Jump to content
SAU Community

Recommended Posts

hi guys just wondering if anyones done it? apparently if you grind with masking tape around the edges you wont stuff the paint?

anywhere to get the triangles?

cheers

The duct is NACA duct

http://en.m.wikipedia.org/wiki/NACA_duct#mw-mf-search

I made one out of my factory steel bonnet on my old rx7 , simple to do

Make a template out of Mylar sticker film on a4 sheet print out make a few copies and confirm same dimensions

Cut one out very carefully

Stick on bonnet in location desired

Check 4 times for location

Trace arc on bonnet with exacto knife you need to cut all the way thru top layer of paint!! Except the front line on nose of the car ( if your quesy don't use knife yet use marker) try and fit between braces if possible

Check 4 times for aligned and underside issues

tape the arc edge just as close as you can to cut line a little water colour paint rubbed on a soft rag if you can't see the cut line

Once the tape is perfect , tape clean rags or towels around the bonnet and vent area the dust will fly everywhere and it's abrasive

A old blanket on the engine bay that is slightly damp to stop fires from sparks and abrasive cut off wheel dust

get Dremmel or similar with fibreglass cut off wheels ( a multitool would work too - vibrating deal but you better be accurate with it!)

Your going to cut all the lines except the front nose line !! cut with Dremel slowly using extreme care

Once cut it should flap loose but be attached on the nose part , carefully untape the flap

get a hair dryer or low heat gun

Warm the paint to about 45c on the flap

carefully and slowly bend the flap down into engine bay with fingers about 30mm

( could be sharp edges)

Now open the bonnet and warm the flap again

It should be kinda a shallow right angle not folded

now bend it with fingers from the bottom of the arc back towards the bonnet in back

The arc should now look like the NACA duct only no sides

trace the contour on some carbon fiber or glass 1 layer thick it should overhang by 5mm or so on each side

now take the bonnet off

flip over on something soft where you can work on it with epoxy stink

the two side strips will be epoxy built up a layer or two more once taped on in shape ( take into account drips etc and they can't be removed on paintwork !! )

once dry the tape can come off

the edge needs pie cut for curves and then tiger seal bonded on with care , dry a day

now cover underside with another layer of carbon or glass to hide merge of steel and carbon

Trim back of duct opening in your fav mesh to stop muppets dropping crap in your engine

the top should be damn near perfect paint wise , just a little touch up on edges and a buff out to shine back up and blend in the touch up

done

Looks perfect !! works awesome

Had mine 11yrs and it never broke loose or cracked the paint

wish I had documented it in photos dooh!!

So the finished product is steel bottom carbon or glass sides , glass sides will need black or your fav paint

I should make some out of carbon that just need cutout and bond lol

Blue painters tape

Dremel

Cut off wheels a few

Marker

Old blanket

Towels ( they can be washed and used again lol just don't let the wife catch you haha)

carbon weave of choice or glass

Paint of needed or black matte

mesh

exacto knife or luffa knife a good one you can push on without it falling to bits

epoxy

Tiger seal

Something to set bonnet on

A friend to help pull it off !!

a bucket load of faith and time don't rush !!

it's simple but must use care and measure 4 times and step back and look at it before cutting

If you cut braces you could be defected !!

When yanking tape off pull towards cut not away or it could rip paint off !!

if you need help with arc let me know

Mine was 30mm wide in front , about 150mm open wide

About 30mm tall opening

A flexible arc tool helps ( from drafting store or stationary shop) draw one side then fold paper to match exact arc on other side

Edited by Carbon 34

Can be done, ask terry, he did it to his black one.

Not sure if you can get away without painting.

I was weighing it up but waited for a genuine vsii one to pop up instead, and I got very lucky.

Anthony has a good memory :)

R34GTR194.jpg

It cost $45 + GST + Delivery > $62 from kenloweracing.com.au > air scoops > 3" NACA Duct

R34GTR204.jpg

It fits under the hole that's been cut into the bonnet > stuck there with epoxy so that paint won't crack due to expansion/contraction via heat/cold.

Hiya,

I just made sure the duct was positioned in the same position as on the V-Spec II & didn't worry about it until - that's right - someone asked the same Q as you.

Then I cut a neat fitting piece of Perspex to fit the slot on wet days - but I hardly ever had to use it.

Terry how does it go with water ingestion?

i assume it'll throw water onto the rear turbo?

Mine was in for 11 years in a snow zone and water was never issue , at speed the heat is so great and air flow speed so high into the inlet it vaporises even in down pours

and mine didn't run any mesh either

even parked the angle didn't allow much in

Terry think your way is a tiny bit easier haha

You can buy vents to drop in with carbon lip showing ( mostly r35 style) but look on USA sites

Create an account or sign in to comment

You need to be a member in order to leave a comment

Create an account

Sign up for a new account in our community. It's easy!

Register a new account

Sign in

Already have an account? Sign in here.

Sign In Now


  • Similar Content

  • Latest Posts

    • Yeah, it's getting like that, my daughter is coming over on Thursday to help me remove the bonnet so I can install the Carbuilders underbonnet stuff,  I might get her to give me a hand and remove the hardtop, maybe, because on really hot days the detachable hardtop helps the aircon keep the interior cool, the heat just punches straight through to rag top I also don't have enough hair for the "wind in the hair" experience, so there is that....LOL
    • Could be falling edge/rising edge is set wrong. Are you getting sync errors?
    • On BMWs what I do because I'm more confident that I can't instantly crush the pinch welds and do thousands of USD in chassis damage is use a set of rubber jacking pads designed to protect the chassis/plastic adapter and raise a corner of the car, place the aforementioned 2x12 inch wooden planks under a tire, drop the car, then this normally gives me enough clearance to get to the front central jack point. If you don't need it to be a ramp it only needs to be 1-1.5 feet long. On my R33 I do not trust the pinch welds to tolerate any of this so I drive up on the ramps. Before then when I had to get a new floor jack that no longer cleared the front lip I removed it to get enough clearance to put the jack under it. Once you're on the ramps once you simply never let the car down to the ground. It lives on the ramps or on jack stands.
    • Nah. You need 2x taps for anything that you cannot pass the tap all the way through. And even then, there's a point in response to the above which I will come back to. The 2x taps are 1x tapered for starting, and 1x plug tap for working to the bottom of blind holes. That block's port is effectively a blind hole from the perspective of the tap. The tapered tap/tapered thread response. You don't ever leave a female hole tapered. They are supposed to be parallel, hence the wide section of a tapered tap being parallel, the existince of plug taps, etc. The male is tapered so that it will eventually get too fat for the female thread, and yes, there is some risk if the tapped length of the female hole doesn't offer enough threads, that it will not lock up very nicely. But you can always buzz off the extra length on the male thread, and the tape is very good at adding bulk to the joint.
    • Nice....looking forward to that update
×
×
  • Create New...