Jump to content
SAU Community

Recommended Posts

Hi

My R33 has developed an odd idle issue when you back off acceleration.

The car has an auto box. You can be driving along and take your food off the gas to slow down for a set of lights and the Revs will occasionally drop as low as 500rpm and then bounce back to normal; this does not happen every time though.

I have had two occasions when the engine stopped, however it starts and idles perfectly and drives without issue.

I've cleaned the AFM, new air cleaner, new plugs. Any advices?

Thanks

Denis

Link to comment
https://www.sau.com.au/forums/topic/452860-r33-idle-issues/
Share on other sites

Atmo BOV? - Get rid of it

Factory ECU? - After cleaning AAC valve, try resetting the ECU (disconnect battery, operate lights etc, to drain residual power, re-connect battery, start car)

It has been covered qutie a few times before.

Link to comment
https://www.sau.com.au/forums/topic/452860-r33-idle-issues/#findComment-7463815
Share on other sites

The engine was fully rebuilt with forged piston, greddy intake manifold, larger injectors, hi flowed turbo, turbosmart blowoff valve, bigger intercooler, Z32 AFM (cleaned regularly) etc etc. The engine has only done 12,000kms in 4 years. There are no mud issues in the AAC or any of the usual issues that are eluded to the great how sections.

Idle is perfect with no fluctuations while sitting. It's only occasionally when you take you foot off the gas to slow for lights etc that the idle drops to 500rpm or lower and then rights itself. This has only occurred in the last few weeks.

I was swaying towards the Turbosmart blowoff valve, but all checked and cleaned and appears OK

Would a TPS cause this? I thought it unlikely.

Sorry if I was somewhat grumpy; you get that way when you're over 60.

Link to comment
https://www.sau.com.au/forums/topic/452860-r33-idle-issues/#findComment-7463852
Share on other sites

I dont have any experience with Autos but I had issues when I went from atmo BOV back to stock. Cleaned AAC and all that and it didnt help. Reset the ECU and it returned to idle fine

But im not sure if you are running stock ECU

The TPS on auto has a digital and analog input to the ECU. The on off part is important on Autos if I recall correctly ( the analog voltage signal is important to both auto and manual) the digital input is easy to check with a meter, run a continuity check accross the 2 pin plug with throttle closed and then open the throttle. It should go from closed circuit to open (or vice versa, been a while since I checked)

The other analog sensor is best checked with consult or the correct software for your ECU. Should be 0.45V

Link to comment
https://www.sau.com.au/forums/topic/452860-r33-idle-issues/#findComment-7463875
Share on other sites

Hey Dennis, try turning your idle air screw counter clockwise till the engine starts to rev higher. Then turn it clockwise one full turn. Sometimes people fool around with this screw and it can cause major idle issues as you have described. Another possible fix could be to lean off the fuel under 800rpm but this depends on the tune in that area so may not help. I am always concerned about changes to the blow off valve as this usually always causes issues. Make sure it is plumbed back.

Link to comment
https://www.sau.com.au/forums/topic/452860-r33-idle-issues/#findComment-7464343
Share on other sites

RB25's tend to want to run a bit rich at idle. I think as rich as 13.2:1 I've seen to give a nice smooth idle.

Off the top of my head I used to run 13.6:1 when I had the Power FC in mine.

Agree about the idle screw, was thinking that the other day. If its wound all the way in the solenoid/valve might be able to compensate just enough to idle, but when its going from higher revs to idle, it can't adjust quick enough or far enough to give a smooth idle.

Link to comment
https://www.sau.com.au/forums/topic/452860-r33-idle-issues/#findComment-7464663
Share on other sites

Well after checking all possibilities I turned to the Turbosmart BOV. After winding it back to the softest setting I discovered no more idle issues.

Why?? You tell me.

Easy the stock.ecu likes having the stock bov, a aftermarket bov on softer settings are more like the factory bov

Link to comment
https://www.sau.com.au/forums/topic/452860-r33-idle-issues/#findComment-7467261
Share on other sites

Create an account or sign in to comment

You need to be a member in order to leave a comment

Create an account

Sign up for a new account in our community. It's easy!

Register a new account

Sign in

Already have an account? Sign in here.

Sign In Now


  • Similar Content

  • Latest Posts

    • Thanks for all the replies fellas. Gonna finish putting it back together and see how it handles the set up. If it starts pinging it’ll be parked.
    • Well, I can recommend the partial AV system translation CD I ordered from Car Audio Workshop in NZ. Whilst it didn't address the date issue, it has conveniently translated on-screen menu items into English, and now allows the GPS-received time to be offset in hours rather than minutes, so I can display Eastern Australian time accurately ( and bump it by another hour when daylight savings starts ).
    • Yuh, if it's 45°C outside, my car is driving in it.
    • I'd be curious to hear more. Otherwise, have you driven a modern x-trail? I wonder how it compares. Here in Australia they are/were popular for rentals and fleet vehicles. I have been in some and my impression was they are bad. But, this may have been very different in the 2000s at a good trim level. Twenty years is plenty of time to make the model worse. I do very much agree with the 2 silver cars in the garage approach. But, not driving because it's too hot would not leave a lot of time in the year for many Australians. I don't think you need to worry too much unless the car has actual issues with overheating. 
    • Back again. I returned to Japan in Jul/Aug to spend time with the car on my birthday and remind myself what all the sacrifice and compromise is for. It happened to line up with the monthly morning meet in Okutama, which I have been wanting to go to for a long time. It's a unique event at a unique spot with really rare, interesting, and quirky cars. It's where all the oldheads and OGs gather. The nighttime scene at DKF certainly has its place and should be experienced if you're into cars, but there's too much bad attention and negativity around it now. IMO the better time is Sunday morning at DKF or Okutama; it's more chill and relaxed. I'm glad I was finally able to go, but not sure it's worth the drive from all the way from Nagoya immediately the day before, unless I was already staying in Tokyo for the days right before the meet, because you have to wake up quite early to make it in time. Funnily enough though I didn't drive the car all that much this trip because it was just too damn hot. While there were zero issues and running temps were nominal and the A/C was strong, RBs already run crazy hot as it is. Sure, it took it all like a champ but something about driving these cars in the ridiculous heat/humidity bothers me and makes me feel like I'm asking too much of it. I'm just me being weird and treating the car like a living thing with feelings; I'm mechanically sympathetic to a fault. Instead I was mainly driving something else around - a KX4(silver) 2001 X-Trail GT, that I acquired in May. There's a few different flavors to choose from with Xs, but visually it's the Nissan version of the Honda CR-V. Mechanically it's a whole different story as this, being the top-trim GT, has an SR20VET mated to a four-speed auto and full-time AWD! It was a very affordable buy in exceptional condition inside and out, with very low mileage...only 48k kms. Most likely it was owned by an older person who kept it garaged and well-maintained, so I'm really happy with how it all worked out. It literally needs zero attention at the moment, albeit except for some minor visual touch-ups. I wanted something quirky, interesting, and practical and for sure it handily delivers on all three of those aspects. I was immediately able to utilize the cargo and passenger capacity to its full extent. It's a lot of fun to drive and is quite punchy through 1st and 2nd. It's very unassuming -in the twisty bits it's a lot more composed than one would think at a glance- and it'll be even better once I get better tires on it(yes, it's an SUV but still a little boat-y for my liking). So...now I have two golden-era Nissans in silver. One sports car and one that does everything else; the perfect two-car solution I think👍 The rest of the trip...I was able to turn my stressed brain off and enjoy it, although I didn't quite get to do as much as I thought. I did some interesting things, met some interesting people, and happened into some interesting situations however, that's all for another post though only if people really want to know. Project-wise, I went back to Mine's again to discuss more plans and am hoping to wrap that up real soon; keep watching this space if that interests you. Additionally, while working in the tormenting sweatbox that is the warehouse, I was able to organize most of the myriad of parts that my friend is storing for me along with the cars, and the 34 has a nice little spot carved out for it: And since it can get so stupid hot in there, that made it all the more easy -after I was standing there looking at the car and said 'f**k it'- to finally remove all the damn gauges that have mostly been an eyesore all this time. Huzzah. The heat basically makes the adhesive backing on the gauge mounts more pliable to work with, so it was far less stressful getting this done. I didn't fully clean it up or chase the wiring though; that will happen once I have the car in closer possession. Another major reason to remove all that stuff is to give people less reasons to get in my car and steal s**t while it's being exported/imported when/if the time comes, which leads us to my next point... ...and that is even though it's time in Japan is technically almost up since it's a November car and the X would be coming in March, I'm still not entirely sure where my life and career is headed; I don't really know what the future looks like and where I'm going to end up. I feel there's a great deal of uncertainty with me and as a result of that, it feels like I'm at a crossroads moreso now than any point in my life thus far and there are some choices I need to make. Yes, I've had some years to consider things and prepare myself, however too much has happened in that time to maintain confidence and everything feels so up in the air; tenuous one might say. Simply put, there's just too much nonsense going on right now from multiple vectors. Admittedly, I'm struggling to stay in the game and keep my eyes on the prize. So much so in fact, that very recently I came the closest I ever have before to calling it quits outright; selling everything and moving on and not looking back. The astute among you will pick up on key subtext within this paragraph. In the meantime I've still managed to slowly acquire some final bits for the car, but it feels nice knowing there's not much left to get and I'm almost across that finish line; I have almost everything I'll ever want for my interpretation and expression on what it is I think an R34 should be. 'til later.
×
×
  • Create New...