Jump to content
SAU Community

Recommended Posts

  • Replies 144
  • Created
  • Last Reply

Top Posters In This Topic

Steve

Great find re the link to the autospeed article.

It's funny b/c i had this conversation with Simon back in 1998 when i use to take my VLt in and i agreed with his reasoning back then. Good to see 4 years later (when the article was written) has hasn't changed his opinion.

I'm no pro regarding turbos, and I'm not going to pretend to be (but i know a bit about pumps, turbines and PRV's, which i'll go into shortly). Nissan enginneers put a BOV there for a reason, and with a plastic inlet spool, I'm not going to argue the point too much. My BOV stays. I do worry about the leaking-overspeed thing tho, which it does atm, so i'm buying an aftermarket jobbie. The beauty of actually having a BOV is you can mimic having no BOV if you want, just wind the bastard right up. for me tho, I have to agree with sydneykids' line, and can see how you need to "tune" your bov for best performance.

To clarify, the "turbine" section of a turbo is actually on the exhaust side, it is an impulse turbine, to be precise. The induction side is indeed a pump, and is definately not a turbine,. If it was a turbine, then you'd be able to call any old centrifugal pump a turbine. Although people do still like to call it one, it is not, by definition, a turbine, just attached to one.

So in the case of a turbo, as with any pump, it will pump up to it's maximum pressure/flow, and then it will dead head/cavitate. So this is fine if you cannot reach the top of this pumps' efficiency curve, ie you cannot reach it's max pressure/flow. however, running no BOV you will very quickly reach this point, at which stage, if the pump still had power, it would increase RPM. HOWEVER, as this is a unique pump, in that at the same time you are dead heading it, you are also removing it's power source, it will not increase in rpm, it will simply slow down , and possibly stall and reverse, as it increases pressure in the run to the throttle butterfly, using nothing but the momentum of it's revolution.

No Bov

It is understandable, how no BOV can increase power. If you manage to change gears quickly enough that your turbine has not stalled, you will have increased pressure after the turbo by a substantial amount, at which point you re-open the throttle, and you get a handy rush of 15+psi into the plenum, and hopefully the turbo hasn't slowed down too much to say, 40000 rpm, using the example Sydney Kid provided before, and is able to speed back up quickly and provide boost. But given how quickly it spools up, I'd imagine it would slow down fairly quickly too, so you'd have to be pretty swift in the throttle all the times to not stall the turbo, which is why BOVs probably aren't used so much in racing. Which would tend to point to the fact that if you're car is not a racer, you might be doing a bit of harm to your turbo by NOT driving your car at full noise all the time and dong snap changes.

Race cars, PRV's

In regards to race cars, most of them run pneumatic boxes nowadays, so the need for a BOV is even less, basically, the only time it would possibly be needed is when they are slowing down for a corner. Indy cars still run pop off valves, which I believe are set slightly higher than their on throttle boost pressure, and so act like a "style" of BOV, in that they release excess pressure (why would they want to do that, i wonder?). Another name for a pop off valve is a pressure relief valve, which actuate at one pressure, and reseat at a lower pressure, by way of two diameters that the passing air acts upon. once the PRV is open, the air acts on a greater surface area, allowing it to reaseat at a lower pressure than it actuated at.

Leaky Bov

It's piss easy to understand how this can stuff things up. one, the overspeed issue mentioned before, and two, also mentioned, you lose all your boost pressure as soon as the bov opens. As my understanding of bovs goes, I dont think that either of these scenarios was what BOV's were designed to do, it's just what we're used to them doing.

Best of Both worlds

If you tune your bov to act like a PRV, voila! you have the perfect system. And the beauty of a BOV over a PRV, is that is is alot more tuneable than a PRV, so you can effectively fine tune the pressure at which it actuates, and the pressure at which it reseats, so as to maintain pressure, and at the same time, keep the turbine spooling. All in all MUCH more controllable than running no bov at all, and you dont run the risk of over pressuring your turbo. And the other advantage it has over a pop off valve is that it is vacuum actuated, so at times when you aren't running at full noise, it will open enough so that your turbo doesn't stall or reverse.

So all in all, If your BOV is leaky or worn out, that is bad. If you race, or drive hard ALL the time (ie not really anything you can do legally on the street), and never just stab it and drop off again (to get that "pigeon" sound, non BOV people! and you say the BOV sound is a load of wank!), you can probably run without a BOV. If you drive your car daily, and dont want to stress too much about doing bad things to your turbo, then a correctly set up BOV is the way to go.

I'd better mention that all that is only IMHO! purely based on what I know about the individual components making up the system, and not necessarily the parts themselves. I dont race, I dont tune. But I do know that if my turbo goes bang cause of a mod I made based on what Mr/Mrs X said, they aint gonna be there to pick up the pieces!

I also notice on that le-mans car, the incredibly short run from turbo to butterfly... ie not much stored energy to try and push itself back past the impeller when(if) the turbo comes to a stop... Not nearly as much as something running an intercooler, complete with runs to and from...

The autospeed article is a very good explanation and could be a very good argument against BOV's, and it is if you're racing, and you can keep the "skidding" noise going for the duration of the gear change, which would be pretty easy. You could even say that the skidding noise is a good thing! But I was thinking, what does it mean when the "skidding" noise stops? and there is 50+PSI infront of it, atmo or vacuum pressure behind it, and no exhaust gases powering it? hmmm. HMMmmmmmmm.....

  • 4 weeks later...

just thought i would ad to the discussion.....

I currently have a supersonic bov on 3" i/c pipes and when the car was running 12 psi it worked fine now the car is running 19 psi i get a loud flutter before the psht noise when i change gears and the car pauses for a second so i am fitting a second bov to solve the problem.

Now that should prove that bov are definently needed.

Steve can you tell me how to fix my problem then as you have helped before with useful info i can always just sell the second bov if there is another way.The sound doesnt bother me i just want to get rid of the deadspot on gearchanges.

And you other tools should stop feeding so much sausage to thorpie,and not attack people for no reason behind the safety of your computer screen.

I am not a mechanic so any help would be appreciated.

Thanks.

heheh Thorpy would think 294rwkw is fully sick.. :rolleyes:

http://www.fueltech.com.au/auto_turboaccessories.html

It states Highflow version available upon request.

i get a loud flutter before the psht noise when i change gears

Where is the bov located? Near the throttle body as the stock setup?

Maybe its adjusted incorrectly.

czy18e, your post was pretty funny :rolleyes: so many factors that need controlling (and examining)to ensure they dont change, before something can be considered proof :D

Did you change anything when you would up the boost?

Have you tried adjusting the BOV, ie, wind it fully shut, as tight as it will go?

Did the same guy tune it for the higher boost as did it at lower boost?

There are alot of different things, but by the sounds, you have throttle lag (ie, it takes a while from when the throttle is opened to when you are making power) - it could be the fact that you are using a bov that is causing the problems (as I found when I started making over 300rwkw) or it could be a poor tune, if you have changed anything else (eg cams) you could be falling off boost (power band is narrower).

First thing I would be looking at is blocking off, or winding shut the bov as much as possible AND checking its not lifting under boost (as cubes is pointing to)

The reason I say this, is when under full boost, with no bov, and lifting off the throttle, you will get a high pitched squeal, not a flutter sound, the flutter comes later (about 1/2 to 3/4 of a second later) once the majority of the compressed air has reverted past the turbo. On quick changes you cant even here the flutter, just a very quick squeel.

Faults like the one you have can be alot easier to trace when on a dyno though, but definately start by looking at adjustment of the BOV

good luck, let us know how you go.

czy18e, your post was pretty funny :) so many factors that need controlling (and examining)to ensure they dont change, before something can be considered proof :)

Did you change anything when you would up the boost? 

Have you tried adjusting the BOV, ie, wind it fully shut, as tight as it will go? 

Did the same guy tune it for the higher boost as did it at lower boost?

There are alot of different things, but by the sounds, you have throttle lag (ie, it takes a while from when the throttle is opened to when you are making power) - it could be the fact that you are using a bov that is causing the problems (as I found when I started making over 300rwkw) or it could be a poor tune, if you have changed anything else (eg cams) you could be falling off boost (power band is narrower).

First thing I would be looking at is blocking off, or winding shut the bov as much as possible AND checking its not lifting under boost (as cubes is pointing to)

The reason I say this, is when under full boost, with no bov, and lifting off the throttle, you will get a high pitched squeal, not a flutter sound, the flutter comes later (about 1/2 to 3/4 of a second later) once the majority of the compressed air has reverted past the turbo.  On quick changes you cant even here the flutter, just a very quick squeel.

Faults like the one you have can be alot easier to trace when on a dyno though, but definately start by looking at adjustment of the BOV

good luck, let us know how you go.

Thanks steve i will try blocking the bov tomorrow and let you know.

The only other things i changed when turning up the boost was fuel pump and injectors.

The same guy tuned it but we didnt do a road tune and so i didnt find out about the throttle lag until i got out of the city(as it only does it on gear changes on high boost)

the cams are stock.

I am going on the dyno again on the 17th and want to have this sorted by then if i can.

And so when i have the bov jammed shut ie.no bov, it wont hurt my turbo ??

Thanks ill post tomorrow with results but if it doesnt fix it ill have to wait for the dyno.

cheers.

I recently fitted an aftermarket BOV which is yet to be plumbed back. Prior to this my OEM s15 re-circ valve used to flutter when I was on full noise.

My aftermarket bov - anything under 0.5 bar I hear flutter. Anything 0.6-0.7 bar it will blow off.

My question is - what is "correctly" setup. Should I set it up so the BOV vents lower than 0.5 bar?

Steve can you tell me how to fix my problem then as you have helped before with useful info i can always just sell the second bov if there is another way.The sound doesnt bother me i just want to get rid of the deadspot on gearchanges.

And you other tools should stop feeding so much sausage to thorpie,and not attack people for no reason behind the safety of your computer screen.

I am not a mechanic so any help would be appreciated.

Thanks.

If you're having dead spots on gear changes do you have a plumback BOV or atmo? Mine was doing that when I had mine atmo because it would be getting too rich. Plumb it back and try then.

Otherwise it might be set too tight or you have no BOV. When my BOV was too tight (i.e. pretty much like not having any BOV) my car would stutter as the turbo shat itself, almost like a surging.

Create an account or sign in to comment

You need to be a member in order to leave a comment

Create an account

Sign up for a new account in our community. It's easy!

Register a new account

Sign in

Already have an account? Sign in here.

Sign In Now



  • Similar Content

  • Latest Posts

    • Any update on this one? did you manage to get it fixed?    i'm having the same issue with my r34 and i believe its to do with the smart entry (keyless) control module but cant be sure without forking out to get a replacement  
    • So this being my first contribution to the SAU forums, I'd like to present and show how I had to solve probably one of the most annoying fixes on any car I've owned: replacing a speedometer (or "speedo") sensor on my newly acquired Series 1 Stagea 260RS Autech Version. I'm simply documenting how I went about to fix this issue, and as I understand it is relatively rare to happen to this generation of cars, it is a gigantic PITA so I hope this helps serve as reference to anyone else who may encounter this issue. NOTE: Although I say this is meant for the 260RS, because the gearbox/drivetrain is shared with the R33 GTR with the 5-speed manual, the application should be exactly the same. Background So after driving my new-to-me Stagea for about 1500km, one night while driving home the speedometer and odometer suddenly stopped working. No clunking noise, no indication something was broken, the speedometer would just stop reading anything and the odometer stopped going up. This is a huge worry for me, because my car is relatively low mileage (only 45k km when purchased) so although I plan to own the car for a long time, a mismatched odometer reading would be hugely detrimental to resale should the day come to sell the car. Thankfully this only occurred a mile or two from home so it wasn't extremely significant. Also, the OCD part of me would be extremely irked if the numbers that showed on my dash doesn't match the actual ageing of the car. Diagnosing I had been in communication with the well renown GTR shop in the USA, U.P.garage up near University Point in Washington state. After some back and forth they said it could be one of two things: 1) The speedometer sensor that goes into the transfer case is broken 2) The actual cluster has a component that went kaput. They said this is common in older Nissan gauge clusters and that would indicate a rebuild is necessary. As I tried to figure out if it was problem #1, I resolved problem #2 by sending my cluster over to Relentless Motorsports in Dallas, TX, whom is local to me and does cluster and ECU rebuilds. He is a one man operation who meticulously replaces every chip, resistor, capacitor, and electronic component on the PCB's on a wide variety of classic and modern cars. His specialty is Lexus and Toyota, but he came highly recommended by Erik of U.P.garage since he does the rebuilds for them on GTR clusters.  For those that don't know, on R32 and R33 GTR gearboxes, the speedometer sensor is mounted in the transfer case and is purely an analog mini "generator" (opposite of an alternator essentially). Based on the speed the sensor spins it generates an AC sine wave voltage up to 5V, and sends that via two wires up to the cluster which then interprets it via the speedometer dial. The signal does NOT go to the ECU first, the wiring goes to the cluster first then the ECU after (or so I'm told).  Problems/Roadblocks I first removed the part from the car on the underside of the transfer case (drain your transfer case fluid/ATF first, guess who found out that the hard way?), and noted the transfer case fluid was EXTREMELY black, most likely never changed on my car. When attempting to turn the gears it felt extremely gritty, as if something was binding the shaft from rotating properly. I got absolutely no voltage reading out of the sensor no matter how fast I turned the shaft. After having to reflow the solder on my AFM sensors based on another SAU guide here, I attempted to disassemble the silicone seal on the back of the sensor to see what happened inside the sensor; turns out, it basically disintegrated itself. Wonderful. Not only had the electrical components destroyed themselves, the magnetic portion on what I thought was on the shaft also chipped and was broken. Solution So solution: find a spare part right? Wrong. Nissan has long discontinued the proper sensor part number 32702-21U19, and it is no longer obtainable either through Nissan NSA or Nissan Japan. I was SOL without proper speed or mileage readings unless I figured out a way to replace this sensor. After tons of Googling and searching on SAU, I found that there IS however a sensor that looks almost exactly like the R33/260RS one: a sensor meant for the R33/R34 GTT and GTS-T with the 5 speed manual. The part number was 25010-21U00, and the body, plug, and shaft all looked exactly the same. The gear was different at the end, but knowing the sensor's gear is held on with a circlip, I figured I could just order the part and swap the gears. Cue me ordering a new part from JustJap down in Kirrawee, NSW, then waiting almost 3 weeks for shipping and customs clearing. The part finally arrives and what did I find? The freaking shaft lengths don't match. $&%* I discussed with Erik how to proceed, and figuring that I basically destroyed the sensor trying to get the shaft out of the damaged sensor from my car. we deemed it too dangerous to try and attempt to swap shafts to the correct length. I had to find a local CNC machinist to help me cut and notch down the shaft. After tons of frantic calling on a Friday afternoon, I managed to get hold of someone and he said he'd be able to do it over half a week. I sent him photos and had him take measurements to match not only the correct length and notch fitment, but also a groove to machine out to hold the retentive circlip. And the end result? *chef's kiss* Perfect. Since I didn't have pliers with me when I picked up the items, I tested the old gear and circlip on. Perfect fit. After that it was simply swapping out the plug bracket to the new sensor, mount it on the transfer case, refill with ATF/Nissan Matic Fluid D, then test out function. Thankfully with the rebuilt cluster and the new sensor, both the speedometer and odometer and now working properly!   And there you have it. About 5-6 weeks of headaches wrapped up in a 15 minute photo essay. As I was told it is rare for sensors of this generation to die so dramatically, but you never know what could go wrong with a 25+ year old car. I HOPE that no one else has to go through this problem like I did, so with my take on a solution I hope it helps others who may encounter this issue in the future. For the TL;DR: 1) Sensor breaks. 2) Find a replacement GTT/GTS-T sensor. 3) Find a CNC machinist to have you cut it down to proper specs. 4) Reinstall then pray to the JDM gods.   Hope this guide/story helps anyone else encountering this problem!
    • So this being my first contribution to the SAU forums, I'd like to present and show how I had to solve probably one of the most annoying fixes on any car I've owned: replacing a speedometer (or "speedo") sensor on my newly acquired Series 1 Stagea 260RS Autech Version. I'm simply documenting how I went about to fix this issue, and as I understand it is relatively rare to happen to this generation of cars, it is a gigantic PITA so I hope this helps serve as reference to anyone else who may encounter this issue. NOTE: Although I say this is meant for the 260RS, because the gearbox/drivetrain is shared with the R33 GTR with the 5-speed manual, the application should be exactly the same. Background So after driving my new-to-me Stagea for about 1500km, one night while driving home the speedometer and odometer suddenly stopped working. No clunking noise, no indication something was broken, the speedometer would just stop reading anything and the odometer stopped going up. This is a huge worry for me, because my car is relatively low mileage (only 45k km when purchased) so although I plan to own the car for a long time, a mismatched odometer reading would be hugely detrimental to resale should the day come to sell the car. Thankfully this only occurred a mile or two from home so it wasn't extremely significant. Also, the OCD part of me would be extremely irked if the numbers that showed on my dash doesn't match the actual ageing of the car. Diagnosing I had been in communication with the well renown GTR shop in the USA, U.P.garage up near University Point in Washington state. After some back and forth they said it could be one of two things: 1) The speedometer sensor that goes into the transfer case is broken 2) The actual cluster has a component that went kaput. They said this is common in older Nissan gauge clusters and that would indicate a rebuild is necessary. As I tried to figure out if it was problem #1, I resolved problem #2 by sending my cluster over to Relentless Motorsports in Dallas, TX, whom is local to me and does cluster and ECU rebuilds. He is a one man operation who meticulously replaces every chip, resistor, capacitor, and electronic component on the PCB's on a wide variety of classic and modern cars. His specialty is Lexus and Toyota, but he came highly recommended by Erik of U.P.garage since he does the rebuilds for them on GTR clusters.  For those that don't know, on R32 and R33 GTR gearboxes, the speedometer sensor is mounted in the transfer case and is purely an analog mini "generator" (opposite of an alternator essentially). Based on the speed the sensor spins it generates an AC sine wave voltage up to 5V, and sends that via two wires up to the cluster which then interprets it via the speedometer dial. The signal does NOT go to the ECU first, the wiring goes to the cluster first then the ECU after (or so I'm told).  Problems/Roadblocks I first removed the part from the car on the underside of the transfer case (drain your transfer case fluid/ATF first, guess who found out that the hard way?), and noted the transfer case fluid was EXTREMELY black, most likely never changed on my car. When attempting to turn the gears it felt extremely gritty, as if shttps://imgur.com/6TQCG3xomething was binding the shaft from rotating properly. After having to reflow the solder on my AFM sensors based on another SAU guide here, I attempted to disassemble the silicone seal on the back of the sensor to see what happened inside the sensor; turns out, it basically disintegrated itself. Wonderful. Not only had the electrical components destroyed themselves, the magnetic portion on what I thought was on the shaft also chipped and was broken. Solution So solution: find a spare part right? Wrong. Nissan has long discontinued the proper sensor part number 32702-21U19, and it is no longer obtainable either through Nissan NSA or Nissan Japan. I was SOL without proper speed or mileage readings unless I figured out a way to replace this sensor. After tons of Googling and searching on SAU, I found that there IS however a sensor that looks almost exactly like the R33/260RS one: a sensor meant for the R33/R34 GTT and GTS-T with the 5 speed manual. The part number was 25010-21U00, and the body, plug, and shaft all looked exactly the same. The gear was different at the end, but knowing the sensor's gear is held on with a circlip, I figured I could just order the part and swap the gears. Cue me ordering a new part from JustJap down in Kirrawee, NSW, then waiting almost 3 weeks for shipping and customs clearing. The part finally arrives and what did I find? The freaking shaft lengths don't match. $&%* I discussed with Erik how to proceed, and figuring that I basically destroyed the sensor trying to get the shaft out of the damaged sensor from my car. we deemed it too dangerous to try and attempt to swap shafts to the correct length. I had to find a local CNC machinist to help me cut and notch down the shaft. After tons of frantic calling on a Friday afternoon, I managed to get hold of someone and he said he'd be able to do it over half a week. I sent him photos and had him take measurements to match not only the correct length and notch fitment, but also a groove to machine out to hold the retentive circlip. And the end result? *chef's kiss* Perfect. Since I didn't have pliers with me when I picked up the items, I tested the old gear and circlip on. Perfect fit. After that it was simply swapping out the plug bracket to the new sensor, mount it on the transfer case, refill with ATF/Nissan Matic Fluid D, then test out function. Thankfully with the rebuilt cluster and the new sensor, both the speedometer and odometer and now working properly!   And there you have it. About 5-6 weeks of headaches wrapped up in a 15 minute photo essay. As I was told it is rare for sensors of this generation to die so dramatically, but you never know what could go wrong with a 25+ year old car. I HOPE that no one else has to go through this problem like I did, so with my take on a solution I hope it helps others who may encounter this issue in the future. For the TL;DR: 1) Sensor breaks. 2) Find a replacement GTT/GTS-T sensor. 3) Find a CNC machinist to have you cut it down to proper specs. 4) Reinstall then pray to the JDM gods.   Hope this guide/story helps anyone else encountering this problem!
    • perhaps i should have mentioned, I plugged the unit in before i handed over to the electronics repair shop to see what damaged had been caused and the unit worked (ac controls, rear demister etc) bar the lights behind the lcd. i would assume that the diode was only to control lighting and didnt harm anything else i got the unit back from the electronics repair shop and all is well (to a point). The lights are back on and ac controls are working. im still paranoid as i beleive the repairer just put in any zener diode he could find and admitted asking chatgpt if its compatible   i do however have another issue... sometimes when i turn the ignition on, the climate control unit now goes through a diagnostics procedure which normally occurs when you disconnect and reconnect but this may be due to the below   to top everything off, and feel free to shoot me as im just about to do it myself anyway, while i was checking the newly repaired board by plugging in the climate control unit bare without the housing, i believe i may have shorted it on the headunit surround. Climate control unit still works but now the keyless entry doesnt work along with the dome light not turning on when you open the door. to add to this tricky situation, when you start the car and remove the key ( i have a turbo timer so car remains on) the keyless entry works. the dome light also works when you switch to the on position. fuses were checked and all ok ive deduced that the short somehow has messed with the smart entry control module as that is what controls the keyless entry and dome light on door opening   you guys wouldnt happen to have any experience with that topic lmao... im only laughing as its all i can do right now my self diagnosed adhd always gets me in a situation as i have no patience and want to get everything done in shortest amount of time as possible often ignoring crucial steps such as disconnecting battery when stuffing around with electronics or even placing a simple rag over the metallic headunit surround when placing a live pcb board on top of it   FML
    • Bit of a pity we don't have good images of the back/front of the PCB ~ that said, I found a YT vid of a teardown to replace dicky clock switches, and got enough of a glimpse to realize this PCB is the front-end to a connected to what I'll call PCBA, and as such this is all digital on this PCB..ergo, battery voltage probably doesn't make an appearance here ; that is, I'd expect them to do something on PCBA wrt power conditioning for the adjustment/display/switch PCB.... ....given what's transpired..ie; some permutation of 12vdc on a 5vdc with or without correct polarity...would explain why the zener said "no" and exploded. The transistor Q5 (M33) is likely to be a digital switching transistor...that is, package has builtin bias resistors to ensure it saturates as soon as base threshold voltage is reached (minimal rise/fall time)....and wrt the question 'what else could've fried?' ....well, I know there's an MCU on this board (display, I/O at a guess), and you hope they isolated it from this scenario...I got my crayons out, it looks a bit like this...   ...not a lot to see, or rather, everything you'd like to see disappears down a via to the other side...base drive for the transistor comes from somewhere else, what this transistor is switching is somewhere else...but the zener circuit is exclusive to all this ~ it's providing a set voltage (current limited by the 1K3 resistor R19)...and disappears somewhere else down the via I marked V out ; if the errant voltage 'jumped' the diode in the millisecond before it exploded, whatever that V out via feeds may have seen a spike... ....I'll just imagine that Q5 was switched off at the time, thus no damage should've been done....but whatever that zener feeds has to be checked... HTH
×
×
  • Create New...