Jump to content
SAU Community

Recommended Posts

Braided lines and a master cylinder stopper will fix all your probs with some new fluided added.

Every car I drive feels like the brakes are spongy in comparison.

Brakes used to be perfect. Bit well the moment you touch the pedal. Problems began after I fried the brakes on a track.

The pedal does nothing until about half travel.

I have braided brake lines, QFM A1RM pads, new discs, master cylinder to strut stopper.

I removed and drained the fluid from all four calipers, refitted, bled - no difference.

I rebuilt the master cylinder - no difference

I rebuilt the front calipers - no difference

I bled the system no less than 10 times including the ABS unit, in the order the manual recommended - no difference.

I lifted the car in the air, an assitant "drove" it while leaning on the brake pedal to trigger the ABS while I bled it - no difference

When I manually energize any of the three ABS servo solenoids and the fluid return motor, the pedal goes rock solid and can't be moved at all. This means the master cylinder is perfect and it's not firewall flex. It's ABS servo or the calipers have gone soft.

Hence I'd like a damaged/leaky ABS unit to investigate the problem. Somebody must have one, i've seen plenty of threads where people have replaced their leaky ones.

Cheers

Edited by Bozz

Lets just say this isn't for the inexperienced, there are hundreds of parts inside. If you can rebuild automatic transmission valve bodies or an engine, you'll probably be able to do this job.

To reassemble it will require complete cleanliness and complete accuracy - a single speck of dirt, a missing check ball, seal or incorrect re-assembly could result in no brakes or brakes locking on and not releasing....

Next week i'll acid dip the parts, get all the replacement seals and reassemble it.

post-371-1280038586_thumb.jpg

  • 3 weeks later...
Lets just say this isn't for the inexperienced, there are hundreds of parts inside. If you can rebuild automatic transmission valve bodies or an engine, you'll probably be able to do this job.

To reassemble it will require complete cleanliness and complete accuracy - a single speck of dirt, a missing check ball, seal or incorrect re-assembly could result in no brakes or brakes locking on and not releasing....

Next week i'll acid dip the parts, get all the replacement seals and reassemble it.

WOW!! Everybody I speak to won't go near it because they are too scared to get it wrong. Really interested in how you go with this, I am in exactly the same boat as you, had to remove my brake booster stopper because it was accentuating the ABS unit leaking. Before that nothing I did could get rid of the spongy brake pedal.

Read a thread about someone rebuilding the ABS unit with new o-rings, had a spare/leaky ABS unit lying around from the first time it started leaking, got all the sizes of the o-rings from the thread and tracked down a supplier that could supply the correct type that are ok for use with brake fluid, bought 3 complete sets just incase I wanted to fix the other one & sell it or needed some spares. 6 months later they are still sitting in the zip locked bags on my desk.

Can you please update thread with any further info you have?

Cheers

Rob

WOW!! Everybody I speak to won't go near it because they are too scared to get it wrong.

probably a wise move in many cases. brakes are a very simple pneumatic system, ABS is a very complex pneumatic system.

Hey,

While its apart, I'm trying to draw a 3D exploded view of it in sketchup - there is absolutely no information on the interwebs about how this particular NipponDenso ABS unit operates.

I'm 90% sure the solenoids have three modes (build, maintain, release) instead of just two modes since there are three in/outlets (two at the top, one at the bottom) but I need to establish how to trigger them out of circuit. When time permits I'll hook up my digital storage CRO to two of the ABS solenoids and see how the ABS controller drives them. Google told me that some Toyota's use three mode solenoids but I can't find any pictures of them to see if the solenoids are the same or not. Then I'll be able to build a controller circuit to trigger and bleed the ABS modulator properly.

I dont think the ABS unit is difficult, just very time consuming and you have to triple check everything. I took photos at every step of disassembly so I shouldn't have dramas reassembling it. The only thing slowing me down now is lack of time

probably a wise move in many cases. brakes are a very simple pneumatic system, ABS is a very complex pneumatic system.

Yeah fair enough, rightly so, all bar one bearing place I went to wouldn't even sell me the EPDM (?) o-rings after I told them I was going to attempt to rebuild my ABS with them. Guess people are too scared of litigation these days.

Sif I could somehow blame them if they failed, I think anyone attempting this knows the risks if they get it wrong, I def wouldn't be blaming a supplier for faulty, unqualified workmanship.

I tried rebuilding my ABS using the EPDM o ring list that was on this forum. I had a big fail with a lot of leakage. Most of the original seals have custom cross-sections (few are orings) and i very much doubt that it would be possible to get it properly sealed unless you can get the real seals. But - if you can get a set of proper seals please let us know!

I tried rebuilding my ABS using the EPDM o ring list that was on this forum. I had a big fail with a lot of leakage. Most of the original seals have custom cross-sections (few are orings) and i very much doubt that it would be possible to get it properly sealed unless you can get the real seals. But - if you can get a set of proper seals please let us know!

Thats really disappointing to hear Adam, I was really hoping someone had a success rebuilding one of these. I really want to keep my ABS, no matter how crappy it is compared to modern day systems. Mine only seems to be leaking from the top, I wonder if I can leave the rest alone and just replace the o-rings in that area that have failed? I have no idea as to how the thing comes apart, was thinking about documenting it so I could put it back in the correct order but never got around to it. When you say you had 'lots of leakage', over what period of time and were you still able to stop the car? Or did you have no pedal whatsoever?

Cheers

Rob

Once you pull the body apart, you seperate the high pressure seals between the solenoids and machined aluminium upper and lower bodies. You wont get it to seal again without replacing the seals. Unfortunately, the bottom seal shape appears to be made of unobtanium and you'll have no hope of getting it back together, sealed, without replacing it.

Work on a spare like I am.

Cheers

Thats really disappointing to hear Adam, I was really hoping someone had a success rebuilding one of these. I really want to keep my ABS, no matter how crappy it is compared to modern day systems. Mine only seems to be leaking from the top, I wonder if I can leave the rest alone and just replace the o-rings in that area that have failed? I have no idea as to how the thing comes apart, was thinking about documenting it so I could put it back in the correct order but never got around to it. When you say you had 'lots of leakage', over what period of time and were you still able to stop the car? Or did you have no pedal whatsoever?

I got pedal pressure but it leaked worse than when I pulled it apart. You might have better luck, but IMO some of the seals from the list arent quite the right size even if you leave the shape question aside, and IIRC there were a few missing from that list.

I checked it as soon as it was reinstalled and bled, and pumping the pedal hard was enough to see the telltale wetness. I bought another second hander that looked good, but it also has a small leak. I'm thinking that the ABS manufacturer might be the best place to get seals from, if they're still available. I would like to have another shot at rebuilding, but I lost motivation...

is it a consistent half way pedal feel? is it normal when it gets to half way?

try adjusting the brake pedal pushrod that goes into the master cylinder, i had to do this on my old s13 to get the pedal working correctly

Hi

You seem the type of person that wants to do it for the challenge; if you need a back up plan I have one in good working order for sale.

Regards Taylor

0408 188 777

Bit late unfortunately - I picked one up in good working order for $25 a few weeks ago and it's in my car now.

Thanks for the offer

is it a consistent half way pedal feel? is it normal when it gets to half way?

try adjusting the brake pedal pushrod that goes into the master cylinder, i had to do this on my old s13 to get the pedal working correctly

Hey,

That's exactly how it feels but in my case, it's not the pushrod:

When I manually energize any of the three ABS servo solenoids and the fluid return motor, the pedal goes rock solid and can't be moved at all. This means the master cylinder is perfect and it's not firewall flex. It's ABS servo or the calipers have gone soft

There is air in the system somewhere, I just can't figure out where. That's one of the reasons I'm pulling down the ABS unit and learning about how it works.

I've emailed NipponDenso to see if they'll give me any info on the unit although I dont think they'll reply.

Cheers

Create an account or sign in to comment

You need to be a member in order to leave a comment

Create an account

Sign up for a new account in our community. It's easy!

Register a new account

Sign in

Already have an account? Sign in here.

Sign In Now


  • Similar Content

  • Latest Posts

    • Wow, thanks for your help guys 🙏. I really appreciate it. Thanks @Rezz, if i fail finding any new or used, full or partial set of original Stage carpets i will come back to you for sure 😉 Explenation is right there, i just missed it 🤦‍♂️. Thanks for pointing out. @soviet_merlin in the meantime, I received a reply from nengun, and i quote: "Thanks for your message and interest in Nengun. KG4900 is for the full set of floor mats, while KG4911 is only the Driver's Floor Mat. FR, RH means Front Right Hand Side. All the Full Set options are now discontinued. However, the Driver's Floor Mat options are still available according to the latest information available to us. We do not know what the differences would be, but if you only want the one mat, we can certainly see what we can find out for you". Interesting. It seems they still have some "new old stock" that Duncan mentioned 🤔. I wonder if they can provide any photos......And i also just realized that amayama have G4900 sets. I'm tempted too. 
    • Any update on this one? did you manage to get it fixed?    i'm having the same issue with my r34 and i believe its to do with the smart entry (keyless) control module but cant be sure without forking out to get a replacement  
    • So this being my first contribution to the SAU forums, I'd like to present and show how I had to solve probably one of the most annoying fixes on any car I've owned: replacing a speedometer (or "speedo") sensor on my newly acquired Series 1 Stagea 260RS Autech Version. I'm simply documenting how I went about to fix this issue, and as I understand it is relatively rare to happen to this generation of cars, it is a gigantic PITA so I hope this helps serve as reference to anyone else who may encounter this issue. NOTE: Although I say this is meant for the 260RS, because the gearbox/drivetrain is shared with the R33 GTR with the 5-speed manual, the application should be exactly the same. Background So after driving my new-to-me Stagea for about 1500km, one night while driving home the speedometer and odometer suddenly stopped working. No clunking noise, no indication something was broken, the speedometer would just stop reading anything and the odometer stopped going up. This is a huge worry for me, because my car is relatively low mileage (only 45k km when purchased) so although I plan to own the car for a long time, a mismatched odometer reading would be hugely detrimental to resale should the day come to sell the car. Thankfully this only occurred a mile or two from home so it wasn't extremely significant. Also, the OCD part of me would be extremely irked if the numbers that showed on my dash doesn't match the actual ageing of the car. Diagnosing I had been in communication with the well renown GTR shop in the USA, U.P.garage up near University Point in Washington state. After some back and forth they said it could be one of two things: 1) The speedometer sensor that goes into the transfer case is broken 2) The actual cluster has a component that went kaput. They said this is common in older Nissan gauge clusters and that would indicate a rebuild is necessary. As I tried to figure out if it was problem #1, I resolved problem #2 by sending my cluster over to Relentless Motorsports in Dallas, TX, whom is local to me and does cluster and ECU rebuilds. He is a one man operation who meticulously replaces every chip, resistor, capacitor, and electronic component on the PCB's on a wide variety of classic and modern cars. His specialty is Lexus and Toyota, but he came highly recommended by Erik of U.P.garage since he does the rebuilds for them on GTR clusters.  For those that don't know, on R32 and R33 GTR gearboxes, the speedometer sensor is mounted in the transfer case and is purely an analog mini "generator" (opposite of an alternator essentially). Based on the speed the sensor spins it generates an AC sine wave voltage up to 5V, and sends that via two wires up to the cluster which then interprets it via the speedometer dial. The signal does NOT go to the ECU first, the wiring goes to the cluster first then the ECU after (or so I'm told).  Problems/Roadblocks I first removed the part from the car on the underside of the transfer case (drain your transfer case fluid/ATF first, guess who found out that the hard way?), and noted the transfer case fluid was EXTREMELY black, most likely never changed on my car. When attempting to turn the gears it felt extremely gritty, as if something was binding the shaft from rotating properly. I got absolutely no voltage reading out of the sensor no matter how fast I turned the shaft. After having to reflow the solder on my AFM sensors based on another SAU guide here, I attempted to disassemble the silicone seal on the back of the sensor to see what happened inside the sensor; turns out, it basically disintegrated itself. Wonderful. Not only had the electrical components destroyed themselves, the magnetic portion on what I thought was on the shaft also chipped and was broken. Solution So solution: find a spare part right? Wrong. Nissan has long discontinued the proper sensor part number 32702-21U19, and it is no longer obtainable either through Nissan NSA or Nissan Japan. I was SOL without proper speed or mileage readings unless I figured out a way to replace this sensor. After tons of Googling and searching on SAU, I found that there IS however a sensor that looks almost exactly like the R33/260RS one: a sensor meant for the R33/R34 GTT and GTS-T with the 5 speed manual. The part number was 25010-21U00, and the body, plug, and shaft all looked exactly the same. The gear was different at the end, but knowing the sensor's gear is held on with a circlip, I figured I could just order the part and swap the gears. Cue me ordering a new part from JustJap down in Kirrawee, NSW, then waiting almost 3 weeks for shipping and customs clearing. The part finally arrives and what did I find? The freaking shaft lengths don't match. $&%* I discussed with Erik how to proceed, and figuring that I basically destroyed the sensor trying to get the shaft out of the damaged sensor from my car. we deemed it too dangerous to try and attempt to swap shafts to the correct length. I had to find a local CNC machinist to help me cut and notch down the shaft. After tons of frantic calling on a Friday afternoon, I managed to get hold of someone and he said he'd be able to do it over half a week. I sent him photos and had him take measurements to match not only the correct length and notch fitment, but also a groove to machine out to hold the retentive circlip. And the end result? *chef's kiss* Perfect. Since I didn't have pliers with me when I picked up the items, I tested the old gear and circlip on. Perfect fit. After that it was simply swapping out the plug bracket to the new sensor, mount it on the transfer case, refill with ATF/Nissan Matic Fluid D, then test out function. Thankfully with the rebuilt cluster and the new sensor, both the speedometer and odometer and now working properly!   And there you have it. About 5-6 weeks of headaches wrapped up in a 15 minute photo essay. As I was told it is rare for sensors of this generation to die so dramatically, but you never know what could go wrong with a 25+ year old car. I HOPE that no one else has to go through this problem like I did, so with my take on a solution I hope it helps others who may encounter this issue in the future. For the TL;DR: 1) Sensor breaks. 2) Find a replacement GTT/GTS-T sensor. 3) Find a CNC machinist to have you cut it down to proper specs. 4) Reinstall then pray to the JDM gods.   Hope this guide/story helps anyone else encountering this problem!
    • So this being my first contribution to the SAU forums, I'd like to present and show how I had to solve probably one of the most annoying fixes on any car I've owned: replacing a speedometer (or "speedo") sensor on my newly acquired Series 1 Stagea 260RS Autech Version. I'm simply documenting how I went about to fix this issue, and as I understand it is relatively rare to happen to this generation of cars, it is a gigantic PITA so I hope this helps serve as reference to anyone else who may encounter this issue. NOTE: Although I say this is meant for the 260RS, because the gearbox/drivetrain is shared with the R33 GTR with the 5-speed manual, the application should be exactly the same. Background So after driving my new-to-me Stagea for about 1500km, one night while driving home the speedometer and odometer suddenly stopped working. No clunking noise, no indication something was broken, the speedometer would just stop reading anything and the odometer stopped going up. This is a huge worry for me, because my car is relatively low mileage (only 45k km when purchased) so although I plan to own the car for a long time, a mismatched odometer reading would be hugely detrimental to resale should the day come to sell the car. Thankfully this only occurred a mile or two from home so it wasn't extremely significant. Also, the OCD part of me would be extremely irked if the numbers that showed on my dash doesn't match the actual ageing of the car. Diagnosing I had been in communication with the well renown GTR shop in the USA, U.P.garage up near University Point in Washington state. After some back and forth they said it could be one of two things: 1) The speedometer sensor that goes into the transfer case is broken 2) The actual cluster has a component that went kaput. They said this is common in older Nissan gauge clusters and that would indicate a rebuild is necessary. As I tried to figure out if it was problem #1, I resolved problem #2 by sending my cluster over to Relentless Motorsports in Dallas, TX, whom is local to me and does cluster and ECU rebuilds. He is a one man operation who meticulously replaces every chip, resistor, capacitor, and electronic component on the PCB's on a wide variety of classic and modern cars. His specialty is Lexus and Toyota, but he came highly recommended by Erik of U.P.garage since he does the rebuilds for them on GTR clusters.  For those that don't know, on R32 and R33 GTR gearboxes, the speedometer sensor is mounted in the transfer case and is purely an analog mini "generator" (opposite of an alternator essentially). Based on the speed the sensor spins it generates an AC sine wave voltage up to 5V, and sends that via two wires up to the cluster which then interprets it via the speedometer dial. The signal does NOT go to the ECU first, the wiring goes to the cluster first then the ECU after (or so I'm told).  Problems/Roadblocks I first removed the part from the car on the underside of the transfer case (drain your transfer case fluid/ATF first, guess who found out that the hard way?), and noted the transfer case fluid was EXTREMELY black, most likely never changed on my car. When attempting to turn the gears it felt extremely gritty, as if shttps://imgur.com/6TQCG3xomething was binding the shaft from rotating properly. After having to reflow the solder on my AFM sensors based on another SAU guide here, I attempted to disassemble the silicone seal on the back of the sensor to see what happened inside the sensor; turns out, it basically disintegrated itself. Wonderful. Not only had the electrical components destroyed themselves, the magnetic portion on what I thought was on the shaft also chipped and was broken. Solution So solution: find a spare part right? Wrong. Nissan has long discontinued the proper sensor part number 32702-21U19, and it is no longer obtainable either through Nissan NSA or Nissan Japan. I was SOL without proper speed or mileage readings unless I figured out a way to replace this sensor. After tons of Googling and searching on SAU, I found that there IS however a sensor that looks almost exactly like the R33/260RS one: a sensor meant for the R33/R34 GTT and GTS-T with the 5 speed manual. The part number was 25010-21U00, and the body, plug, and shaft all looked exactly the same. The gear was different at the end, but knowing the sensor's gear is held on with a circlip, I figured I could just order the part and swap the gears. Cue me ordering a new part from JustJap down in Kirrawee, NSW, then waiting almost 3 weeks for shipping and customs clearing. The part finally arrives and what did I find? The freaking shaft lengths don't match. $&%* I discussed with Erik how to proceed, and figuring that I basically destroyed the sensor trying to get the shaft out of the damaged sensor from my car. we deemed it too dangerous to try and attempt to swap shafts to the correct length. I had to find a local CNC machinist to help me cut and notch down the shaft. After tons of frantic calling on a Friday afternoon, I managed to get hold of someone and he said he'd be able to do it over half a week. I sent him photos and had him take measurements to match not only the correct length and notch fitment, but also a groove to machine out to hold the retentive circlip. And the end result? *chef's kiss* Perfect. Since I didn't have pliers with me when I picked up the items, I tested the old gear and circlip on. Perfect fit. After that it was simply swapping out the plug bracket to the new sensor, mount it on the transfer case, refill with ATF/Nissan Matic Fluid D, then test out function. Thankfully with the rebuilt cluster and the new sensor, both the speedometer and odometer and now working properly!   And there you have it. About 5-6 weeks of headaches wrapped up in a 15 minute photo essay. As I was told it is rare for sensors of this generation to die so dramatically, but you never know what could go wrong with a 25+ year old car. I HOPE that no one else has to go through this problem like I did, so with my take on a solution I hope it helps others who may encounter this issue in the future. For the TL;DR: 1) Sensor breaks. 2) Find a replacement GTT/GTS-T sensor. 3) Find a CNC machinist to have you cut it down to proper specs. 4) Reinstall then pray to the JDM gods.   Hope this guide/story helps anyone else encountering this problem!
    • perhaps i should have mentioned, I plugged the unit in before i handed over to the electronics repair shop to see what damaged had been caused and the unit worked (ac controls, rear demister etc) bar the lights behind the lcd. i would assume that the diode was only to control lighting and didnt harm anything else i got the unit back from the electronics repair shop and all is well (to a point). The lights are back on and ac controls are working. im still paranoid as i beleive the repairer just put in any zener diode he could find and admitted asking chatgpt if its compatible   i do however have another issue... sometimes when i turn the ignition on, the climate control unit now goes through a diagnostics procedure which normally occurs when you disconnect and reconnect but this may be due to the below   to top everything off, and feel free to shoot me as im just about to do it myself anyway, while i was checking the newly repaired board by plugging in the climate control unit bare without the housing, i believe i may have shorted it on the headunit surround. Climate control unit still works but now the keyless entry doesnt work along with the dome light not turning on when you open the door. to add to this tricky situation, when you start the car and remove the key ( i have a turbo timer so car remains on) the keyless entry works. the dome light also works when you switch to the on position. fuses were checked and all ok ive deduced that the short somehow has messed with the smart entry control module as that is what controls the keyless entry and dome light on door opening   you guys wouldnt happen to have any experience with that topic lmao... im only laughing as its all i can do right now my self diagnosed adhd always gets me in a situation as i have no patience and want to get everything done in shortest amount of time as possible often ignoring crucial steps such as disconnecting battery when stuffing around with electronics or even placing a simple rag over the metallic headunit surround when placing a live pcb board on top of it   FML
×
×
  • Create New...