Jump to content
SAU Community

Recommended Posts

Hey guys.

I'm hearing a strange sound that i at first thought was spark knock due to a poor tune or even rod knock or worse, but I'm leaning towards a bad lifter due to the high consistency/repeatablity of the sound (and not to mention I've added a ton of fuel and killed timing to make sure). These are the details of the sound:

-Sounds like a rapping similar to spark knock

-Only occurs under medium/high load acceleration AND

-Only occurs above 3k rpm OR around atmospheric on the boost gauge

-Does not occur under very light acceleration up to redline

-Does not occur when revving in neutral

-Does not seem to be heard at engine RPM

-Just started occuring within the last 50 km on a new RB25/30 build

I had to spin the cams around several times when the engine was dry to put the timing belt on. Is it possible there's air in the lifters now? Is there anything I can try before i proceed to pull the damn thing apart? Any other ideas?

Thanks.

Link to comment
https://www.sau.com.au/forums/topic/334855-rb2530-bad-lifter/
Share on other sites

definately has a bearing type knock not a pinging sound and is wierd how it only does it under load,

how rich is it when it ramps up and makes the sound?

my 2 cents is bearing knock but in early stages and needs load to be evident

drain your oil into a clean container and sit it in the sun. you will be able to see if there is any bearing material in it. if so, $60 worth of oil and $80 worth of new bigends is cheaper than a new bottom end....

better to be safe than sory.

To test if its big ends, warm the motor up till its capable of making the sound when free revving, then disconnect 1 coilpack at a time until it doesnt make the sound anymore...

If one of the coilpacks being undone cuts the sound, you know youve got rod knock.

I am all for trying to slap in a new set of bearings too provided the crank isnt marked. Had one chew RIGHT OUT on me before and luckily didnt mark the crank. Motor is still going today :)

Thanks guys I'll try the thing with the oil.

The thing is it doesnt make that sound when free revving with no load. Thats the strange part. And it really doesn't seem like its at engine RPM which is why I'm thinking valvetrain... FML.

Edited by ST240

I understand that... But shouldnt you be able to hear rod knock just free revving the thing?

It definately isnt spark knock. Just logged a run, AFRs in the low 10s, timing was 10* (!) map was anywhere from vac to 4 psi. And it still makes the sound as loud and as consistent as ever. Please tell me that isnt spark knock, although i wish it was.

Edit:

Here it is free revving. No knock sound.

Edited by ST240

Well there was shiny particulates in the oil/filter. Quite a bit and smaller than grains of salt. The oil also had a silvery swirl to it. For comparisons sake i changed the oil in my dd 240sx beater with at least 2k+ km since last change and there wasnt nearly as much. Under half the amount. So for the RB to have double the f**king particulates on 200 km doesnt look good at all.

Is there any point in pursuing further? Are particles typical on a rebuild? I was going to try driving it while disconnecting one injector/coilpack at a time to see if i could isolate it. But i definately do not want to wreck the crank. FML. Serious.

Edited by ST240

Its not hard to remove the sump and take a look. If its a big end bearing you'll find a heap of copper particles sitting in the sump. You'll also be able to push on the rods to see which one has any signs of movement/wear.... as long as the crank is still ok you should be just looking at some new big end bearings...

yeah id remove the sump, take the caps off the rods and check them out, see if its more than 1 failing, if you cant find anything wrong there then remove the main caps 1 at a time and check the bearings there too, refit it before removing the next one.

if you find a failed bearing you need to try determine what caused it, might need to measure the crank to see if its the correct size for the bearing used.

talk to your machinist that machined the engine for rebuild to see what they think caused it.

if nothing is found get some new bearings, what brand did you use? maybe try a different brand.

i wouldnt drive it anymore or the cost of a new gasket for the sump and some big end bearings might turn into and new crank

You guys are gonna hate me. But i have to post this up incase anyone else has the same problem:

The nuts holding the turbo to the exhaust manifold were loose. That sound was obviously the exhaust pulses escaping once there was back pressure on the turbo. I tightened them up and they were loose within 40 km! To solve this, I fabbed up some little "tabs" similar to the ones that come stock on our RBs, that you bend against the nuts to stop them from backing off.

Thanks guys :P .

Edited by ST240

Create an account or sign in to comment

You need to be a member in order to leave a comment

Create an account

Sign up for a new account in our community. It's easy!

Register a new account

Sign in

Already have an account? Sign in here.

Sign In Now


  • Similar Content

  • Latest Posts

    • Hi, is the HKS  Tower Bar still available ? negotiable ? 🤔
    • From there, it is really just test and assemble. Plug the adapter cables from the unit into the back of the screen, then the other side to the car harness. Don't forget all the other plugs too! Run the cables behind the unit and screw it back into place (4 screws) and you should now have 3 cables to run from the top screen to the android unit. I ran them along the DS of the other AV units in the gap between their backets and the console, and used some corrugated tubing on the sharp edges of the bracket so the wires were safe. Plug the centre console and lower screen in temporarily and turn the car to ACC, the AV should fire up as normal. Hold the back button for 3 sec and Android should appear on the top screen. You need to set the input to Aux for audio (more on that later). I put the unit under the AC duct in the centre console, with the wifi antenna on top of the AC duct near the shifter, the bluetooth antenna on the AC duct under the centre console The GPS unit on top of the DS to AC duct; they all seem to work OK there are are out of the way. Neat cable routing is a pain. For the drive recorder I mounted it near the rear view mirror and run the cable in the headlining, across the a pillar and then down the inside of the a pillar seal to the DS lower dash. From there it goes across and to one USB input for the unit. The second USB input is attached to the ECUtec OBD dongle and the 3rd goes to the USB bulkhead connected I added in the centre console. This is how the centre console looks "tidied" up Note I didn't install the provided speaker, didn't use the 2.5mm IPod in line or the piggyback loom for the Ipod or change any DIP switches; they seem to only be required if you need to use the Ipod input rather than the AUX input. That's it, install done, I'll follow up with a separate post on how the unit works, but in summary it retains all factory functions and inputs (so I still use my phone to the car for calls), reverse still works like factory etc.
    • Place the new daughterboard in the case and mount it using the 3 small black rivets provided, and reconnect the 3 factory ribbon cables to the new board Then, use the 3 piggyback cables from the daughterboard into the factory board on top (there are stand offs in the case to keep them apart. and remember to reconnect the antenna and rear cover fan wires. 1 screw to hold the motherboard in place. Before closing the case, make a hole in the sticker covering a hole in the case and run the cable for the android unit into the plug there. The video forgot this step, so did I, so will you probably. Then redo the 4 screws on back, 2 each top and bottom, 3 each side and put the 2 brackets back on.....all ready to go and not that tricky really.      
    • Onto the android unit. You need to remove the top screen because there is a daughterboard to put inside the case. Each side vent pops out from clips; start at the bottom and carefully remove upwards (use a trim remover tool to avoid breaking anything). Then the lower screen and controls come out, 4 screws, a couple of clips (including 3 flimsy ones at the top) and 3 plugs on the rear. Then the upper screen, 4 screws and a bunch of plugs and she is out. From there, remove the mounting brackets (2 screws each), 4 screws on the rear, 2 screws top and bottom and 3 screws holding in the small plates on each side. When you remove the back cover (tight fit), watch out for the power cable for the fan, I removed it so I could put the back aside. The mainboard is held in by 1 screw in the middle, 1 aerial at the top and 3 ribbon cables. If you've ever done any laptop stuff the ribbon cables are OK to work with, just pop up the retainer and they slide out. If you are not familiar just grab a 12 year old from an iphone factory, they will know how it works The case should now look like this:
    • Switching the console was tricky. First there were 6 screws to remove, and also the little adapter loom and its screws had to come out. Also don't forget to remove the 2 screws holding the central locking receiver. Then there are 4 clips on either side....these were very tight in this case and needed careful persuading with a long flat screw driver....some force required but not enough to break them...this was probably the fiddliest part of the whole job. In my case I needed both the wiring loom and the central locking receiver module to swap across to the new one. That was it for the console, so "assembly is the reverse of disassembly"
×
×
  • Create New...