Jump to content
SAU Community

Recommended Posts

We are in process of getting bakelite inlet gaskets for RB20/25 and 26. This material prevents heat transfer from heads to inlet plenum. For RB26 added bonus of replacing the factory paper throttle body and inlet plenum gasket which are notorious for blowing out and getting air leaks. Up to now only option is after market gasket such as expensive Tomei metal ones which work fine but still transfer heat.

We have had the gaskets scanned and ready to make and will have in next week or so. We have already had made for VG30 300ZX. This is not a new invention as they are available on E Bay a while back for many engines in USA but not Skylines so we decided to do it. They will not be much more than factory ones depending on volume but way cheaper and better than Japanese aftermarket ones. 2 birds one rock deal.

Wondering what the interest would be. Remember average of 7 degrees increase or reduction in temp means 1% plus or minus in power.

PS If you have stock inlet gaskets and boost your GTR which is most then only a matter of time. Also never put strong solvent cleaners down throttle bodies as it can disolve the factory grey rubber type throttle body sealant and cause an air leak and idle will remain way too high.

Pic is of my VG30 DETT.

Link to comment
https://www.sau.com.au/forums/topic/68034-bakelite-inlet-gaskets/
Share on other sites

There's an old (over 5 years) Autospeed article about these:

http://www.autospeed.com/cms/A_0401/article.html

And i started a rather short-lived thread about it:

http://www.skylinesaustralia.com/forums/sh...ead.php?t=56688

I'd be certainly interested to see how these perform when tested independantly.

bakelite hey? How does this stuff go in compression - is it going to deform, crack or deteorate over time being squashed between the head and the inlet manifold.

What sort of temperatures can it cope with.

What are the thermal properties - ie heat transfer rate through the material, (W/Deg_C/m)

It has been used for this purposeas wel as many other applications for years. I am not aware of any probs only benefits. A hole lot better than aper ones the GTR's have from factory.

The only question I have is that the inlet manifolds already have coolant water passages in them so the the heat will come from the coolant rather than the head casting . I'm always in favour of good gaskets that seal well , but the heat insulation would probably work better on non water heated manifolds such as the RB26's plenum section . My theory only , I'd reckon at high flow rates (revs/boost) the inlet air dosen't spend enough time in the manifold section to absorb much heat . I also think its desirable to have some heat in the inlet charge at idle and low engine speeds for fuel vaporisation meaning clean emissions and good fuel consumption .

Cheers A .

Yes and we found this on VG30 also. We also remove the throttle body heating on zeds for same reason. You could drill and tap and run external these water galleries although have not had a close look at it on RB26. It is accumulative if getting heated by coolant and combustion heat, removing or limiting one will help. Correct air would not spend much time passing through although at low speed road driving probably make more of a difference. Main point being it would help and better than factory gaskets which is a prob and way cheaper than Tomei or other gaskets.

There is no benefit in heating the inlet charge unless you live in VERY cold climate and much more benefit in cooling or rather avoiding heating.

They will prob be around $50 each at most. Prob is I have to get at least a hundred made and adds up to thousands and will take a long time to sell a hundred or more to need to get some funds back.

being in the electricity industry I see allot of Bakelite products and when it is fairly thin, as it would need to be with a gasket, it would be fairly fragile and as with a paper gasket with some age it becomes brittle. wouldn't the ambient temperature of the engine bay sort of rule out trying to stop heat transfer by using the gasket to stop metal to metal contact. in a GTR the first intake manifold has a gallery fed from the the head in it which feeds both cooloant supplies for the turbo's, one around the front of the motor and one around the back. The throttle bodies and intake plenum don't have any water galleries in them. but your not wrong about the gasket blowing out between the head and the first intake manifold, my 33 did it straight away and i just spent a day replacing the one on my wifes 32.

Will advise when available and should be in next few weeks. Re temps the thing that makes the heat is the engine and turbo and this is what we are helping shield against. The heads are hotter than under bonnet temps.

  • 2 years later...

Create an account or sign in to comment

You need to be a member in order to leave a comment

Create an account

Sign up for a new account in our community. It's easy!

Register a new account

Sign in

Already have an account? Sign in here.

Sign In Now


  • Similar Content

  • Latest Posts

    • As discussed in the previous post, the bushes in the 110 needed replacing. I took this opportunity to replace the castor bushes, the front lower control arm, lower the car and get the alignment dialled in with new tyres. I took it down to Alignment Motorsports on the GC to get this work done and also get more out of the Shockworks as I felt like I wasn't getting the full use out of them.  To cut a very long story short, it ended up being the case the passenger side castor arm wouldn't accept the brand new bush as the sleeve had worn badly enough to the point you could push the new bush in by hand and completely through. Trying a pair of TRD bushes didn't fix the issue either (I had originally gone with Hardrace bushes). We needed to urgently source another castor arm, and thankfully this was sourced and the guys at the shop worked on my car until 7pm on a Saturday to get everything done. The car rides a lot nicer now with the suspension dialled in properly. Lowered the car a little as well to suit the lower profile front tyres, and just bring the car down generally. Eternally thankful for the guys down at the shop to get the car sorted, we both pulled big favours from our contacts to get it done on the Saturday.  Also plugged in the new Stedi foglights into the S15, and even from a quick test in the garage I'm keen to see how they look out on the road. I had some concerns about the length of the LED body and whether it'd fit in the foglight housing but it's fine.  I've got a small window coming up next month where I'll likely get a little paint work done on the 110 to remove the rear wing, add a boot wing and roof wing, get the side skirt fixed up and colour match the little panel on the tail lights so that I can install some badges that I've kept in storage. I'm also tempted to put in a new pair of headlights on the 110.  Until then, here's some more pictures from Easter this year. 
    • I would put a fuel pressure gauge between the filter and the fuel rail, see if it's maintaining good fuel pressure at idle going up to the point when it stalls. Do you see any strange behavior in commanded fuel leading up to the point when it stalls? You might have to start going through the service manual and doing a long list of sensor tests if it's not the fuel system for whatever reason.
    • Hi,  Just joined the forum so I could share my "fix" of this problem. Might be of use to someone. Had the same hunting at idle issue on my V36 with VQ35HR engine after swapping the engine because the original one got overheated.  While changing the engine I made the mistake of cleaning the throttle bodies and tried all the tricks i could find to do a throttle relearn with no luck. Gave in and took it to a shop and they couldn't sort it. Then took it to my local Nissan dealership and they couldn't get it to idle properly. They said I'd need to replace the throttle bodies and the ecu probably costing more than the car is worth. So I had the idea of replacing the carbon I cleaned out with a thin layer of super glue and it's back to normal idle now. Bit rough but saved the car from the wreckers 🤣
    • After my last update, I went ahead with cleaning and restoring the entire fuel system. This included removing the tank and cleaning it with the Beyond Balistics solution, power washing it multiple times, drying it thoroughly, rinsing with IPA, drying again with heat gun and compressed air. Also, cleaning out the lines, fuel rail, and replacing the fuel pump with an OEM-style one. During the cleaning process, I replaced several hoses - including the breather hose on the fuel tank, which turned out to be the cause of the earlier fuel leak. This is what the old fuel filter looked like: Fuel tank before cleaning: Dirty Fuel Tank.mp4   Fuel tank after cleaning (some staining remains): Clean Fuel Tank.mp4 Both the OEM 270cc and new DeatschWerks 550cc injectors were cleaned professionally by a shop. Before reassembling everything, I tested the fuel flow by running the pump output into a container at the fuel filter location - flow looked good. I then fitted the new fuel filter and reassembled the rest of the system. Fuel Flow Test.mp4 Test 1 - 550cc injectors Ran the new fuel pump with its supplied diagonal strainer (different from OEM’s flat strainer) and my 550cc injectors using the same resized-injector map I had successfully used before. At first, it idled roughly and stalled when I applied throttle. Checked the spark plugs and found that they were fouled with carbon (likely from the earlier overly rich running when the injectors were clogged). After cleaning the plugs, the car started fine. However, it would only idle for 30–60 seconds before stalling, and while driving it would feel like a “fuel cut” after a few seconds - though it wouldn’t fully stall. Test 2 – Strainer swap Suspecting the diagonal strainer might not be reaching the tank bottom, I swapped it for the original flat strainer and filled the tank with ~45L of fuel. The issue persisted exactly the same. Test 3 – OEM injectors To eliminate tuning variables, I reinstalled the OEM 270cc injectors and reverted to the original map. Cleaned the spark plugs again just in-case. The stalling and “fuel cut” still remained.   At this stage, I suspect an intermittent power or connection fault at the fuel pump hanger, caused during the cleaning process. This has led me to look into getting Frenchy’s fuel hanger and replacing the unit entirely. TL;DR: Cleaned and restored the fuel system (tank, lines, rail, pump). Tested 550cc injectors with the same resized-injector map as before, but the car stalls at idle and experiences what feels like “fuel cut” after a few seconds of driving. Swapped back to OEM injectors with original map to rule out tuning, but the issue persists. Now suspecting an intermittent power or connection fault at the fuel pump hanger, possibly cause by the cleaning process.  
×
×
  • Create New...