Jump to content
SAU Community

Recommended Posts

Hi guys, i recently attempted to fount a front mount intercooler kit on my R33. Had no problems removing the standard intercooler but i am facing great difficulties cutting a hole in the chasis on the drivers side and trimming the reinforcement bar. Need the car urgently back on the road but not able to drive the car to a mechanic to get it fixed because the standard intercooler and the reinforcement bar have been removed!

Was wondering anyone out there could help me in cutting the hole in the chasis and trimming the reinforcement bar. Will pay some money. I am located in central brisbane.

Can contact me on 0432022070

Link to comment
https://www.sau.com.au/forums/topic/78561-could-someone-please-help-me/
Share on other sites

If I were you I'd call some mobile car stereo/immobiliser installers until you find one with the equipment to cut metal in their truck.

also I'd save you waiting around for some good samaratin on here.

The alternate solution is Cable ties and gaffer tape. Just tie and tape your car back together and drive it to the workshop.

Big drill, expensive hole saw bit, push hard...

Alternatively... Drill lots of small holes around the circumference of where you want the hole until you have yourself a big hole...

As for the reo bar, a grinder and cutting disk works wonders... Shouldn't cost you more than 30 bucks at Supercheap to get one... Just watch your fingers ;)

Either get a proper drill (none of this cordless shit).. and a hole cutter that fits onto the end of the drill. Again, a drill from bunnings will cost you $30 and even ok quality. The hole cutters are NOT expensive (bad strutto) for the cheap ass one.. about $15. You will probably destroy the blade, but just throw it out afterwards. Problem is that its probably not going to be wide enough diameter, so you may have to do two side by side.

Otherwise, Bunnings.. anglegrinder.. this is what I used no problems. Just draw up a "box" and cut 4 straight and neat lines. Anglegrinder is about $30 these days (nothing) and even not too bad quality.. thinner disc is about $2..Angle grinder is $30 entertainment in itself, shoots off all sorts of fireworks.. you'll be going "weeeee" the whole time..

nice effort cyrus.

go to a decent tool shop such as tradetools or glennfords and get a steel holesaw suitable for the size of your cooler pipe.

on a r33 you will have to remove your washer bottle obviously. use an electric drill to drill the hole, its advisable to use cutting oil or a holl drilling spray to save your new hole saw otherwise you will **** the teeth on it. also dont go too fast at it or again you will heat the metal up and screw the teeth on the holesaw.

cutting the rio use an angle grinder, make sure you actually hang onto it and dont test the sharpness of the blade on your fingers. be carefull using powertools, they can do nasty things in the wrong hands.

If I were you I'd call some mobile car stereo/immobiliser installers until you find one with the equipment to cut metal in their truck.

also I'd save you waiting around for some good samaratin on here.

The alternate solution is Cable ties and gaffer tape. Just tie and tape your car back together and drive it to the workshop.

The good samaratin has arrived!

Problem solvered. Just borrowed my dad's little compressor and used my air hacksaw from work. Drilled a pilot hole and worked my way around from there. Not too many hassles cept the hole is more square than round. You can't see it anyway so everyone ended up satisfied in the end.

masonry bit you may as well stand there with the hose and try and blast your way through.

you need a proper hole saw made for use with steel, or a steel drill bit, another option is use a drill bit to drill a small slot out then use a reciprocating saw to cut the hole out, be warned this isnt a pretty way to do it, it ends up pretty messy

Word of wise guys too, when using a grinder around your car cover the roof,bonnet/boot (depending on were u r working) & windscreen with sheets!!!!!!!! Trust me you don't want metal bits melted into your paint work & windscreen.

Create an account or sign in to comment

You need to be a member in order to leave a comment

Create an account

Sign up for a new account in our community. It's easy!

Register a new account

Sign in

Already have an account? Sign in here.

Sign In Now


  • Similar Content

  • Latest Posts

    • Hi, is the HKS  Tower Bar still available ? negotiable ? 🤔
    • From there, it is really just test and assemble. Plug the adapter cables from the unit into the back of the screen, then the other side to the car harness. Don't forget all the other plugs too! Run the cables behind the unit and screw it back into place (4 screws) and you should now have 3 cables to run from the top screen to the android unit. I ran them along the DS of the other AV units in the gap between their backets and the console, and used some corrugated tubing on the sharp edges of the bracket so the wires were safe. Plug the centre console and lower screen in temporarily and turn the car to ACC, the AV should fire up as normal. Hold the back button for 3 sec and Android should appear on the top screen. You need to set the input to Aux for audio (more on that later). I put the unit under the AC duct in the centre console, with the wifi antenna on top of the AC duct near the shifter, the bluetooth antenna on the AC duct under the centre console The GPS unit on top of the DS to AC duct; they all seem to work OK there are are out of the way. Neat cable routing is a pain. For the drive recorder I mounted it near the rear view mirror and run the cable in the headlining, across the a pillar and then down the inside of the a pillar seal to the DS lower dash. From there it goes across and to one USB input for the unit. The second USB input is attached to the ECUtec OBD dongle and the 3rd goes to the USB bulkhead connected I added in the centre console. This is how the centre console looks "tidied" up Note I didn't install the provided speaker, didn't use the 2.5mm IPod in line or the piggyback loom for the Ipod or change any DIP switches; they seem to only be required if you need to use the Ipod input rather than the AUX input. That's it, install done, I'll follow up with a separate post on how the unit works, but in summary it retains all factory functions and inputs (so I still use my phone to the car for calls), reverse still works like factory etc.
    • Place the new daughterboard in the case and mount it using the 3 small black rivets provided, and reconnect the 3 factory ribbon cables to the new board Then, use the 3 piggyback cables from the daughterboard into the factory board on top (there are stand offs in the case to keep them apart. and remember to reconnect the antenna and rear cover fan wires. 1 screw to hold the motherboard in place. Before closing the case, make a hole in the sticker covering a hole in the case and run the cable for the android unit into the plug there. The video forgot this step, so did I, so will you probably. Then redo the 4 screws on back, 2 each top and bottom, 3 each side and put the 2 brackets back on.....all ready to go and not that tricky really.      
    • Onto the android unit. You need to remove the top screen because there is a daughterboard to put inside the case. Each side vent pops out from clips; start at the bottom and carefully remove upwards (use a trim remover tool to avoid breaking anything). Then the lower screen and controls come out, 4 screws, a couple of clips (including 3 flimsy ones at the top) and 3 plugs on the rear. Then the upper screen, 4 screws and a bunch of plugs and she is out. From there, remove the mounting brackets (2 screws each), 4 screws on the rear, 2 screws top and bottom and 3 screws holding in the small plates on each side. When you remove the back cover (tight fit), watch out for the power cable for the fan, I removed it so I could put the back aside. The mainboard is held in by 1 screw in the middle, 1 aerial at the top and 3 ribbon cables. If you've ever done any laptop stuff the ribbon cables are OK to work with, just pop up the retainer and they slide out. If you are not familiar just grab a 12 year old from an iphone factory, they will know how it works The case should now look like this:
    • Switching the console was tricky. First there were 6 screws to remove, and also the little adapter loom and its screws had to come out. Also don't forget to remove the 2 screws holding the central locking receiver. Then there are 4 clips on either side....these were very tight in this case and needed careful persuading with a long flat screw driver....some force required but not enough to break them...this was probably the fiddliest part of the whole job. In my case I needed both the wiring loom and the central locking receiver module to swap across to the new one. That was it for the console, so "assembly is the reverse of disassembly"
×
×
  • Create New...