Jump to content
SAU Community

Recommended Posts

The bathurst GTR's had a thicker block than ur normal rb26dett, they kept cracking the normal RB26 blocks and it was only making approx 600hp.

The one and only genuine N1 block that I have looked at (and had ultrasonically tested) has thicker cylinder walls. This seems to have been accomplished by casting the water jackets smaller. The outside of the block looked the same as normal:cheers:

I used Domed 87mm RB25 Wiseco forgy's, decked the block .020" and ended up with a CR of 8.2-8.3:1.

My calculations on paper said that I should have ended up with a static comp of 9.2:1 HOWEVER after the physical measurements & dummy assembly that was far from being true. This is why it is so important not to buy from a catalogue.

Which ones? Were they custom or out of the catalogue?

-----

While we are talking about Forgy's..

I've discovered I have a little piston slap while its stone cold.

I was watching a CA18DET that had forged internals on the dyno, I heard the same slight strange noise from that. I asked what the noise was and was told it is slight piston slap.

The CA18DET was one of Nisspeed's cars (Who builtup Whatsisnames and a few other tough RB's). What suprised me was that the CA18DET was slapping while it was warm. I suspect large bore clearances due to the amount of boost that was needed to make 200rwkw from the poor ol' 1.8ltr.. heheh

I suspect I have the slight slap when stone cold due to the larger bore clearances that were setup.

I said to the engine builder that I may be running hard stints around Mallala and may even run up to 24psi.

He said the Wiseco specs were to make the clearance larger if you are using the motor on the track or 24psi. So he did so...

the pistons were catalogue rb25 forgies brought thru Trev, JNR24

compared 2 sets side by side, same part numbers, mine were just larger :S

cant complain now, whats done is done. Just need to sort out alot of shitty things before i can put the motor into the car

So the dummy assemble gave you the 9:1?

Not to worry... ditch the 2mm headgasket and drop a set of big cams in it.. :spank:

Its best not to have a huge quench with a high static comp as its an invite for detonation.

What did the comp ratio work out to without the 2mm headgasket?

What was the deck height?

Hey Joel,

Do you know what piston clearance was machined into your setup?

I've finally had my first mechanical malody on the RB30DET. I was expecting the engine to grenade but its turned out to be the turbo. The rear shaft support bearing looks like it completely disintergrated and either blew out the exhaust or fell into the oil return into the sump. With only the front bearing the whole shaft assembly wobbled itself to destruction with both wheels rubbing and grinding themselves on their respective housings...the result...great clouds of smoke remeniscent of the old formula 1 turbo days. Needless to say I quickly turned around and shut it down.

As an aside...I have previously stated that the turbo was an SB8005A. Well in taking a closer look and knowing more now than 3 years ago, it is actually an SB8006, part # 70177-14 (the engraved cover helps ! ) That means it had the 82mm GT40 series compressor wheel, not the TO4S as previously thought, mated to a GT30 60mm turbine. In consideration to the Garrett performance catalogue, this appears to be a GT30R with the larger GT35R compressor wheel, even though the core part numbers are still different. This makes me less worried about using the proper GT35R with its larger turbine in the new build.

Phantom,

I'm running a 0.004" piston/bore clearance for what they state as track and or 24psi+.

General street use of under 24psi & no track they recommend a 0.003" clearance.

I figured i want to be able to push it hard up at Mallala and not worry about a piston locking the motor and throwing a rod.

The piston slap is really quiet when cold, you have to really listen and know what you are listening for otherwise it sounds a little like a slightly noisy top end. To hear it you have to lift the bonnet and put your head down near the exhaust side.

Warm up.. I generally idle it for 30secs-1min while I buckle up and put my wallet etc in the glovebox.

Then literally idle off short shifting and light throttle until water temp is up (~1-2km's) then I drive it normally for another 5-10minutes to wait for the oil temp to come up and oil pressure drop.

---

The RB25DET oil pump gives me quite a bit more oil pressure and much earlier in the rpm over the rb20det oil pump. When cold I get oil pressure up around 7kg or in the middle of the 8 and the line under it.

Once warm oil pressure sits slightly above the first mark which is around 2kg then as soon as you slight raise the rev's oil pressure is up slightly over the 4, once reving its up slightly over 6.

lol got a bit off the track there....

discopotato03....unfortunately time isn't readily available and since I preffer to do all the work myself it will probably be somewhere within Q2 next year before the new engine is ready :D I dont want to throw a nice brand new turbo on an old engine even though its tempting.

Clint32...1.06 rear housing, ~250rwKW, 1 bar

Is there any reason you are building up a new motor?

The only issue I am concerned about is the amount of kms the bores will last for with a .004" clearance. Especially being a daily driver.

Time to buy a little Micra.. lol

Hey Joel,

The spec sheet I got with my Arias forgies also specifies .004", but regardless of intended use. Interestingly it also says that with "Pro-Coating" you can reduce this to .002", which is within the factory spec (upper end) of an RB26DETT. I have yet to assertain what this is but I assume its the typical oil attracting skirt coating and a ceramic crown coating. All of this can be done for a few hundered bucks in Melbourne. I guess if you can deflect as much heat as possible from the crown, and/or use piston squirters less expansion wil occur allowing a tighter clearance. It would be interesting to put a piston in an oven to 2-300 degrees and see exactly how much they expand with a micrometer, although I have no idea what the typical skirt running temperature would be. I doubt it would be much higher than this or else the oil would carbonise pretty quickly.

As for the new engine build....I want to push the envelope a bit higher...aftermarket rods/pistons/rb26 head etc. to the tune of about 600bhp. I'm hesitant to push my standard internal 75000 km RB30DET to such levels without at least a freshen up, even though it still seems ok, but I want rock solid reliability, without the threat of meltdown all the time. I'm also currently implementing something very time consuming in design and construction.....RB30DETS. Working on it seperately still allows me to drive the Skyline everyday.

Thats quite interesting to know Phantom.

If I were building a street RB30DET I would most certianly stretch to get the coating.

It will only extend the engine life. Piston slap is well knowen to reduce engine life.

Phantom, when the motor goes all together could you post what deck height, how much you had to deck the block, comp ratio and the rest of the specs?

Reason being is when selecting pistons I had trouble with the off the shelf range. Basically they either had a really low comp ratio but good quench or a really high comp ratio and good quench.

I tried getting some specs from Arias but wasn't very successful.

Some km life numbers of a .004" clearance if any one has any?

----

Alf... Long gone are the days of Big V8's with big lumpy cams where daily driving was affected. :)

I agree getting the CR right with pistons flush to the deck is not easy , with the interest in this conversion I'm surprised no ones had specials made . Nizpro has been doing these for ages so does anyone know if they do a piston that suits the std rods , block and four valve heads . Another avenue could be the OS Giken three liter pistons if they're available at a sane price , though if they suit RB26 rods the gudgeons are surely 22mm . It may be possible to run the pistons slightly proud of the block but less than the thickness of the head gasket , this will be limited I guess by the piston to valve clearence and the compression height of the pistons ie how much off the block safely to achieve it . So depending on valve lift approaching top center it may be possible to squeeze in 8.5 - 8.6 to 1 with off the shelf pistons . Joel you have mentioned the ideal squish height or thickness , I'll have to measure my 26 head but the step into the combustion chamber is huge compared to an FJ20 so may work ok ?

My cooling system will use the viscous hub WP fan , I like the idea of the constant airflow through the rad keeping a reserve of slightly cooler water in the core so that the thermostat can controll the jacket temperature . LOL I have never been totally sold on a part time cooling fan and some like me reckon the thermos don't pull enough air anyway . Just my two paseos worth .

Chow for now A .

Joel, the piston slap you refer to earlier in the CA 18 is more likely the top ring land of the piston touching the bore. As a general rule, piston noise when the engine is cold is as you said, the skirt making a little noise just when cold, wich should go after warm up, unless the piston to bore cleaance is massive, ie worn out... piston noise when warm will generally be the top ring land touching, wich can be made worse if the piston to bore cleaance is opened out a little (due to more rock). This can occur when the top ring land is not machined small enough comparative to the skirt size. Its very interesting to look at different piston manufacturers differing designs in this area. there is a general rule of thumb amount smaller this area should be, .008" - .009" per inch of bore. If the top ring land is not this amount smaller, it will become too big as the piston crown begins to heat up and contact the bore, this produces no noise when cold and then begins to make noise as the engine warms up.... if the engine is pulled down slight scuff marks will be seen on the top ring land.Ill bet the pistons in the CA 18 were wiseco, they tend to run fairly large top ring land diameters, ie small difference in skirt to ring land size. So if the clearance was opened up a little on set up, it could put it right on the border of touching... Hope all that makes sense and is of some help...

Create an account or sign in to comment

You need to be a member in order to leave a comment

Create an account

Sign up for a new account in our community. It's easy!

Register a new account

Sign in

Already have an account? Sign in here.

Sign In Now



  • Similar Content

  • Latest Posts

    • From there, it is really just test and assemble. Plug the adapter cables from the unit into the back of the screen, then the other side to the car harness. Don't forget all the other plugs too! Run the cables behind the unit and screw it back into place (4 screws) and you should now have 3 cables to run from the top screen to the android unit. I ran them along the DS of the other AV units in the gap between their backets and the console, and used some corrugated tubing on the sharp edges of the bracket so the wires were safe. Plug the centre console and lower screen in temporarily and turn the car to ACC, the AV should fire up as normal. Hold the back button for 3 sec and Android should appear on the top screen. You need to set the input to Aux for audio (more on that later). I put the unit under the AC duct in the centre console, with the wifi antenna on top of the AC duct near the shifter, the bluetooth antenna on the AC duct under the centre console The GPS unit on top of the DS to AC duct; they all seem to work OK there are are out of the way. Neat cable routing is a pain. For the drive recorder I mounted it near the rear view mirror and run the cable in the headlining, across the a pillar and then down the inside of the a pillar seal to the DS lower dash. From there it goes across and to one USB input for the unit. The second USB input is attached to the ECUtec OBD dongle and the 3rd goes to the USB bulkhead connected I added in the centre console. This is how the centre console looks "tidied" up Note I didn't install the provided speaker, didn't use the 2.5mm IPod in line or the piggyback loom for the Ipod or change any DIP switches; they seem to only be required if you need to use the Ipod input rather than the AUX input. That's it, install done, I'll follow up with a separate post on how the unit works, but in summary it retains all factory functions and inputs (so I still use my phone to the car for calls), reverse still works like factory etc.
    • Place the new daughterboard in the case and mount it using the 3 small black rivets provided, and reconnect the 3 factory ribbon cables to the new board Then, use the 3 piggyback cables from the daughterboard into the factory board on top (there are stand offs in the case to keep them apart. and remember to reconnect the antenna and rear cover fan wires. 1 screw to hold the motherboard in place. Before closing the case, make a hole in the sticker covering a hole in the case and run the cable for the android unit into the plug there. The video forgot this step, so did I, so will you probably. Then redo the 4 screws on back, 2 each top and bottom, 3 each side and put the 2 brackets back on.....all ready to go and not that tricky really.      
    • Onto the android unit. You need to remove the top screen because there is a daughterboard to put inside the case. Each side vent pops out from clips; start at the bottom and carefully remove upwards (use a trim remover tool to avoid breaking anything). Then the lower screen and controls come out, 4 screws, a couple of clips (including 3 flimsy ones at the top) and 3 plugs on the rear. Then the upper screen, 4 screws and a bunch of plugs and she is out. From there, remove the mounting brackets (2 screws each), 4 screws on the rear, 2 screws top and bottom and 3 screws holding in the small plates on each side. When you remove the back cover (tight fit), watch out for the power cable for the fan, I removed it so I could put the back aside. The mainboard is held in by 1 screw in the middle, 1 aerial at the top and 3 ribbon cables. If you've ever done any laptop stuff the ribbon cables are OK to work with, just pop up the retainer and they slide out. If you are not familiar just grab a 12 year old from an iphone factory, they will know how it works The case should now look like this:
    • Switching the console was tricky. First there were 6 screws to remove, and also the little adapter loom and its screws had to come out. Also don't forget to remove the 2 screws holding the central locking receiver. Then there are 4 clips on either side....these were very tight in this case and needed careful persuading with a long flat screw driver....some force required but not enough to break them...this was probably the fiddliest part of the whole job. In my case I needed both the wiring loom and the central locking receiver module to swap across to the new one. That was it for the console, so "assembly is the reverse of disassembly"
    • But first....while I was there, I also swapped across the centre console box for the other style where the AV inputs don't intrude into the (very limited !) space.  Part# was 96926-4GA0A, 284H3-4GA0B, 284H3-4GA0A. (I've already swapped the top 12v socket for a USB bulkhead in this pic, it fit the hole without modification:) Comparison of the 2: Basically to do the console you need to remove the DS and PS side console trim (they slide up and back, held in by clips only) Then remove the back half of the console top trim with the cupholders, pops up, all clips again but be careful at the front as it is pretty flimsy. Then slide the shifter boot down, remove the spring clip, loose it forever somewhere in the car the pull the shift knob off. Remove the tiny plastic piece on DS near "P" and use something thin and long (most screwdrivers won't fit) to push down the interlock and put the shifter down in D for space. There is one screw at the front, then the shifter surround and ashtray lift up. There are 3 or 4 plugs underneath and it is off. Next is the rear cover of the centre console; you need to open the console lid, pop off the trim covering the lid hinge and undo the 2rd screw from the driver's side (the rest all need to come out later so you can do them all now and remove the lid) Then the rear cover unclips (6 clips), start at the top with a trim tool pulling backwards. Once it is off there are 2 screws facing rearwards to remove (need a short phillips for these) and you are done with the rear of the console. There are 4 plugs at the A/V box to unclip Then there are 2 screws at the front of the console, and 2 clips (pull up and back) and the console will come out.
×
×
  • Create New...