Jump to content
SAU Community

Recommended Posts

Wasn't sure exactly where to post this, so.. well.. here will do.

Okay, so I was parking my car and all of a sudden I start hearing this crazy squeeling sound, I was in the middle of a busy car park so I drove it like 20m and left it on the side of the street. Upon inspected, none of my belts were spinning. Well.. they came and went and then eventually stopped completely.

However, the car still idled fine (except for the squeeling sound) and still is capable of driving (just with no alternator, AC, power steering, water pump, etc). It goes forward and backward and still starts.

The only conclusion I've reached is that something has gone wrong with the harmonic balancer as that is capable of causing all the belts to stop.

Since then, I've had it in a workshop and they've told me something to do with the woodruff key f**ked up. This to me doesn't make sense. These don't just come loose (as far as I'm aware) since they're machined fit and are held in by a number of other factors. But possibly he meant the harmonic balancer bolt that goes into the crankshaft (possibly not tightened properly)? He has told me that the harmonic balancer is stuffed and will need replacing and the crankshaft is damaged.

Another thing I don't understand is how the crankshaft is damaged and why bill is estimated at 1/4 of 5 digits.

Can any of you share your wisdom. Any ideas are greatly appreciated. Thank you.

Link to comment
https://www.sau.com.au/forums/topic/136568-soo-my-belts-dont-spin/
Share on other sites

The woodruff key holds the harmonic balancer in the right place on the crank, it sits in a recess on the crank, and fits into a slot on the harmonic balancer, either the crank has broken around the key and then it's moved around and f**ked shit up or (more likely) the key has just broken..and f**ked shit up.

To fix properly it's exxy 'cos it's engine out, pulled down, fixed, then put back together, then engine back in, it can be done dodgy, but then the harmonic balancer is unlikely to ever come off again...

woodruff keys would explain it, the bolt only holds the hb and timing gear in place but these are a bastard to get out even without the bolt.

in an engine in bad shape its possible to shear them off, although i havent seen it happen.

what it MAY be, but this is purely my idea and may be completley wrong...

someones taken your HB off and lost a woodruff key in the process (your crank has 2, one for the timing belt gear which sticks out a bit into the HB, and one mainly for the HB). they might have thought it would be fine on the one sticking out of the timing belt gear.

its either that or your HB woodruff key has sheared off completley which would explain your car still running ok from the woodruff key still attached on the timing belt gear (otherwise you would have done serious damage to valves, pistons from cam timing being off).

You may not need a new crank either, they can weld and re-machine woodruff key holes and splines etc. But it is very much a specialist job. It's a special technique, a special weld, all without any distortion, and no heat stress. I'd avoid metal spraying it can chip under stress. And it would still require a motor rebuild etc. But it is as good as new or better. I've had it done on motors that you can no longer get parts for and they are holding up fine.

But a reco or new crank may be cheaper, you'll have to suck it and see!

Create an account or sign in to comment

You need to be a member in order to leave a comment

Create an account

Sign up for a new account in our community. It's easy!

Register a new account

Sign in

Already have an account? Sign in here.

Sign In Now


  • Similar Content

  • Latest Posts

    • After my last update, I went ahead with cleaning and restoring the entire fuel system. This included removing the tank and cleaning it with the Beyond Balistics solution, power washing it multiple times, drying it thoroughly, rinsing with IPA, drying again with heat gun and compressed air. Also, cleaning out the lines, fuel rail, and replacing the fuel pump with an OEM-style one. During the cleaning process, I replaced several hoses - including the breather hose on the fuel tank, which turned out to be the cause of the earlier fuel leak. This is what the old fuel filter looked like: Fuel tank before cleaning: Dirty Fuel Tank.mp4   Fuel tank after cleaning (some staining remains): Clean Fuel Tank.mp4 Both the OEM 270cc and new DeatschWerks 550cc injectors were cleaned professionally by a shop. Before reassembling everything, I tested the fuel flow by running the pump output into a container at the fuel filter location - flow looked good. I then fitted the new fuel filter and reassembled the rest of the system. Fuel Flow Test.mp4 Test 1 - 550cc injectors Ran the new fuel pump with its supplied diagonal strainer (different from OEM’s flat strainer) and my 550cc injectors using the same resized-injector map I had successfully used before. At first, it idled roughly and stalled when I applied throttle. Checked the spark plugs and found that they were fouled with carbon (likely from the earlier overly rich running when the injectors were clogged). After cleaning the plugs, the car started fine. However, it would only idle for 30–60 seconds before stalling, and while driving it would feel like a “fuel cut” after a few seconds - though it wouldn’t fully stall. Test 2 – Strainer swap Suspecting the diagonal strainer might not be reaching the tank bottom, I swapped it for the original flat strainer and filled the tank with ~45L of fuel. The issue persisted exactly the same. Test 3 – OEM injectors To eliminate tuning variables, I reinstalled the OEM 270cc injectors and reverted to the original map. Cleaned the spark plugs again just in-case. The stalling and “fuel cut” still remained.   At this stage, I suspect an intermittent power or connection fault at the fuel pump hanger, caused during the cleaning process. This has led me to look into getting Frenchy’s fuel hanger and replacing the unit entirely. TL;DR: Cleaned and restored the fuel system (tank, lines, rail, pump). Tested 550cc injectors with the same resized-injector map as before, but the car stalls at idle and experiences what feels like “fuel cut” after a few seconds of driving. Swapped back to OEM injectors with original map to rule out tuning, but the issue persists. Now suspecting an intermittent power or connection fault at the fuel pump hanger, possibly cause by the cleaning process.  
    • For race cars, this is one part where I find having the roll cage bar having gone through a hole in the floor better than the build it up on a ledge inside... The Merc I help on, the main hoop ends are marked on the car, and the jack is marked... Jack goes under a few inches and lifts one whole side of the car up... Removes that fight for long slim jacks for race car duties!   My biggest issue for the daily drivers I work on, is my jacks don't go high enough. The jacks start out on a few blocks, jack it up, then start a second jack under it on more blocks, and then I can get an axle stand under it. My axle stands are presently in use, and are nearly fully extended. The car is sitting with barely more than a cm of clearance to get the wheel off the studs! Sarah's Kluger is the same, as it has an ungodly amount of droop available in the suspension and a distinct lack of good jacking points!
    • Happy? Yep, my to do list is getting shorter and shorter. Either this light approaching is the end of the tunnel, or I'm about to be hit by a train... Ha ha ha   Also, Duncan isn't that far out of town that you need to make a multi day drive out of it. 😛
    • Sorry I meant that we are building the EH for a client.
    • LOL, when one "money pit" is never enough Noice, and excellent work mate
×
×
  • Create New...