Jump to content
SAU Community

Recommended Posts

  • 2 weeks later...

If you can do this cost effective with your effort and parts you could make some good money.

Nobody who has a leaky ABS wants to buy 2nd hand and new the price is out of this world.

Some even remove ABS all together after getting a leak.

It seems that in my case it was working, it just had some leaks. Tomorrow I should have it all back together if I get the rest of the orings. Not all the orings could be replaced at this stage.

If I can get hold of some 9mm ID x 1.5 EPDM and some 008Q EPDM quad rings that will only leave 1 part which will have to be ever so slightly modified to accept an off the shelf round oring.


Unfortunately trying to fix these units can be like chasing your tail; most of our customers have ended up removing the ABS all together. If you'd like a quote on the components require (new master, lines, brackets...) drop me a line.

Cheers,

Andrew

im just wondering why do you need o rings for? the brake lines do you need to cut or it can be bend to make it fit?

Oo la la! nearly done. Oring shop forgot one oring and 2 others are not fitting well.

I am rebuilding my R32 GTR ABS unit. The orings are so old they are no longer round and no longer sealing properly.

If your talking about the R34 GTR ABS unit then you need to make new lines. Google up some pics of R32 and R34 GTR engine bays and you will be able to spot the differences.

now only to figure out the proper wiring >_<

I am rebuilding my R32 GTR ABS unit. The orings are so old they are no longer round and no longer sealing properly.

If your talking about the R34 GTR ABS unit then you need to make new lines. Google up some pics of R32 and R34 GTR engine bays and you will be able to spot the differences.

The rebuilt ABS unit is back in and (partially) bled. Took it for a spin around the block and will check for leaks tomorrow.

To bleed it properly the ABS unit needs to be operated while it's being bled with pressure. When you start the car it runs the ABS motor, but I'm not sure if its actuating the solenoids.I have a feeling these were pre-bled at the factory then installed.

Next step is to monitor the ABS with an oscilloscope so I can make a bleeding tool. Then I can bench test whole unit :)

  • Like 2

Touche :)

I went through every o-ring that was needed, measured the grooves they sit in and used an o-ring calculator to calculate what o-rings would give the optimum squish then measured all of the new o-rings once they were in their respective grooves to ensure that they were what I calculated. Any o-ring I put in has squeeze within a certain range so that the o-ring will seal and not tear from over compression.

Something I cam across while fiddling with the ABS was that some ABS pumps, probably later ones, had a different design of check valve that aren't prone to leaking. The ones that leak easily are a poor design. I have one which I will pull apart to see if they did anything different internally.

Edited by dontfeelcold

have you tested if the abs kick in and there is no air in the lines?

Yes, in a safe place, but I already bled the entire ABS unit, so there is no air whatsoever in it.

ABS is not leaking and I managed to fully bleed it. Had to power up the abs motor and the solenoids and then you can bleed it properly.

Create an account or sign in to comment

You need to be a member in order to leave a comment

Create an account

Sign up for a new account in our community. It's easy!

Register a new account

Sign in

Already have an account? Sign in here.

Sign In Now



  • Similar Content

  • Latest Posts

    • Good luck on the weekend mate
    • Must have been an absolute nightmare to drive when the power steer was out, the rack ratio/wheel size/caster is all set up for power assistance
    • Welcome to SAU, what are you looking at buying?
    • I checked the injectors again (1 and 2, since they’re easiest to access) to make sure they weren’t clogged. Even though the entire fuel system had been cleaned, I wanted to be certain. Everything looked clean, so I reinstalled and connected everything. When I started the car to confirm everything was okay, it immediately revved up high, so I shut it off straight away. I checked to see if I’d missed a vacuum hose or something, but everything was connected. On the second attempt, the car ran without the high idle, but I noticed a distinct “compressed air” sound coming from the engine bay. Tracing the sound, I pushed injector #6 forward slightly and the noise stopped — it turned out it wasn’t seated properly, despite the fuel rail being bolted down. While holding it in place, the car idled steadily without stalling and ran for over 5 minutes. At this point, I pulled all six injectors out just in case I hadn’t seated them correctly or dirt had gotten onto the O-rings. Unfortunately, I discovered that I had damaged 3 out of 6 injectors (the OEM 270cc ones) during installation. So yes, this was my fault. Since only the pintle caps were damaged, I’ve ordered a Fuel Injector Service Kit from NZEFI to refurbish them. In the meantime, I reinstalled my new injectors – the car now idles fine for over 15 minutes without stalling. I have not attempted to drive it so far. It’s not perfect yet, as it hesitates when the throttle is pressed, but it’s a big improvement. Unplugging the IACV with the new injectors idles at around 800rpm, even with the IACV screw tightened fully. But this is probably due to tune.
    • I wanted to try and preserve the front bumper as long as possible, they're not cheap and are made to order in Japan. Taking inspiration from my previous K11 Micra build where I made an undertray for the Impul bumper, I did the same for this BN Sports bumper but a little slimmed down.  This time round I only made a 'skid plate' (if that's the correct wording/term) for just the bumper surface area, the Micra version covered the gap like an undertray. Starting off with a sheet of mild steel approx. 0.9mm thick 4ft x 2ft in size. I traced around the bumper, cut it out and cleaned the edges. Luckily I was able to get two halves from one piece of metal In the video I installed it as is, but I've since then I've removed it to spray and add a rubber edging trim. The rubber trim is suitable for 1-2mm and it's a really nice tight fit. The bolts had to be loosened due to the plates being too tight against the bumper, the trim wouldn't push on I used some stainless M6 flat headed bolts for a flusher finish (rather than hex heads poking down), I believe this style fastener is used for furniture too incase you struggle to source some. The corner's are a little wider, but this may be an advantage incase I get close to bumping it  The front grill got some attention, finally getting round to repairing it. Upon removal one fixing pulled itself out of the plastic frame, one side is M8 that fixes inside of the frame, where as the other side is M5. Not knowing I could get replacements, I cut down an M8 bolt, threaded it inside the frame along with a decent amount of JB Weld.  The mesh was replaced to match the bumper. One hole on the bonnet/hood had to be drilled out to 8mm to accommodate the new stud, once the glue had set it could be refitted. I think the reason the grill was double meshed was to hide the horn/bonnet latch (which makes sense) but I much prefer it matching the bumper Bumper refitted and it's looking much better IMO The Youtube video can be seen here: https://www.youtube.com/watch?v=bVZP35io9MA
×
×
  • Create New...