Jump to content
SAU Community

Recommended Posts

Thought that Mike and I were coming down to your place tomorrow night and then drinking scotch and then going to Yattla for the cruise?
Ha! That would of been good.

Sadly I have already plans with family tomorrow

  • 1 month later...
  • 3 weeks later...

Well run in has been done (so I've been told)

As much as I want to go and get it tuned again I'm saving for suspension parts FTM as a car is only as good as it handles

I will put some minor updates soon ;)

  • Like 1
  • 1 month later...

Alright it has been quite some time since I have updated this build thread

I guess I have been enjoying it, hence why bugger all updates

but this aint true as I have in fact done a bucket load

First up........

I decided to take off the windshield water grill and see what has been lurking under there

so after taking off the mandatory wiper and bonnet bolts and removing them I got this

IMG_0660_zps769ef280.jpg

it wasn't pretty

IMG_0661_zps2697894f.jpg

IMG_0664_zps7df0caf5.jpg

IMG_0666_zps7b98eb43.jpg

so lets get all this cleaned up ;)

  • Like 1

Got my trusty garage vacuum cleaner and started sucking up all the dirt and silt lying within the under there grill

IMG_0667_zpsc2878bf5.jpg

IMG_0668_zpsf79fe553.jpg

IMG_0726_zps10cc773a.jpg

even took these little suckers out for some restoration lol

IMG_0729_zps3370aa74.jpg

after a quick wipe with some warm water and soap and it already started to look a better

but me not being satisfied I wanted to go one step further

IMG_0736_zpsf2f29b4d.jpg

IMG_0844_zps0be6f9b2.jpg

I removed the bolts to the wiper motors (except for the middle one so just tapped it up) and taped up everything else with plastic sheeting

next step was to apply a coat of clear where the windshield grill usually sits

results

IMG_0734_zpsc779bd95.jpg

IMG_0738_zpsd9e834a4.jpg

IMG_0898_zpsc6bd5459.jpg

IMG_0900_zps6787302c.jpg

  • Like 1

IMG_0731_zps61375da7.jpg

managed to clean them plugs rather well and went straight back in their home

IMG_0901_zps1b38e4eb.jpg

whilst I was at it I thought I would pay some attention to the actual grill which looked rather in poor shape

IMG_0886_zpsfc54ad01.jpg

IMG_0888_zps0864a96f.jpg

IMG_0889_zpsc12f2ba0.jpg

After a quick wash with some sugar soap and warm water it looked like this

IMG_0894_zpsac8d2491.jpg

I glued the lip back with some Loctite Precision Super Glue Gel (highly recommend it for delicate applications)

IMG_0891_zps84a3419f.jpg

IMG_0893_zpsd8dfedf0.jpg

Then I applied some Meguiars Plastx to get it to look like this

IMG_0892_zpsdf783d1f.jpg

back in the engine bay - I had some broken studs to take off and rethread

IMG_0869_zps165aaf0a.jpg

after much swearing and broken drill bits I got the bastard out lol

IMG_0868_zps75476492.jpg

IMG_0866_zpsdb94de90.jpg

me and drills - thank Christ I am not a dentist

Time for some rethreading

IMG_0865_zps44174980.jpg

this is actually rather delicate to do and you must turn slowly then reverse slowly to get the right threading technique but I managed very well thanks to Youtube lol

IMG_0870_zps15db47a8.jpg

new stud in place

next up the rear wing

IMG_4882_zps0bf118a2.jpg

thought I would take the rear wing off to detail it...........

lets just say that when I saw this

IMG_4883_zps81c11175.jpg

IMG_4887_zps2134c4bc.jpg

I knew that there was going to need more than just wax and polish

IMG_4885_zpse2166cd5.jpg

IMG_4886_zpsf47abe44.jpg

the rear wing stay brackets were fooked to say the least

IMG_4889_zpsb9057cdf.jpg

IMG_4893_zpscb503641.jpg

IMG_4895_zpsfd80df57.jpg

totally corroded and unusable

the car without the rear wing

IMG_4897_zps93fb00aa.jpg

we will get all this cleaned up too

IMG_4910_zps9993d796.jpg

IMG_4911_zpsdab5806b.jpg

IMG_4914_zps21ea56b5.jpg

ta dah!

a bit of detailing done (cut and polish)

IMG_4918_zps10f4a572.jpg

IMG_4915_zpsa261c6d2.jpg

it sure does have a different appearance without the rear wing

  • Like 1

Create an account or sign in to comment

You need to be a member in order to leave a comment

Create an account

Sign up for a new account in our community. It's easy!

Register a new account

Sign in

Already have an account? Sign in here.

Sign In Now



  • Similar Content

  • Latest Posts

    • Next on the to-do list was an oil and filter change. Nothing exciting to add here except the oil filter is in a really stupid place (facing the engine mount/subframe/steering rack). GReddy do a relocation kit which puts it towards the gearbox, I would have preferred towards the front but there's obviously a lot more stuff there. Something I'll have to look at for the next service perhaps. First time using Valvoline oil, although I can't see it being any different to most other brands Nice... The oil filter location... At least the subframe wont rust any time soon I picked up a genuine fuel filter, this is part of the fuel pump assembly inside the fuel tank. Access can be found underneath the rear seat, you'll see this triangular cover Remove the 3x plastic 10mm nuts and lift the cover up, pushing the rubber grommet through The yellow fuel line clips push out in opposite directions, remove these completely. The two moulded fuel lines can now pull upwards to disconnect, along with the wire electrical plug. There's 8x 8mm bolts that secure the black retaining ring. The fuel pump assembly is now ready to lift out. Be mindful of the fuel hose on the side, the hose clamp on mine was catching the hose preventing it from lifting up The fuel pump/filter has an upper and lower section held on by 4 pressure clips. These did take a little bit of force, it sounded like the plastic tabs were going to break but they didn't (don't worry!) The lower section helps mount the fuel pump, there's a circular rubber gasket/grommet/seal thing on the bottom where the sock is. Undo the hose clip on the short fuel hose on the side to disconnect it from the 3 way distribution pipe to be able to lift the upper half away. Don't forget to unplug the fuel pump too! There's a few rubber O rings that will need transferring to the new filter housing, I show these in the video at the bottom of this write up. Reassembly is the reverse Here's a photo of the new filter installed, you'll be able to see where the tabs are more clearing against the yellow OEM plastic Once the assembly is re-installed, I turned the engine over a few times to help build up fuel pressure. I did panic when the car stopped turning over but I could hear the fuel pump making a noise. It eventually started and has been fine since. Found my 'lucky' coin underneath the rear seat too The Youtube video can be seen here: https://www.youtube.com/watch?v=uLJ65pmQt44&t=6s
    • It was picked up on the MOT/Inspection that the offside front wheel bearing had excessive play along with the ball joint. It made sense to do both sides so I sourced a pair of spare IS200 hubs to do the swap. Unfortunately I don't have any photos of the strip down but here's a quick run down. On the back of the hub is a large circular dust cover, using a flat head screw driver and a mallet I prised it off. Underneath will reveal a 32mm hub nut (impact gun recommended). With the hub nut removed the ABS ring can be removed (I ended up using a magnetic pick up tool to help). Next up is to remove the stub axle, this was a little trickier due to limited tools. I tried a 3 leg puller but the gap between the hub and stub axle wasn't enough for the legs to get in and under. Next option was a lump hammer and someone pulling the stub axle at the same time. After a few heavy hits it released. The lower bearing race had seized itself onto the stub axle, which was fine because I was replacing them anyway. With the upper bearing race removed and the grease cleaned off they looked like this The left one looked pristine inside but gave us the most trouble. The right one had some surface rust but came apart in a single hit, figure that out?! I got a local garage to press the new wheel bearings in, reassemble was the opposite and didn't take long at all. Removing the hub itself was simple. Starting with removing the brake caliper, 2x 14mm bolts for the caliper slider and 2x 19mm? for the carrier > hub bolts. I used a cable tie to secure the caliper to the upper arm so it was out of the way, there's a 10mm bolt securing the ABS sensor on. With the brake disc removed from the hub next are the three castle nuts for the upper and lower ball joints and track rod end. Two of these had their own R clip and one split pin. A few hits with the hammer and they're released (I left the castle nuts on by a couple of turns), the track rod ends gave me the most grief and I may have nipped the boots (oops). Fitting is the reversal and is very quick and easy to do. The lower ball joints are held onto the hub by 2x 17mm bolts. The castle nut did increase in socket size to 22mm from memory (this may vary from supplier) The two front tyres weren't in great condition, so I had those replaced with some budget tyres for the time being. I'll be replacing the wheels and tyres in the future, this was to get me on the road without the worry of the police hassling me.
    • Yep, the closest base tune available was for the GTT, I went with that and made all the logical changes I could find to convert it to Naturally Aspirated. It will rev fine in Neutral to redline but it will be cutting nearly 50% fuel the whole way.  If I let it tune the fuel map to start with that much less fuel it wont run right and has a hard time applying corrections.  These 50% cuts are with a fuel map already about half of what the GTT tune had.  I was having a whole lot of bogging when applying any throttle but seem to have fixed that for no load situations with very aggressive transient throttle settings. I made the corrections to my injectors with data I found for them online, FBCJC100 flowing 306cc.  I'll have to look to see if I can find the Cam section. I have the Bosch 4.9 from Haltech. My manifold pressure when watching it live is always in -5.9 psi/inHg
    • Hi My Tokico BM50 Brake master cylinder has a leak from the hole between the two outlets (M10x1) for brake pipes, I have attached a photo. Can anyone tell me what that hole is and what has failed to allow brake fluid to escape from it, I have looked on line and asked questions on UK forums but can not find the answer, if anyone can enlighten me I would be most grateful.
    • It will be a software setting. I don't believe many on here ever used AEM. And they're now a discontinued product,that's really hard to find any easy answers on. If it were Link or Haltech, someone would be able to just send you a ECU file though.
×
×
  • Create New...