Jump to content
SAU Community

Recommended Posts

Hi all,

As the title says I got my Stagea tuned today.

I went to HiTech Dyno (run by John Keen who ran Turbo Tune many years ago, incidentally also the brother of Bill Keen from ATS who fitted my turbo). They have a very good reputation here in SA and prices were very good. ($250 to install and tune safc).

Had new spark plugs fitted, SAFC1 (blue screen) installed and tuned, and a JRD boost controller installed (similar to the $22 manual boost controller).

Very happy with the result - 170.2 rwkw!!

It was on a 2WD dyno so i'm not sure how to convert to awkw (I've always thought it was just rwkw-20=awkw - someone correct me on this)..

and if you follow the boost graph, this figure is at only 9psi :P

Mods are:

- GT30 turbo (machined into stock R34 housing)

- 3" turbo-back exhaust

- JRD boost controller set to 11psi

- SAFC1

- Apexi Panel Air Filter (dry type).

- MV auto trans valve upgrade.

Boost builds quickly to 11psi but then soon starts dropping off down to 9psi. Not bad from a $35 boost controller tho (that includes Postage).

I dont have a AFR graph - but I'm thinking of calling into the place sometime and getting some extra printouts - I've heard they keep the files on their computer...

Here's the dyno printout, showing power and boost:

post-23960-1160557327.jpg

:P

Link to comment
https://www.sau.com.au/forums/topic/138246-my-latest-dyno-results/
Share on other sites

Nice! So is that a 70% power gain over the turbo on it's own? (I think you had a disappointing 100kw run before)

Luke

Not quite. The 100kw run was on a 4wd dyno.

The exhaust made the biggest difference. I reckon I picked up nearly 40awkw after that due to the bigger turbo (normally an exhaust would give ~20kw extra).

Then with the safc install and tune that would've picked up a bit extra...

Its about a 40% power gain (exhaust, safc, jrd boost controller). :P

Not only that, it has good response now too.

nice, at 9psi too! Roughly, I gather that to be around 145awk then?

will you be doing a larger fmic and raising boost? Im sure you could have an easy 200rwkw with the next tune :P

Cooling wasn't a problem. The issue was more about fuel...

The safc can only correct so much and at higher airflow with the gt30 turbo John reckoned I'd be getting too close to the ecu's fuel cut. Not sure how to overcome that exactly...

160awkw was my target, and I would've thought 170rwkw is closer to 150awkw (??) so thats close enough for me.

A better quality boost controller that holds 11psi constant would give me the 160awkw I was after.

There is more potential in the car than this but at this point I have a good reliable car making decent power and I'm very happy with that. :D

thats a decent amount of power to put on the tarmac ....gr8 results there....now u mentioned fuel was a problem...do u reckon a higher flowing fuel pump and a fuel regulator is gonna help towards a 200rwkw benchmark?

would be interesting to see what my s1 would be capable of using the stock turbo @10psi normal and 12psi angry mode....but that will be a month away still coz im pretty broke at the moment (day care bills for my young ones really biting into my budget)

what did you have to do when tuning on a 2wd dyno unit? as in did you just pull a fuse or was the atessa system somewhat more complicated to get around?

just curious as i am getting my computer fitted mid next week in my series2 manual so would be nice to know if its safe to just yank the fuse, or do i have to do a whole lot more?

must drop the front driveshaft.

dont just pull the fuse - attessa repairs arnt cheap.

madaz drove his GT4 with a space-saver rim on for a while, shagged his system, was a 4k fix I think. always drop the shaft.

:dry:

must drop the front driveshaft.

dont just pull the fuse - attessa repairs arnt cheap.

madaz drove his GT4 with a space-saver rim on for a while, shagged his system, was a 4k fix I think. always drop the shaft.

:)

yep, they dropped the front driveshaft AND pulled the fuse (just clearing that up). :)

the r32 gtr's could be put into rwd by just pulling the fuse but anything later than that requires the front driveshaft removed as well.

:)

fcruz3r: not sure if fuel pump and fuel pressure regulator will allow me to get more power. My knowledge on it all is very limited but I'd guess that these would definitely help, and would be required to get more power, but on their own they may not be enough. At the moment there is no issue with fuel at all. The only problem was that if I raise the boost any higher than 12psi the ecu cuts the fuel so John from hitech dyno made sure it was going to be safe as is. There doesn't appear to be any issue at all with the car right now.

As far as I know the ecu will cut fuel once it detects too much air flow (and hence would require more fuel than the ecu thinks the car can handle, and therefore it cuts fuel to prevent damage). So just the ability to provide more fuel wouldn't be enough as far as I see it. I know the apexi SITC (ignition timing) allows better control over ignition timing and also allows the safc to be tuned better (independant of ignition timing) but I'm not sure how to remove the fuel cut issue etc...

Either way, I've spent over $2k on the car in the last month so its time to leave it alone for a while and enjoy it in its current state. And I must say it IS very enjoyable right now.

The safc has made a very noticeable difference in power, from midrange right to the top end, and sounds so much "cleaner" and nicer than before the tune. Before it ran very rich (could smell petrol after driving hard) and the power really dropped off at the top end as I presume it possibly was hitting R&R mapping at high revs...either way it had a flat spot near 4000-4500 rpm and failed to pick up after that.

But now its got very smooth power delivery all the way. Its something like 50% more power than before I did the exhaust and safc etc. and the difference is just incredible. :)

what did you have to do when tuning on a 2wd dyno unit? as in did you just pull a fuse or was the atessa system somewhat more complicated to get around?

just curious as i am getting my computer fitted mid next week in my series2 manual so would be nice to know if its safe to just yank the fuse, or do i have to do a whole lot more?

oxford are you taking it to UAS. they have done at least 2 manuals now and have/are building some experience with them.

no i wont be takin my car to UAS.

i am in ballarat in victoria so am taking it to a local mob i just wanted to clarify some things that i have had conflicting opinions on.

EG: #1 dont hafta take shafts out but need to bleed off pressure in the atessa system, #2 do hafta take shafts out or will burn clutches out, #3 if do chose to take shafts out it will lunch the front diff because of the lash when there is no load on it etc....

thats why i thouhgt i would ask some of the guys on here and get a 15th opinion.

i have since spoken to andy (EGA41T) on the phone and he has assured me that when his was done they took the shafts out and seemed to be all good so i am gonna take that info to my tuner as a good recommendation.

person i am gettin to do the power fc install was just not sure as he had never seen let alone tuned a stagea before he laid eyes on mine couple weeks ago, even though he has worked plenty of skylines over in the past he just wanted to be sure so as to not damage my car.

hey steve....reckon u could get some pics of where u mounted the safc...am looking for ideas and atm the only place i can think of is just in front of the gear leaver which i think will make the coin box and drink holder useless.

unless of course i get a new head unit and remove the crap jap shiet thats in there...but thats gonna cost $$$

hey steve....reckon u could get some pics of where u mounted the safc...am looking for ideas and atm the only place i can think of is just in front of the gear leaver which i think will make the coin box and drink holder useless.

unless of course i get a new head unit and remove the crap jap shiet thats in there...but thats gonna cost $$$

haha a photo won't be necessary at the moment. Its not actually mounted anywhere.

They ran the cable around so it sticks out just to the right of the passenger seat beside where the stereo is (it pokes out under the plastic).

All I've done is place it under the passenger seat so you can see the cable but not the unit - and it doesn't get thrown around when I accelerate or turn.

It would look great mounted on the dash somewhere but I'm just concerned about getting pulled over and being defected for it. :)

Not sure where to mount it. I'm thinking just on the side wall there to the left of the stereo and under the glovebox. Any other ideas? :D

fcruz3r: not sure if fuel pump and fuel pressure regulator will allow me to get more power. My knowledge on it all is very limited but I'd guess that these would definitely help, and would be required to get more power, but on their own they may not be enough. At the moment there is no issue with fuel at all. The only problem was that if I raise the boost any higher than 12psi the ecu cuts the fuel so John from hitech dyno made sure it was going to be safe as is. There doesn't appear to be any issue at all with the car right now.

As far as I know the ecu will cut fuel once it detects too much air flow (and hence would require more fuel than the ecu thinks the car can handle, and therefore it cuts fuel to prevent damage). So just the ability to provide more fuel wouldn't be enough as far as I see it. I know the apexi SITC (ignition timing) allows better control over ignition timing and also allows the safc to be tuned better (independant of ignition timing) but I'm not sure how to remove the fuel cut issue etc...

You have a couple of easy (relatively cheap) ways to achieve a result;

1. Fit a larger fuel pump, a GTR one would be fine ($200 or so on the for sale forum)

2. A Nismo adj fuel pressure regulator ($150 from Nengun)

3. Increase the fuel pressure to ~45 psi (standard is 34-36 psi)

4. Replace the fuel hoses and use better clamps, the standard ones are not up to the higher pressure.

5. Use the SAFC to lean it off (lower the AFM voltage input to the ECU) as required at low loads, where the increase fuel pressure has richened it up too much.

6. You shouldn’t have to apply too much SAFC correction at higher revs (over ~5,500 rpm) as the increase fuel pressure should do that for you

7. Then use an SITC to advance/retard the ignition timing as required. They are getting hard to find, so if you don’t already have one, start looking now.

That should get you to around 215-220 rwkw which is about as much as the standard injectors are going to cope with (even at the higher fuel pressure).

:D cheers :P

#1 dont hafta take shafts out but need to bleed off pressure in the atessa system

#2 do hafta take shafts out or will burn clutches out

#3 if do chose to take shafts out it will lunch the front diff because of the lash when there is no load on it

1. You remove front tail shaft, not the drive shafts. Can bleed off pressure, but it's messy and you have to bleed the air out when replacing it. Simpler to just remove the front tailshaft, takes about 10 minutes.

2. 100% BS

3. 100% BS

:D cheers :P

You have a couple of easy (relatively cheap) ways to achieve a result;

1. Fit a larger fuel pump, a GTR one would be fine ($200 or so on the for sale forum)

2. A Nismo adj fuel pressure regulator ($150 from Nengun)

3. Increase the fuel pressure to ~45 psi (standard is 34-36 psi)

4. Replace the fuel hoses and use better clamps, the standard ones are not up to the higher pressure.

5. Use the SAFC to lean it off (lower the AFM voltage input to the ECU) as required at low loads, where the increase fuel pressure has richened it up too much.

6. You shouldn’t have to apply too much SAFC correction at higher revs (over ~5,500 rpm) as the increase fuel pressure should do that for you

7. Then use an SITC to advance/retard the ignition timing as required. They are getting hard to find, so if you don’t already have one, start looking now.

That should get you to around 215-220 rwkw which is about as much as the standard injectors are going to cope with (even at the higher fuel pressure).

:( cheers :(

wow, so are you suggesting that I could get around 200awkw for less than $1000 from here?

I do want to keep it safe so the engine still lasts a long time so dont want to push the stock internals too far to the limits.

Still, this would be a great upgrade for sometime in the future (maybe this time next year).

Gotta love the upgrade potential of turbo cars. :)

One thing I would assume with the above list is that because there is talk of increasing fuel pressure and making more power, there would also be a negative impact on fuel economy as a result. Something I'll need to weigh up if the opportunity to do these mods ever arises :P

Create an account or sign in to comment

You need to be a member in order to leave a comment

Create an account

Sign up for a new account in our community. It's easy!

Register a new account

Sign in

Already have an account? Sign in here.

Sign In Now


  • Similar Content

  • Latest Posts

    • Well, that's kinda the point. The calipers might interfere with the inside of the barrels 16" rims are only about 14" inside the barrels, which is ~350mm, and 334mm rotors only leave about 8mm outboard for the caliper before you get to 350, And.... that;s not gunna be enough. If the rims have a larger ID than that, you might sneak it in. I'd be putting a measuring stick inside the wheel and eyeballing the extra required for the caliper outboard of the rotor before committing to bolting it all on.
    • OK, so again it has been a bit of a break but it was around researching what had been done since I didn't have access to Neil's records and not everything is obvious without pulling stuff apart. Happily the guy who assembled the engine had kept reasonable records, so we now know the final spec is: Bottom end: Standard block and crank Ross 86.5mm forgies, 9:1 compression Spool forged rods Standard main bolts Oil pump Spool billet gears in standard housing Aeroflow extended and baffled sump Head Freshly rebuilt standard head with new 80lb valve springs Mild porting/port match Head oil feed restrictor VCT disabled Tighe 805C reground cams (255 duration, 8.93 lift)  Adjustable cam gears on inlet/exhaust Standard head bolts, gasket not confirmed but assumed MLS External 555cc Nismo injectors Z32 AFM Bosch 023 Intank fuel pump Garret 2871 (factory housings and manifold) Hypertune FFP plenum with standard throttle   Time to book in a trip to Unigroup
    • I forgot about my shiny new plates!
    • Well, apparently they do fit, however this wont be a problem if not because the car will be stationary while i do the suspension work. I was just going to use the 16's to roll the old girl around if I needed to. I just need to get the E90 back on the road first. Yes! I'm a believer! 🙌 So, I contacted them because the site kinda sucks and I was really confused about what I'd need. They put together a package for me and because I was spraying all the seat surfaces and not doing spot fixes I decided not to send them a headrest to colour match, I just used their colour on file (and it was spot on).  I got some heavy duty cleaner, 1L of colour, a small bottle of dye hardener and a small bottle of the dye top coat. I also got a spray gun as I needed a larger nozzle than the gun I had and it was only $40 extra. From memory the total was ~$450 ish. Its not cheap but the result is awesome. They did add repair bits and pieces to the quote originally and the cost came down significantly when I said I didn't need any repair products. I did it over a weekend. The only issues I had were my own; I forgot to mix the hardener into the dye two coats but I had enough dye for 2 more coats with the hardener. I also just used up all the dye because why not and i rushed the last coat which gave me some runs. Thankfully the runs are under the headrests. The gun pattern wasn't great, very round and would have been better if it was a line. It made it a little tricky to get consistent coverage and I think having done the extra coats probably helped conceal any coverage issues. I contacted them again a few months later so I could get our X5 done (who the f**k thought white leather was a good idea for a family car?!) and they said they had some training to do in Sydney and I could get a reduced rate on the leather fix in the X5 if I let them demo their product on our car. So I agreed. When I took Bec in the E39 to pick it up, I showed them the job I'd done in my car and they were all (students included) really impressed. Note that they said the runs I created could be fixed easily at the time with a brush or an air compressor gun. So, now with the two cars done I can absolutely recommend Colourlock.  I'll take pics of both interiors and create a new thread.
    • Power is fed to the ECU when the ignition switch is switched to IGN, at terminal 58. That same wire also connects to the ECCS relay to provide both the coil power and the contact side. When the ECU sees power at 58 it switches 16 to earth, which pulls the ECCS relay on, which feeds main power into the ECU and also to a bunch of other things. None of this is directly involved in the fuel pump - it just has to happen first. The ECU will pull terminal 18 to earth when it wants the fuel pump to run. This allows the fuel pump relay to pull in, which switches power on into the rest of the fuel pump control equipment. The fuel pump control regulator is controlled from terminal 104 on the ECU and is switched high or low depending on whether the ECU thinks the pump needs to run high or low. (I don't know which way around that is, and it really doesn't matter right now). The fuel pump control reg is really just a resistor that controls how the power through the pump goes to earth. Either straight to earth, or via the resistor. This part doesn't matter much to us today. The power to the fuel pump relay comes from one of the switched wires from the IGN switch and fusebox that is not shown off to the left of this page. That power runs the fuel pump relay coil and a number of other engine peripherals. Those peripherals don't really matter. All that matters is that there should be power available at the relay when the key is in the right position. At least - I think it's switched. If it's not switched, then power will be there all the time. Either way, if you don't have power there when you need it (ie, key on) then it won't work. The input-output switching side of the relay gains its power from a line similar (but not the same as) the one that feeds the ECU. SO I presume that is switched. Again, if there is not power there when you need it, then you have to look upstream. And... the upshot of all that? There is no "ground" at the fuel pump relay. Where you say: and say that pin 1 Black/Pink is ground, that is not true. The ECU trigger is AF73, is black/pink, and is the "ground". When the ECU says it is. The Blue/White wire is the "constant" 12V to power the relay's coil. And when I say "constant", I mean it may well only be on when the key is on. As I said above. So, when the ECU says not to be running the pump (which is any time after about 3s of switching on, with no crank signal or engine speed yet), then you should see 12V at both 1 and 2. Because the 12V will be all the way up to the ECU terminal 18, waiting to be switched to ground. When the ECU switches the fuel pump on, then AF73 should go to ~0V, having been switched to ground and the voltage drop now occurring over the relay coil. 3 & 5 are easy. 5 is the other "constant" 12V, that may or may not be constant but will very much want to be there when the key is on. Same as above. 3 goes to the pump. There should never be 12V visible at 3 unless the relay is pulled in. As to where the immobiliser might have been spliced into all this.... It will either have to be on wire AF70 or AF71, whichever is most accessible near the alarm. Given that all those wires run from the engine bay fusebox or the ECU, via the driver's area to the rear of the car, it could really be either. AF70 will be the same colour from the appropriate fuse all the way to the pump. If it has been cut and is dangling, you should be able to see that  in that area somewhere. Same with AF71.   You really should be able to force the pump to run. Just jump 12V onto AF72 and it should go. That will prove that the pump itself is willing to go along with you when you sort out the upstream. You really should be able to force the fuel pump relay on. Just short AF73 to earth when the key is on. If the pump runs, then the relay is fine, and all the power up to both inputs on the relay is fine. If it doesn't run (and given that you checked the relay itself actually works) then one or both of AF70 and AF71 are not bringing power to the game.
×
×
  • Create New...