Jump to content
SAU Community

Recommended Posts

Hi guys,

a couple of days ago after a hard drive back from the airport my R32 started idling funny. When warm it started bouncing from idle (800 rpm) to 2000 rpm. I've been driving the car for a couple of days now, and it's quite embarassing. When I'm at the lights people think I'm trying to run them!

I have searched the forums long and hard, and have cleaned my AAC Valve to no avail. I now believe it is the air regulator. Problem is I don't know were this is. I read that it was underneath the intake plenum. If someone could take a pic that would be great. Also if anyone knows if this part is servicable, or will I need to replace it?

If anyone esle has had the same problem I would love to hear their input.

Link to comment
https://www.sau.com.au/forums/topic/45774-r32-gts-t-fluctuating-idle/
Share on other sites

I've had a really bad fluctuating idle that also had a slight miss.

I cleaned the AAC valve and the idle fluctuation was ALMOST gone.

2 years later I put the mesh back on to the AFM and all idle problems are gone.

Its now got a 100% perfect smooth idle.

I have heard of o2 sensors also causing an issue.

My actions would be.

Clean AAC valve

Check if your afm has mesh on both the front and rear. If not slap it on.

If idle problems are still around either get your injectors cleaned/checked out or replace the o2 sensor.

after a really hard run, e.g. running 70 laps on a circuit over a whole trackday, the hydraulic lifters sometimes get a bit stuffed, which would also cause the funny idle. will usually go back to normal after a few days, or after a service. my own experience.. :D

after a really hard run, e.g. running 70 laps on a circuit over a whole trackday, the hydraulic lifters sometimes get a bit stuffed, which would also cause the funny idle.  will usually go back to normal after a few days, or after a service.  my own experience.. :D

70 laps would see the complete breakdown of your engine oil, almost to a water like state, hence the problem with the lifters. Do you have a oil cooler? What sort of oil do you run?

In regards to idle problem, AAC valve is usually the culprit

Ok guys,

Nissan called this mourning and after 2 days of tying to figure it out there still unsure. They said that because it's an import there diagnostic machine can't read

all the codes?! Thay reffered me to another workshop. On top of this they tried to

charge me for there time. I refused to pay as I don't think they did anything.

Hopefully I have better luck with the next place.

chris32 - heheh i don't run 70 laps all in one go... 10-15 laps at a time, 5-7 sessions a trackday. Using Valvoline fully syn, car has run extremely reliably for over a year of about 15 trackdays inc 2 at Eastern Creek with very low knock readings (std 11 yr old engine with HKS 2530). Running a BEL Garage 19 row oil cooler and 3-core radiator.

chris32 - heheh i don't run 70 laps all in one go... 10-15 laps at a time, 5-7 sessions a trackday.  Using Valvoline fully syn, car has run extremely reliably for over a year of about 15 trackdays inc 2 at Eastern Creek with very low knock readings (std 11 yr old engine with HKS 2530).  Running a BEL Garage 19 row oil cooler and 3-core radiator.

cool, sounds like a good setup you have there. I run a decent oil cooler myself, and a similar turbo to yours. Only have done one trackday of about 25 laps, but it kept it nice and cool

Chris

why keep on guessing by replacing this and replacing that???? You need to systimatically go through all the vacuum piping to and from the AAC valve & idle control solenoid and clamp them off with a brake line clamp and see if this changes the fast idle. Simple. If the idle does not change then its something else like a inlet manifold gasket blown out (very common in older skylines).

This can be confirmed with the ol can of break disc cleaner in an aerosol can. Give it a squirt alone the inlet manifold right against the cylinder head and if the gasket is gone, broken, blown out, it will get sucked in and the idle will stumble as it burns the break cleaner fluid.

Give that a go.

Changing the O2 sensor just for the sake of it could well be a waste of your money, besides, even if it is stuffed that won't make your idle jump up & down like that.

MIke

Create an account or sign in to comment

You need to be a member in order to leave a comment

Create an account

Sign up for a new account in our community. It's easy!

Register a new account

Sign in

Already have an account? Sign in here.

Sign In Now


  • Similar Content

  • Latest Posts

    • Thanks for all the replies fellas. Gonna finish putting it back together and see how it handles the set up. If it starts pinging it’ll be parked.
    • Well, I can recommend the partial AV system translation CD I ordered from Car Audio Workshop in NZ. Whilst it didn't address the date issue, it has conveniently translated on-screen menu items into English, and now allows the GPS-received time to be offset in hours rather than minutes, so I can display Eastern Australian time accurately ( and bump it by another hour when daylight savings starts ).
    • Yuh, if it's 45°C outside, my car is driving in it.
    • I'd be curious to hear more. Otherwise, have you driven a modern x-trail? I wonder how it compares. Here in Australia they are/were popular for rentals and fleet vehicles. I have been in some and my impression was they are bad. But, this may have been very different in the 2000s at a good trim level. Twenty years is plenty of time to make the model worse. I do very much agree with the 2 silver cars in the garage approach. But, not driving because it's too hot would not leave a lot of time in the year for many Australians. I don't think you need to worry too much unless the car has actual issues with overheating. 
    • Back again. I returned to Japan in Jul/Aug to spend time with the car on my birthday and remind myself what all the sacrifice and compromise is for. It happened to line up with the monthly morning meet in Okutama, which I have been wanting to go to for a long time. It's a unique event at a unique spot with really rare, interesting, and quirky cars. It's where all the oldheads and OGs gather. The nighttime scene at DKF certainly has its place and should be experienced if you're into cars, but there's too much bad attention and negativity around it now. IMO the better time is Sunday morning at DKF or Okutama; it's more chill and relaxed. I'm glad I was finally able to go, but not sure it's worth the drive from all the way from Nagoya immediately the day before, unless I was already staying in Tokyo for the days right before the meet, because you have to wake up quite early to make it in time. Funnily enough though I didn't drive the car all that much this trip because it was just too damn hot. While there were zero issues and running temps were nominal and the A/C was strong, RBs already run crazy hot as it is. Sure, it took it all like a champ but something about driving these cars in the ridiculous heat/humidity bothers me and makes me feel like I'm asking too much of it. I'm just me being weird and treating the car like a living thing with feelings; I'm mechanically sympathetic to a fault. Instead I was mainly driving something else around - a KX4(silver) 2001 X-Trail GT, that I acquired in May. There's a few different flavors to choose from with Xs, but visually it's the Nissan version of the Honda CR-V. Mechanically it's a whole different story as this, being the top-trim GT, has an SR20VET mated to a four-speed auto and full-time AWD! It was a very affordable buy in exceptional condition inside and out, with very low mileage...only 48k kms. Most likely it was owned by an older person who kept it garaged and well-maintained, so I'm really happy with how it all worked out. It literally needs zero attention at the moment, albeit except for some minor visual touch-ups. I wanted something quirky, interesting, and practical and for sure it handily delivers on all three of those aspects. I was immediately able to utilize the cargo and passenger capacity to its full extent. It's a lot of fun to drive and is quite punchy through 1st and 2nd. It's very unassuming -in the twisty bits it's a lot more composed than one would think at a glance- and it'll be even better once I get better tires on it(yes, it's an SUV but still a little boat-y for my liking). So...now I have two golden-era Nissans in silver. One sports car and one that does everything else; the perfect two-car solution I think👍 The rest of the trip...I was able to turn my stressed brain off and enjoy it, although I didn't quite get to do as much as I thought. I did some interesting things, met some interesting people, and happened into some interesting situations however, that's all for another post though only if people really want to know. Project-wise, I went back to Mine's again to discuss more plans and am hoping to wrap that up real soon; keep watching this space if that interests you. Additionally, while working in the tormenting sweatbox that is the warehouse, I was able to organize most of the myriad of parts that my friend is storing for me along with the cars, and the 34 has a nice little spot carved out for it: And since it can get so stupid hot in there, that made it all the more easy -after I was standing there looking at the car and said 'f**k it'- to finally remove all the damn gauges that have mostly been an eyesore all this time. Huzzah. The heat basically makes the adhesive backing on the gauge mounts more pliable to work with, so it was far less stressful getting this done. I didn't fully clean it up or chase the wiring though; that will happen once I have the car in closer possession. Another major reason to remove all that stuff is to give people less reasons to get in my car and steal s**t while it's being exported/imported when/if the time comes, which leads us to my next point... ...and that is even though it's time in Japan is technically almost up since it's a November car and the X would be coming in March, I'm still not entirely sure where my life and career is headed; I don't really know what the future looks like and where I'm going to end up. I feel there's a great deal of uncertainty with me and as a result of that, it feels like I'm at a crossroads moreso now than any point in my life thus far and there are some choices I need to make. Yes, I've had some years to consider things and prepare myself, however too much has happened in that time to maintain confidence and everything feels so up in the air; tenuous one might say. Simply put, there's just too much nonsense going on right now from multiple vectors. Admittedly, I'm struggling to stay in the game and keep my eyes on the prize. So much so in fact, that very recently I came the closest I ever have before to calling it quits outright; selling everything and moving on and not looking back. The astute among you will pick up on key subtext within this paragraph. In the meantime I've still managed to slowly acquire some final bits for the car, but it feels nice knowing there's not much left to get and I'm almost across that finish line; I have almost everything I'll ever want for my interpretation and expression on what it is I think an R34 should be. 'til later.
×
×
  • Create New...