Jump to content
SAU Community

Recommended Posts

Hey guys,

I've been looking at thread trying to find the answer to my problem but I'm still confused and don't know where to start.

OK so I'm running a GT35R, 850cc injectors, Z32 AFM, walbro fuel pump, power fc (not running the O2 sensor because it made it rich as) etc etc.

I got it back from the tuners 2 weeks ago and he said he couldn't take it over 14psi because it was begnning to sputter at high RPM anywhere above 14psi, so he just placed a safe tune of 9psi on it running 200rwkw.

The tuner said I needed to get new coilpacks so Splitfires are on the books.

However, the past few days something weird has started happening. I let my car warm up, start driving ITS FINE. Then when I'm in 4th gear on a flat road or going down hill and i press the accelerator ever so slightly, I'll get a few sputters, but if I drop the gear and give it it will come on boost no worries.

Anyways, so yesterday I'm driving down the highway and im in 4th gear and i try to accelerate. My car starts sputtering so bad that I can't even get it to move. So i have to pull over and I cant get the revs over 1500 RPM because its sputtering so bad even when im reving it on the spot.

I let my car sit there for a minute or two, take off and its fine, however it begins doing it every now and again after a couple of minutes so I left it at my grandmas house and got a lift.

I picked up my car after a couple of hours and it was fine on the cold start, driving perfectly, but as soon as it warmed up it began doing the same thing.

It eventually got so bad that i pulled over and the check engine light came on and it began searching for idle and every time i would rev it, the revs would drop so low it almost stalled until finally it did stall.

I got it home driving 40 km/h in 4th gear not taking it over 2000RPM. LEft it over night.

I started it up this morning and gave it a few revs and the problem isn't there. So i'm assuming it only happens when the car warms up which leads me to believe it is the coilpacks. However, I want to be 100% sure before I go spend $600 on splitfires.

Cheers

Chris.

Link to comment
https://www.sau.com.au/forums/topic/326290-sputtering-issue-wtf/
Share on other sites

  Muff said:
are you still using afm???

could be a prob with the solder in the afm.

happended to me. + the car would cut out.....

good luck

Hey mate

Yeah I'm using a Z32 ...

But if that was the case, how come it worked fine for the first 2 weeks?? :S

i do have alot of missfire and the head of my engine gets really really hot i don't know if this is normal?

Edited by LI51CA

Z32 AFM 2nd hand by any chance? If so there is a better than even chance it may need re-soldering.

CRC Red Urethane Seal Coat for your coil packs is the cheapest fix. Click the link below for more info.

http://www.skylinesaustralia.com/forums/in...t&p=4540665

  LI51CA said:
I started it up this morning and gave it a few revs and the problem isn't there. So i'm assuming it only happens when the car warms up which leads me to believe it is the coilpacks. However, I want to be 100% sure before I go spend $600 on splitfires.

Hey mate, have a read through my misfire resolution thread before buying the coilpacks. In my case the Crank Angle Sensor was stuffed, which caused misfiring and lack of power from 4000 rpm onwards.

Ideally you could look into borrowing a set of coils from someone for a day and testing with those both cold and warm to see whether they fix the problem or not.

Cheers

mate if you read my post... its only running 9psi because i need new coils because anything above 14psi it breaks down... the pump is fine for 500hp my mate has a similair set up and no porblems...

I'm not replacing anything

  paulr33 said:
GT35R + 200rwkw + walbro pump

something doesn't add up

please replace the fuel pump and check the AFR's

  • 3 months later...

hey guys,

i have spent almost all day reading up different threads to find something similar to what im dealing with and this is the closest so far.

i recently had some pretty big leaking from my injectors on my 1990 R32 GTR (so bad it was actually dripping from all the way down at the bell housing under the car), after changing out the sels n rings the two problem injectors where still leaking. Luckily a friend had some spare working GTiR injectors which he sent me for FREE!! (anything free is just awesome) haha. I swapped out the two leaking ones and everything seemed to be good, no leaking or fuel smell.

Took the car for an hour and a half run to gold coast from northern NSW and it was running quite smooth. spent a night up there having a few "spirited" drives and returned the next day. while returning back down d coast i noticed a few times that there didnt seem to be full power under the accelerator but nothing much and once i put my foot down it would start pulling like always. 30-40 minutes later near byron bay the car started spluttering and struggleing so bad i could barely get it to accelerate and with my foot in a consitatnt position it was as if i was bliping the throttle, after bout 30secs-1min of me freaking out and trying to get to a spot to pull over the problem cleared and the car seemed back to normal. so i keep driving keeping a very watchful eye on everything and it seemed fine for a while. i then noticed that when it felt a bit low on power again a few times while cruising, & even while travelling around 80km on the highway, if i put it in neutral and didn't accelerate the car would completely stall even once bring up the check light for a few seconds while still moving along. a bit firther down the road and it started spluttering n freaking out again to the point where i could barely accelerate, or even keep the revs up. again after another 30-1min it returned to running fine.

i pulled over once i got to a nice big carpark to check what i could see and nothing looked wrong and car was running fine again, so took it home and parked it.

I have read to check and clean the AAC and IAC, which i will be doing today, and also that it could be a crankangle sensor, or AFM's, or O2 sensor, or engine temp sensor, or faulty coil packs, or even ECU.

can anyone help who may have experienced something similar. i no this is a long post and am sorry to jack the thread but i am at wits end and need to drive the car 10hrs down to sydney in a few day and dont really want this to happen again. i am going to try to look at all these things but currently dont have a scan tool or much time so i want to try and narrow down my search.

thanks heaps guys.

  • 4 months later...
  On 01/11/2010 at 4:02 AM, KrayzieGTR said:

hey guys,

i have spent almost all day reading up different threads to find something similar to what im dealing with and this is the closest so far.

i recently had some pretty big leaking from my injectors on my 1990 R32 GTR (so bad it was actually dripping from all the way down at the bell housing under the car), after changing out the sels n rings the two problem injectors where still leaking. Luckily a friend had some spare working GTiR injectors which he sent me for FREE!! (anything free is just awesome) haha. I swapped out the two leaking ones and everything seemed to be good, no leaking or fuel smell.

Took the car for an hour and a half run to gold coast from northern NSW and it was running quite smooth. spent a night up there having a few "spirited" drives and returned the next day. while returning back down d coast i noticed a few times that there didnt seem to be full power under the accelerator but nothing much and once i put my foot down it would start pulling like always. 30-40 minutes later near byron bay the car started spluttering and struggleing so bad i could barely get it to accelerate and with my foot in a consitatnt position it was as if i was bliping the throttle, after bout 30secs-1min of me freaking out and trying to get to a spot to pull over the problem cleared and the car seemed back to normal. so i keep driving keeping a very watchful eye on everything and it seemed fine for a while. i then noticed that when it felt a bit low on power again a few times while cruising, & even while travelling around 80km on the highway, if i put it in neutral and didn't accelerate the car would completely stall even once bring up the check light for a few seconds while still moving along. a bit firther down the road and it started spluttering n freaking out again to the point where i could barely accelerate, or even keep the revs up. again after another 30-1min it returned to running fine.

i pulled over once i got to a nice big carpark to check what i could see and nothing looked wrong and car was running fine again, so took it home and parked it.

I have read to check and clean the AAC and IAC, which i will be doing today, and also that it could be a crankangle sensor, or AFM's, or O2 sensor, or engine temp sensor, or faulty coil packs, or even ECU.

can anyone help who may have experienced something similar. i no this is a long post and am sorry to jack the thread but i am at wits end and need to drive the car 10hrs down to sydney in a few day and dont really want this to happen again. i am going to try to look at all these things but currently dont have a scan tool or much time so i want to try and narrow down my search.

thanks heaps guys.

Was driving my R33 GTR from sydney to melbourne, this has also happened to me, was cruising for about 3 hours then the symptoms above started happening, hesitation misfire etc, pulled over drove and again couple mins later and the car was fine,

It seems to come and go. im leaning towards coilpacks or AFM, anyone have an idea? don't want to be throwing parts into the problem trying to find a fix

Pull the top cover off your afms and resolder the joints. My car had pretty much identical symptoms and thats what caused mine.

The reason they run fine cold is because the solder joints still contacted well enough to not lose signal but when a bit of heat gets into it the dry joints open up and go open cct.

If i get a chance at work tommorrow ill gut my spare one and make up a tutorial on fixing them, its fairly simple and on takes bout 20 min.

Create an account or sign in to comment

You need to be a member in order to leave a comment

Create an account

Sign up for a new account in our community. It's easy!

Register a new account

Sign in

Already have an account? Sign in here.

Sign In Now


  • Similar Content

  • Latest Posts

    • Seat of the pants assessment of the new intake: The car is way less "doughy" when hitting the loud pedal, especially off idle when stopped or in traffic, I did use a cheapo lazer thermal thingo to measure the temp around where the pod filter got its air, it was between 55 - 60°C, in saying this the car was shut off and not moving, so the OEM intake pipe was not supplying any fresh air to where the pod was when the car was at least moving A weird bonus was induction noise on the throttle in the cabin increased a bit,  I was worried that I was actually going to lose some of that induction noise I love so much, outside though, when I got the daughter to do a WOT drive by pass for me, the induction noise has increased alot when on the throttle, not quite ITB doort, but well up there I'm extremely happy with the results and have been exploring the country roads in the region  As for house mods: 1.New front fence is up and is awesome, it really upgraded how the joint looks from the street, and the added security is nice 2. Electricians have replace some interior lights, and with more lighting in the garage, a few new motion detecting lights out the front above the garage, front room, and at the front door, which I have already found heaps helpful coming and going, also now has fancy pants CCTV all round the house The only hold point for power though is the solar and batteries due to supply issues, although this will happen over the next few weeks 3. I have done a heap of landscaping out the front and I'm almost ready to do a new small retaining wall with some nice blocks to replace the brick and cemented in rocks around the raised garden beds cemented in river stone "was the fashion at the time" the house was built. I currently have a pallet of retaining wall blocks and 2 bulka bags of 20mm blue metal to replace the wood chip that is in the raised garden beds around the house 4. I now have 3 big raised garden beds for out the back to grow some vegetables, about 70cm high, 200cm long and 100cm wide 5. My 2 compost bins are already pretty full with brown, green and kitchen waste from the landscaping I'vedone so far, but they will probably take a few months to break down, so anything else that gets chopped, trimmed, and kitchen waste will just start filling the base of the raised garden beds to about 30cm before I start throwing 40cm of good compost, and stuff, for the vegetables to grow in, I'll need a few ton of compost and soil, but the local supplier can sent me bulka bags of the stuff Basically the logs, wood chips and a few strategically placed rocks for drainage, will give the beds some good organic materials down low to break down over time, and they will hold moisture during the warmer months to save the water in my big arse water tank if we don't get alot of rain So, all in all, the car and house mods are going well, and I'm really enjoying being retired, I sleep in too 0700 and slowly plod around inside until I feel like actually doing anything, and only work in the yard for as long as want, which has actually been alot over the last few weeks,  although when you look at it, it seems that not a huge amount of work has been done,  until I look at the before I started the work pics Happy days and good times indeed 
    • hahaha yeah. Plan is to get side skirts and probably just rear pods. But going to do them one-by-one. I've got a set that I really like from RHDJapen, but that one isn't shipped to AU. So need to find someone who can get it for me
    • Here's an idea, answer the questions I asked you as they are trying to work out WHY the LSD will be binding up in a straight line.
    • You haven't driven many modern cars then have you? Most of them have sfa steering feel with their stupid electric bullshit steering systems.
×
×
  • Create New...