanks heaps for the advise that sounds like the majority of what i needed to know :rolleyes:

yea taking the sr20 apart was a bit of a bitch the way we did it eg no hoist lol we wont be making that mistake again.

and once again cheers Jengi really appreciate the help

  • 2 weeks later...

I have done a handful of skyline clutches on the ground. I just advise anyone of concidering doing their clutch without a hoist. The box is quite heavy and large on a skyline and it really just isnt worth the pain and well danger of doing it under the car, from now on i will only do them on a hoist with a trans stand.

I do them on the ground all the time , this is what i do .

Jack the car as high as possible , put stands on all corners then do all the unbolting as jengi posted , i let the gear oil out of the box first though . When all the bolts are undone , i leave a couple on the bellhousing , i use a trolley jack , on the gtr or any 4wd i tie the the box to the jack ( use chain ) ,undo the last 2 bolts on the bellhousing , then lower the box to the ground . If i have clearence problem ( getting it out from under the car ) , i either get another jack and jack the car heigher or i drop the box on a little creaper like trolley and bring out like that .

Of course if you have a hoist and a transmission jack its heaps easier .

  • Thanks 1
  • 4 months later...
I'm thinking of changing my clutch in the next few weeks. Few quick questions...

Do you need a special tool to align the clutch?  

How many litres of fluid does the transmission need?

How long would you expect it to take?

You do need something , a broken shaft will do the job .

Trany takes about 3.8 lts .

Time depends on your skills and tools you have .

Done this before.... 1st time was piss when we didn't change the clutch. As soon as you move the clutch plates and have to realign them and its multi plates it gets tricky.....esp when ur doing it on the ground. We had trouble getting the spline to go through the plates as we could'nt get the angle right.... got the old man to come up and help and went through 1st go :confused:

Cheers.

Also, I'm thinking of just changing the clutch plate. Is this worth the effort or should I replace it with a whole new kit? I dont really want the pedal to feel heavier than stock...

Why you want to change the "just the clutch plate " , is the clutch slipping ? if yes dont bother do a complete job , if no dont bother taking it out until it starts slipping .

by clutch plate do you mean the thrust bearing ??? if so i would do it thats the only reason i was going to drop the box out to replace that but i have since realised it is not worth the effort.

Thrust bearing is just that a bearing , clutch plate is the round thing with the friction material on it , so no 2 different things .

Why you want to change the "just the clutch plate " , is the clutch slipping ? if yes dont bother do a complete job  , if no dont bother taking it out until it starts slipping .

Obviously its slipping. Even in 5th at 100km/h, before it makes full boost, it slips.

After doing some reading it seems that changing just the clutch plate provides more 'bite' while retaining the factory feel of the pedal (and its cheaper). Is this true?

Obviously its slipping. Even in 5th at 100km/h, before it makes full boost, it slips.  

After doing some reading it seems that changing just the clutch plate provides more 'bite' while retaining the factory feel of the pedal (and its cheaper). Is this true?

If it slips , bite the bulet take the box off and replace the whole thing .

You dont have to use a different pressure plate , you can use a Nissan one if you like ( i wouldnt though ) .

By just changing the clutch plate now , you are going to have to pull the box down again to replce the pressure plate , clutch plate and thrust bearing very soon.

The reason its slipping worn clutch plate and pressure plate or to much power if not stock.

  • 1 year later...

ok sounds hard but eazy at the same time to change the clutch.

atm i only have the money to get a decent clutch and dont have money to pay someone to install a clutch.

when dropping out the gear box does it slide off the drive shaft or dose it stay connected and it just dropps down to give you access to the clutch??

if someone has pics of what to undo would be help full or a site that gives more details

thanks

Create an account or sign in to comment

You need to be a member in order to leave a comment

Create an account

Sign up for a new account in our community. It's easy!

Register a new account

Sign in

Already have an account? Sign in here.

Sign In Now


  • Similar Content

  • Latest Posts

    • Had I known the diff between R32 and R33 suspension I would have R33 suspension. That ship has sailed so I'm doing my best to replicate a drop spindle without spending $4k on a Billet one.
    • OEM suspension starts to bind as soon as the car gets away from stock height. I locked in the caster and camber before cutting off the kingpin. I then let the upright down in a natural (unbound) state before re-attaching it. Now it moves freely in bump and droop relative to the new ride height. My plan is to add GKTech arms before the car is finished so I can dial camber and caster further. It will be fine. This isn't rocket science. Caster looks good, camber is good, upper arm doesn't cause crazy gain and it is now closer to the stock angle and bump steer checks out. Send it.
    • Pay careful attention to the kinematics of that upper arm. The bloody things don't work properly even on a normal stock height R32. Nissan really screwed the pooch on that one. The fixes have included changing the hole locations on the bracket to change the angle of the inner pivot (which was fairly successful but usually makes it impossible to install or remove the arm without unbolting the bracket from the tower, which sucks) and various swivelling upper arm designs. ALL the swivelling upper arm designs that look like a capital I (with serifs) suck. All of them. Some of them are in fact terribly unsafe. Even the best one of them (the old UAS design) shat itself in short order on my car. The only upper arm that works as advertised and is pretty safe is the GKTech one. But it is high maintenance on a street car. I'm guessing that a 600HP car as (stupidly, IMO) low as you are going is not going to be a regular driver. So the maintenance issues on suspension parts are probably not going to be a problem. But you really must make sure that however your fairly drastically modded suspension ends up, that the upper arms swing through an arc that wants to keep the inner and outer bolts parallel. If the outer end travels through an arc that makes that end's bolt want to skew away from parallel with the inner bolt, you will build up enormous binding and compressing forces in the bushes, chew them out and hate life. The suspension compliance can actually be dominated by the bush binding, not the spring rate! It may be the case that even something like the GKTech arm won't work if your suspension kinematics become too weird, courtesy of all the cut and shut going on. Although you at least say there's no binding now, so maybe you're OK. Seeing as you're in the build phase, you could consider using R33/4 type upper arms (either that actual arm, OEM or aftermarket) or any similar wishbone designed to suit your available space, so alleviate the silliness of the R32 design. Then you can locate your inner pivots to provide the correct kinematics (camber gain on compression, etc).
    • The frontend wouldn't go low enough because the coilover was max low and the upper control arm would collapse into itself and potentially bottom out in the strut tower. I made a brace and cut off the kingpin and then moved the upright down 1.25" and welded. i still have to finish but this gives an idea. Now I can have a normal 3.25" of shock travel and things aren't binding. I'm also dropping the lower arm and tie rod 1.25".
    • Motor and body mockup. Wheel fitment and ride height not set. Last pic shows front ride height after modifying the front uprights to make a 1.25" drop spindle.
×
×
  • Create New...