Jump to content
SAU Community

Recommended Posts

I was going to run WMI, but was told but so many people not to, I am kinda glad I didnt now, you are right water stays cooler for longer, but once it warms up it is almost impossible to get cold again with the size heat exchanger you can fit in most cars without lots of cutting etc.

  • Replies 58
  • Created
  • Last Reply

Top Posters In This Topic

It'll be a water to air intercooler. The water stays cool for a fair while after u slow down. 12psi is pretty low tho. Hottest days here in Tas are about 35 degrees at the very most and i won't have air con or anything. Also I'll be running a Haltech with air temp compensation set up to run richer once air temps get too high for my liking.

had nothing but trouble with W2A they heat soak way to much, i even tried a 600x400 radiator and an extra reserve in the boot to slow down heat soak. Under bonnet temps just kill the benefits... if you could mount the w2a in the cabin away from under bonnet heat it would be great.... just not practical.

There's a LOT of shit out there in terms of crap water to air intercoolers. I think that crap (75% of the stuff out there) gives it a bad name. I'm gonna give it a go in what i think would work with a massive overkill of radiator area (multiple radiators). Also the huge total surface area of the fins inside the intercooler is hundreds of times more than the outer surface of the heat exchanger. i can't see how it'd be affected by under bonnet temps any more than it does to intercooler piping. The thought of 30cm of total piping length plus an intercooler half the volume of a conventional fmic is too good not to at least try. i want near instant throttle response and full boost at about 2500rpm!

increase to 10:1 on pump your crazy... on E85 then your talking.

AEM ecu is awesome providing its the version 2. My favourite plug in ecu atm behind PFC.

crazy? maybe 11:1...or even 12:1 with E85... many can do all day with those comp ratios.

Higher comp is more efficient but too much with not good enough fuel means detonation.

Higher comp will make more power for the same level of boost, all else being equal.

Higher comp will bring boost on quicker.

Lower comp allows running more boost without detonation on the same fuel.

I read a lot about -9's and -5's. -9's fit a perfect to street car for what most people say, but once it reaches the upper rpms it runs out of it's puff, this is where the -5's shine.

Here's a dyno graph with a comparison of -9 and -5's, the taller line is obviously -5s, but you can see that the -9's match the description as above.. and notice that the -5's are only 300 rpms behind. But notice the torque curve... even though not sooner, but it allows you to say in gear longer before it dives down.

v4qiyg.jpg

They follow nearly nearly identical paths on the up climb (the difference noted above), the -5's does it more efficiently. I plotted both the -9's and -5's compressor maps. Like I said 77% over 74%, less hot air the better. Tuning and cams can make the -5 spin sooner.

I am after a track build, what ever gets me around the corners faster and have enough top end to keep up in the straights. Raising CR will allow more off-boost power, which for a tracker that means a fatter power band to be used. My differential ratio is 4.363, so naturally in the higher rpms...with this...it would make the -5 spin sooner...and in the end I would have a lot of top end too. A bit of tuning can make the -5's respond sooner as well.

i call bogus on the comparo.... ramp rates are not the same between runs.... i have the same dyno and can tell you the only way to split the runs like that is to either run a 4sec start delay to build boost or increase the ramp rate in seconds..

Power correction is in DIN which over inflates the power by a bit too (about 10-15rwkw @ that power)...

There's a LOT of shit out there in terms of crap water to air intercoolers. I think that crap (75% of the stuff out there) gives it a bad name. I'm gonna give it a go in what i think would work with a massive overkill of radiator area (multiple radiators). Also the huge total surface area of the fins inside the intercooler is hundreds of times more than the outer surface of the heat exchanger. i can't see how it'd be affected by under bonnet temps any more than it does to intercooler piping. The thought of 30cm of total piping length plus an intercooler half the volume of a conventional fmic is too good not to at least try. i want near instant throttle response and full boost at about 2500rpm!

we were using PWR kits.

we were using PWR kits.

I REALLY hate putting down Australian companys but that is exactly what I was talking about. The core design is terrible. The ratio of coolant to charge air area is way wrong and tube and fin intercoolers with the charge air going through the tubes like in an air to air is very inefficient in a water to air core.

Best is a very fine bar and plate design with lots of fin surface area. Also the coolant passages don't need to be anywhere as big as the air passages because the coolant can transfer heat much easier than water. This means more area for the charge air in the same physical dimensions.

Plazmaman or ARE are the way to go.

I agree that getting the heat out of the water is the hardest part and a huge challenge. I don't even know if it'll be any good but i'm willing to take the risk. I'm only aiming for 220-240rwkw and the car has heaps of frontal area to use for the radiators. (one in the middle where a FMIC goes , fully ducted and one off to the side where an oil cooler is usually mounted)

Edited by bradsm87

I REALLY hate putting down Australian companys but that is exactly what I was talking about. The core design is terrible. The ratio of coolant to charge air area is way wrong and tube and fin intercoolers with the charge air going through the tubes like in an air to air is very inefficient in a water to air core.

Best is a very fine bar and plate design with lots of fin surface area. Also the coolant passages don't need to be anywhere as big as the air passages because the coolant can transfer heat much easier than water. This means more area for the charge air in the same physical dimensions.

Plazmaman or ARE are the way to go.

I agree that getting the heat out of the water is the hardest part and a huge challenge. I don't even know if it'll be any good but i'm willing to take the risk. I'm only aiming for 220-240rwkw and the car has heaps of frontal area to use for the radiators. (one in the middle where a FMIC goes , fully ducted and one off to the side where an oil cooler is usually mounted)

yeah we gave up on them, ran a decent 115mm tube and fin cooler and car never ran better.... (bar and plate was just too heavy).

Higher comp is more efficient but too much with not good enough fuel means detonation.

Higher comp will make more power for the same level of boost, all else being equal.

Higher comp will bring boost on quicker.

Lower comp allows running more boost without detonation on the same fuel.

Increasing comp also reduces EGTS when running on E85.

about 9.7:1 and 18psi would be the highest I'd go on pump 98.

I know a guy who runs an 11:1 SR20 running 23psi on E85!!!

running big cams means you can get away with higher static comp ratios as the dynamic compression ratio decreases as well, keep this in mind.

  • 1 month later...

http://www.kb-silvolite.com/calc.php?action=comp

Here is the calulator I was going to use but I do not know the "Deck Clearance (in.)Note: Neg. nubmer above deck, Pos. number below deck" if anyone can help?

Create an account or sign in to comment

You need to be a member in order to leave a comment

Create an account

Sign up for a new account in our community. It's easy!

Register a new account

Sign in

Already have an account? Sign in here.

Sign In Now



  • Similar Content

  • Latest Posts

    • Well, I'm tired. I'm tired because about 4PM yesterday, before today's appointment someone immediately bought my bumper. They couldn't get it any other day as they're on the way back to NSW. So I had to do that big GTR conversion I had been planning. Unfortunately, the information on SAU about what you need and how this is done is incomplete. So what should be a simple bolt on affair, yeah, it's not. Did you know if you use all GTR items the bonnet won't close? This little manuever sent me into about 1am the night before trying to dodge a way to get it closed. I will have to revisit this in the next few days  - or maybe not, I may let a body shop figure it out. It all needs to come up and my motivation to pull the bumper off is low. It also seems to hit things in the bay where the GTT bonnet didn't. Yes I used 100% new OEM GTR items. Today, I had the joy of driving to the dyno looking like this: Given I had roughed in the fuel and given sensible but pretty conservative timing, I didn't really bet on having the car drive out any real difference than when it drove in. Sadly due to a miscommunication and laptop fun and games (and almost bricking the dongle, prayers and firmware updates indeed), I ended up using HP Tuner credits to licence the car that was already licenced. So in the end my laptop was used. It turns out my butt dyno is still well calibrated after all this time. The 325kw was on 74% Ethanol, the 313kw line was on 98. The other line is the 'before' line which was 281kw. While the numbers are pretty low, they're pretty in line with what you'd expect. Even if US dynos bump the whole result up about 50KW, gaining 10-15% is similar gains.  The curve of the cam is pretty much spot on with what was discussed as well. All this said, it still feels bad to not see the number you secretly want to see. Even if the car drove great beforehand, and I knew pretty confidently the car would drive out much the same way it drove in due to the nature of a wellish dialled in LS1 not gaining much if anything at all from being tuned from where it was. As expected, the car isn't particularly sensitive to running it at anywhere between 12.0 and 13.0 - And the initial timing at 20deg and 12.0 made 308KW. So 3 degrees of timing, and leaning it out to 12.7 for 5kw, anything above stopped giving any benefit until E85 (which has an additional 2 deg as before). Car itself behaved entirely fine. I found out that 100C = 1.15V! IAT at about 7pm was 19C. I might mess with the bonnet mounting.. but given the REO NEEDS TO BE CHOPPED TO FIT A GTR BAR this is possibly something I may leave gathering (more) dust until it returns to paint jail.
    • It sounds farrrrrrr too cold at your place Duncan... Here I was thinking our 10 degrees overnight is getting cold...
    • oh yeah, reminded this morning....bin lids frozen shut too
    • In my case not, because of total reno. But yeah.
    • Did you use an electronic speedo drive? Does you speedometer read all the way to 180km?
×
×
  • Create New...