Jump to content
SAU Community

Recommended Posts

For those who do have probs just check your soldering job. The tracks are very close in spots and thats necessary to keep the size of the unit down. Its very easy to short out a component if you are not careful. Use a magnifying glass to check the circuit board after its been built and clean the board after you have soldered the components with a small plastic brush to remove any metalic contaminants.

Hope thats of some help

Regards

Bov

  • Replies 91
  • Created
  • Last Reply

Top Posters In This Topic

  • 2 weeks later...

may do another batch later on, but realistically that wouldnt be before feb (the boards themselves may take up to a month to get done)

would also want a bit more feedback on what would be good to improve if i was to. currently i have:

1. fix yellow led

2. make those 2 tight spaced components more room

3. more room so crystal can lay flat (look into low profile crystal)

4. look into 4024 14 pin counter (replace 4060 16 pin)

5. IC sockets rather than soldering into pcb (given pcb sits lower than i originally designed means theyll fit)

6. change pcb a bit where leds go to make it square (originally that cutout bit wasnt supposed to be cutout by pcb manufacturers)

7. dont use that stupid packaging tape as it leaves the boxes sticky!

8. finally, see how difficult it would be to put USB on same board

Edited by NewKleer

I kind of like how the LEDs poke through the screw holes for the Serial ports, but i also think its important to be able to lock the serial cables onto the unit. Since many of these will be mounted permanently there is a chance that they could vibrate loose without the DB9 connector screws...

its pretty difficult to put the nuts onto the connectors (ive not idea how ud do it without glueing them on, unless u just somehow use the existing holes where leds go thru as the nut). its pretty dam tight fit for the connectors to go together, so i dont think they fall off easily?

and the idea is that u disconnect the consult cable from the box when not using it (to cut power etc)

Chalk another one up for working first go.

Finally got a few hours free today to solder it up and test it out. Worked fine with all the software mentioned in the thread. FYI I didn't solder any of the pins in the consult connector. I just crimped them as they were designed to do. I actually found this to be the easiest part of the job.

Thanks for the kit NewKleer.

what did u use to crimp them? i dont have any crimping tools on hand (and i doubt most people would) but might be useful to get one if theres a cheap one that can do it

ive found 2 more kits all ready to go that i didnt think i had (might have 1 or 2 more after this also, but need to check parts).

Edited by NewKleer

ive gone ahead and designed a combined usb/serial version that potentially can be used as either serial, usb, or both (with jumpers changing whether its serial or usb), which improves on all the points i listed above (except not worrying about point 4).

only thing is if u want to have both usb and serial, to switch between them ud have to open the box (unless u drill a hole and maybe get those easy to change jumpers that have the extra plastic on it to make it longer so its easy to grab to remove, if anyone knows what i mean)

the usb chip is a smd one (surface mount) so i might have to solder it to the board for usb versions as i cant imagine it being too easy for most people to do with normal soldering iron.

Edited by NewKleer

will need to test circuit (mainly usb side) before boards are manufactured, and then do the construction guide etc, so realistically not till feb some time (and of course assuming theres nothing major goes wrong with any of it)

good to hear.

heres a few pics on the layout of the pcb for the usb/serial one. the 4 blocks in the middle (and one down bottom left) are the jumpers to switch between usb/serial. top right chip is usb which ill hopefully be able to solder to pcb. waiting on parts (1-2 weeks) before i can test circuit, then go ahead with board manufacture if all is good.

Edited by NewKleer
  • 2 weeks later...

still waiting on some parts to do some testing before i get boards done. however i might put this on hold while im working on the consult display which could, if i go overboard, include a usb/serial consult interface as part of it (if it does i might cancel this one). not sure that ill have the funds up front to do both at same time, so will have to see.

its definitely the priority over this given being something thats useful everyday (whereas the majority of people wont have a laptop permanently in the car)

Edited by NewKleer
  • 2 weeks later...

ive decided at this stage to put any further consult interface kits on hold indefinitely as i wont have time whilst working on the consult lcd display:

http://www.skylinesaustralia.com/forums/in...howtopic=102414

im planning to have it come with integrated serial and usb consult interfaces

Guest
This topic is now closed to further replies.



  • Similar Content

  • Latest Posts

    • Look, realistically, those are some fairly chunky connectors and wires so it is a reasonably fair bet that that loom was involved in the redirection of the fuel pump and/or ECU/ignition power for the immobiliser. It's also fair to be that the new immobiliser is essentially the same thing as the old one, and so it probably needs the same stuff done to make it do what it has to do. Given that you are talking about a car that no-one else here is familiar with (I mean your exact car) and an alarm that I've never heard of before and so probably not many others are familiar with, and that some wire monkey has been messing with it out of our sight, it seems reasonable that the wire monkey should be fixing this.
    • Wheel alignment immediately. Not "when I get around to it". And further to what Duncan said - you cannot just put camber arms on and shorten them. You will introduce bump steer far in excess of what the car had with stock arms. You need adjustable tension arms and they need to be shortened also. The simplest approach is to shorten them the same % as the stock ones. This will not be correct or optimal, but it will be better than any other guess. The correct way to set the lengths of both arms is to use a properly built/set up bump steer gauge and trial and error the adjustments until you hit the camber you need and want and have minimum bump steer in the range of motion that the wheel is expected to travel. And what Duncan said about toe is also very true. And you cannot change the camber arm without also affecting toe. So when you have adjustable arms on the back of a Skyline, the car either needs to go to a talented wheel aligner (not your local tyre shop dropout), or you need to be able to do this stuff yourself at home. Guess which approach I have taken? I have built my own gear for camber, toe and bump steer measurement and I do all this on the flattest bit of concrete I have, with some shims under the tyres on one side to level the car.
    • Thought I would get some advice from others on this situation.    Relevant info: R33 GTS25t Link G4x ECU Walbro 255LPH w/ OEM FP Relay (No relay mod) Scenario: I accidentally messed up my old AVS S5 (rev.1) at the start of the year and the cars been immobilised. Also the siren BBU has completely failed; so I decided to upgrade it.  I got a newer AVS S5 (rev.2?) installed on Friday. The guy removed the old one and its immobilisers. Tried to start it; the car cranks but doesnt start.  The new one was installed and all the alarm functions seem to be working as they should; still wouldn't start Went to bed; got up on Friday morning and decided to have a look into the no start problem. Found the car completely dead.  Charged the battery; plugged it back in and found the brake lights were stuck on.  Unplugging the brake pedal switch the lights turn off. Plug it back in and theyre stuck on again. I tested the switch (continuity test and resistance); all looks good (0-1kohm).  On talking to AVS; found its because of the rubber stopper on the brake pedal; sure enough the middle of it is missing so have ordered a new one. One of those wear items; which was confusing what was going on However when I try unplugging the STOP Light fuses (under the dash and under the hood) the brake light still stays on. Should those fuses not cut the brake light circuit?  I then checked the ECU; FP Speed Error.  Testing the pump again; I can hear the relay clicking every time I switch it to ON. I unplugged the pump and put the multimeter across the plug. No continuity; im seeing 0.6V (ECU signal?) and when it switches the relay I think its like 20mA or 200mA). Not seeing 12.4V / 7-9A. As far as I know; the Fuel Pump was wired through one of the immobiliser relays on the old alarm.  He pulled some thick gauged harness out with the old alarm wiring; which looks to me like it was to bridge connections into the immobilisers? Before it got immobilised it was running just fine.  Im at a loss to why the FP is getting no voltage; I thought maybe the FP was faulty (even though I havent even done 50km on the new pump) but no voltage at the harness plug.  Questions: Could it be he didnt reconnect the fuel pump when testing it after the old alarm removal (before installing the new alarm)?  Is this a case of bridging to the brake lights instead of the fuel pump circuit? It's a bit beyond me as I dont do a lot with electrical; so have tried my best to diagnose what I think seems to make sense.  Seeking advice if theres for sure an issue with the alarm install to get him back here; or if I do infact, need an auto electrician to diagnose it. 
    • Then, shorten them by 1cm, drop the car back down and have a visual look (or even better, use a spirit level across the wheel to see if you have less camber than before. You still want something like 1.5 for road use. Alternatively, if you have adjustable rear ride height (I assume you do if you have extreme camber wear), raise the suspension back to standard height until you can get it all aligned properly. Finally, keep in mind that wear on the inside of the tyre can be for incorrect toe, not just camber
    • I know I have to get a wheel alignment but until then I just need to bring the rear tyres in a bit they're wearing to the belt on the inside and brand new on the outside edge. I did shorten the arms a bit but got it wrong now after a few klms the Slip and VDC lights come on. I'd just like to get it to a point where I can drive for another week or two before getting an alignment. I've had to pay a lot of other stuff recently so doing it myself is my only option 
×
×
  • Create New...