Jump to content
SAU Community

Recommended Posts

Mafia,

Did you do a compression test when it was cold and also after when it's warmed up?

Possibility the head isn't torqued properly as well, hard to say. Probably popping off the head is your best option (not fun).

Just out of curiosity, how come you torqued them to 80ft/lbs and not 72ft/lbs as per ARP spec?

I had a little piece of paper that came with the studs that said 80ft/lbs on it, so thats what I went to. Will the extra cause an issue?

Shutting down the engine immediatly from hot and checking the plugs should reveal which plug is being steam cleaned, though thats not a fool proof method, as steam cleaning requires some combustion to happen. If the cylinder doesnt fire at all, the plug will just be wet and smell of fuel.

The scope will only spot damage after its happened. Having water in your oil is good enough reason to pull the head off and check the gasket is covering the water and oil passeges properly. Your going to have to do it to fix the issue anyway, so why delay...

Did you do a test alignment of the gasket on the head and the block to make sure it covered the holes?

What kind of gasket did you use?

Was the block decked and the head re-surface before you put the head back on?

Tested the allignment of the gasket, and everything seemed to line up fine, no issues.

Didn't get the head or deck re-surfaced because it was a slapper. I know you're going to call me stupid, but barely checked the flatness of the surfaces. The Engine shop did say the deck was pretty good though. Or good enough I should say.

Mafia,

Did you do a compression test when it was cold and also after when it's warmed up?

Possibility the head isn't torqued properly as well, hard to say. Probably popping off the head is your best option (not fun).

Was still fairly hot \ warm when I did the compression test. Want me to do a cold one? The plugs are still finger tight. Ready to test again.

The head isn't that bad to remove, dropping the turbo off the manifold to the side, disconnecting the inlet pipe, and unplugging the injectors, IAC and the other IAC \ control thing. Then just a matter of dropping the coolant and then cam covers, head bolts, and someone to help you lift it off.

Now, here is a problem, and most of you are probably going to call me a retard (I give you permission to lol).

I realized that I forgot to put in those 3 little bolts. You know. The pricks that are a complete ass to get to when removing the head. And One would think that these allow more seal on the oil drains on the front and back of the head. Water is there too. And since they are oil drains, there is no pressure, and then allowing 13 psi of water into the oil. Probably not much, but enough to create havoc.

*Cowers and waits for the insults*

Edited by The Mafia

You should pressure test the cooling system cold, then warm the engine and do it again.

I wonder if not having the fastners in there is alowing the head to move away from the block (when warm) enough to cause the leak?

Mafia,

Any chance you can put together a list of parts and where you purchased them for the slapper? I'm considering doing this soon as I have just scored a few RB30 Blocks. Not sure if i'd go as far as re ringing and doing the bearings tho for the first block. Second block will be used for a slow build up.

If the paper said 80ft/lbs then thats cool. Unless you used the higher torque from the next grade of studs... Either way I cant see it being an issue.

You probably should pull the head and then clean the gasket and apply hylomar to it and retorque it down. As GTRNUR said, hymolar is fantastic stuff. I've reused the same headgasket three times without any issues :)

Don't beat yourself up for having a go. There are many that wouldnt have gotten as far as you have already, and nobody gets their first engine 100% correct.

A standard graphite syle head gasket will tolerate up to 0.007" of surface variation. Chances are the block was fine, but the heads are rarely perfectly square. The head being alloy tends to take on the distortion of the head gasket and block it was previously bolted too. Its called bruising, and is the main reason heads are shaved, so as to produce a dead flat surface to mate to the block. Having said that, a good coating of hylomar spray on the head gasket would have also guaranteed a seal. When you do re-fit the head, you should give the gasket a good 3 coats a side letting it tack off between coats, so its got an even shade of blue.

The head stud torque will be fine, provided the block was torque plated to the same torque when the finish hones were done. So long as the bolt torque is at the recommended tension, and under the yeild strength of the bolt it will be fine. The blocks hold a hell of a lot of tension. The 1/2" studs in my engine are torqued to 110ft-lb.

thanks GTRNUR. I appreciate your input.

Does anyone know if those 3 little bolts will make all the difference?

I'm thinking of biting the bullet, and just pulling the head - Its might be a "defeat in detail" kind of approach, but I want it to be fixed 100%, and no more guess work.

If I pull the head I can check:

The grub screw

The bores

The gasket (And replace with heaps of hylomar spray)

Install the three little bolts

etc etc

I might even use my spare head - Prep it out of the car, and get it faced.

This "hylomar spray", is it like copper spray?

Hylomar is an ACL product, and its a non-setting high temp silicon base sealant. You get it from supercheap auto or autobarn. Cheap as chips and worth its weight in mur. The acl product is intended for use on copper head gaskets, much like the copper spray, but it is definatly not copper.

Also, I do have a cometic 3 layer 1.3mm head gasket but I was told the surfaces have to be 100% flat for that. So I bought the Durotek 1.3mm graphite with the fire rings.

Definitely couldn't use the cometic?

You normally need a pretty good surface finish to use a mls headgasket. Probably 40RA or finer. Usually with alloy heads/cast iron blocks and mls headgaskets, the finer the finish the better. If you arent getting your head faced, then probably best to not use your mls gasket.

GTRNUR will probably confirm this. After all his development work on his open deck stroker build he would be an expert in this area!

You normally need a pretty good surface finish to use a mls headgasket. Probably 40RA or finer. Usually with alloy heads/cast iron blocks and mls headgaskets, the finer the finish the better. If you arent getting your head faced, then probably best to not use your mls gasket.

GTRNUR will probably confirm this. After all his development work on his open deck stroker build he would be an expert in this area!

Yes I confirm this! I wouldnt consider an MLS gasket unless both surfaces are machined dead flat. Some machineshops use different tooling to shave/deck heads and blocks too. Its worth asking around to see who can do the best surface finish to the highest tolerance. Or just o-ring the cylinders and use a standard gasket and its even better than an MLS gasket.

Not really related to your post but... did you just follow the RB30 guide here on the forum to build your engine? Was there anything missing? I'm considering an RB30, but up til now, biggest job i've done is installing a turbo :P but i have mechanically minded friends who could help

I doubt those 3 little bolts would be an issue, recently when I took off my head on my rb25det I found whoever previously touched it they only put one of those small bolts and didnt put 1 head bolt and I have driven it around for about 100000 with alot of thrashing and the gasket didnt leak or blow.

Ok, so the head has been removed.

Here is the Verdict:

- The Exhaust cam cover at the back was all sludged up with a caramel looking oil \ water.

- The cams were a little sludged up

- I did actually install the two rear little bolts. The front one wasn't installed.

- The head gasket looked like it wasn't sealed properly where the VCT feed is (and grub screwed).

- The bores are still like new and have very prominent hone marks thank f**k.

- Seems the head gasket was the issue all the way, leaking into an oil drain

Resolutions:

- I will check the flatness of the head

- I am thinking if the head doesn't need to be surfaced, I will Defcon the grub screw in to make sure it doesn't leak.

- If the head needs surfacing, I will get the grub screw removed and weld up the head.

- Might look at adjusting the head gasket to suit the gallery a little more

- Will make sure that little bolt at the front is done up nice and tight.

If anyone has anymore tips, I would appreciate anything you can give me.

Thanks again for all of your help here.

GTRNUR was right on the money, thats for sure.

Glad you caught it in time.

I think you'll find a re-surface and some Hylomar will solve all your woes.

Are you planning on doing a full tear down and re-assmelble, or just re-doing the top end? If your going to try just re-doing the top end it is still worth pulling off the main cradle and having a peek at the main bearing journels. Have a look at one or two rod bearing journels as well while your at it. Just so you can restore your confidence in the engine.

  • Like 1

A light spray of Hylomar regardless. Never had an issue doing so, once had an issue not doing so.

And face the head its only $40-50, they give it a bath that will clean all the sludge and crap out of it.

Create an account or sign in to comment

You need to be a member in order to leave a comment

Create an account

Sign up for a new account in our community. It's easy!

Register a new account

Sign in

Already have an account? Sign in here.

Sign In Now



  • Similar Content

  • Latest Posts

    • Hi all,   long time listener, first time caller   i was wondering if anyone can help me identify a transistor on the climate control unit board that decided to fry itself   I've circled it in the attached photo   any help would be appreciated
    • I mean, I got two VASS engineers to refuse to cert my own coilovers stating those very laws. Appendix B makes it pretty clear what it considers 'Variable Suspension' to be. In my lived experience they can't certify something that isn't actually in the list as something that requires certification. In the VASS engineering checklist they have to complete (LS3/NCOP11) and sign on there is nothing there. All the references inside NCOP11 state that if it's variable by the driver that height needs to maintain 100mm while the car is in motion. It states the car is lowered lowering blocks and other types of things are acceptable. Dialling out a shock is about as 'user adjustable' as changing any other suspension component lol. I wanted to have it signed off to dissuade HWP and RWC testers to state the suspension is legal to avoid having this discussion with them. The real problem is that Police and RWC/Pink/Blue slip people will say it needs engineering, and the engineers will state it doesn't need engineering. It is hugely irritating when aforementioned people get all "i know the rules mate feck off" when they don't, and the actual engineers are pleasant as all hell and do know the rules. Cars failing RWC for things that aren't listed in the RWC requirements is another thing here entirely!
    • I don't. I mean, mine's not a GTR, but it is a 32 with a lot of GTR stuff on it. But regardless, I typically buy from local suppliers. Getting stuff from Japan is seldom worth the pain. Buying from RHDJapan usually ends up in the final total of your basket being about double what you thought it would be, after all the bullshit fees and such are added on.
    • The hydrocarbon component of E10 can be shittier, and is in fact, shittier, than that used in normal 91RON fuel. That's because the octane boost provided by the ethanol allows them to use stuff that doesn't make the grade without the help. The 1c/L saving typically available on E10 is going to be massively overridden by the increased consumption caused by the ethanol and the crappier HC (ie the HCs will be less dense, meaning that there will definitely be less energy per unit volume than for more dense HCs). That is one of the reasons why P98 will return better fuel consumption than 91 does, even with the ignition timing completely fixed. There is more energy per unit volume because the HCs used in 98 are higher density than in the lawnmower fuel.
    • No, I'd suggest that that is the checklist for pneumatic/hydraulic adjustable systems. I would say, based on my years of reading and complying with Australian Standards and similar regulations, that the narrow interpretation of Clause 3.2 b would be the preferred/expected/intended one, by the author, and those using the standard. Wishful thinking need not apply.
×
×
  • Create New...